2007 Ford Expedition fuel system problems

Filed Feb 22, 2023 · Fuel system · 204,000 miles · GA

The contact owns a 2007 Ford Expedition. The contact stated while driving approximately 35 MPH, the vehicle stalled in the middle of the roadway. The contact was able to place the vehicle in park(P) and the contact was unable to restart the vehicle. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the fuel pump needed to be replaced. The vehicle had been repaired; however, the fuel pump failed a few years later. The manufacturer had been informed of the failure. The failure mileage was approximately 204,000.

Filed May 12, 2022 · Fuel system · SC

My expodition has a bad gas smell and skips a little please help me

Filed Feb 2, 2018 · Fuel system · ND · crash · 1 injury

Every time I fuel up the gas fumes fill the inside of the vehicle and the smell is so strong that we have to turn off our cell phones in fear of ignition

Filed Jan 29, 2018 · Engine, Fuel system · 123,800 miles · MD

My truck was purchased new and I have recently had more fuel gas waste quickly in the past year. I recently had the fuel line changed in june 2017 because a spark plug burnt out and caused it to have a leak that was dangerously close to the gas tank. I have 123k miles on it and the check engine line comes on every time after half a gas tank is done. I had the truck driving and it shuts off on its own. Sometimes it will have a strong shaking of the motor or no warning at all while driving on the road. I'm very concerned because we thought it was the camshaft which is what the error code pops up and the spark plugs and coils have been replaced. Every thing else has been maintained but I'm still have the engine and fuel problem. The gas goes so fast and this is a v8 where I usually drive a 6 mile to work now says it has been a 40 mile drive. Don't know what else to do and may take it back to trade for another vehicle brand. I had to park the truck after it shut off on me again on a side street before getting on the highway.

Filed Jun 3, 2017 · Fuel system · 150,988 miles · AZ

The vehicle would not start. After diagnosis we found the fuel pump which in located inside the fuel tank had burned and melted at the wire connectors. Had the fuel been lower and the wires exposed the fumes would have exploded. This is a very dangerous and a recall should be issued before someone dies from a fire. The fuel tank is also located directly under the left side seats.

Filed Feb 21, 2017 · Fuel system · 184,000 miles · SC

Tl* the contact owns a 2007 ford expedition. The contact stated that while driving at 35 MPH the vehicle stalled. The contact stated that an unknown warning light illuminated after the failure was experienced. The vehicle was towed to an independent mechanic where it was informed that there was a fuel leak and that the fuel system failed. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was 184,000. The VIN was not available. Updated 05/10/17*lj

Filed Oct 4, 2016 · Fuel system · 170,000 miles · TX

I left to go grocery shopping around noon this march. About 15 min. Into my drive going up a hill on a highway and right after passing a car that was doing about 50 in a 70 MPH zone, my car just died while topping the hill. I had no power steering, and no breaks. Thankfully I have had car with out power steering and knew it was going to be tough to get it on the shoulder before being hit by the semi that was behind me. It would not start or do anything after that so I popped the hood to check my fuses. And found out it was the fuel pump fuse. I had over a quarter tank of gas left and no warning as to any problem with my car. I check all my fluids on the regular and have oils changed when needed. When the fuel tank was pulled all the wires on the pump were melted. Lucky it dudnt catch fire, and the part to replace this is ridiculously expensive.

Filed Jan 22, 2016 · Fuel system · 170,000 miles · GA

Tl* the contact owns a 2007 ford expedition. While attempting to start the vehicle, it failed to start. The contact stated that there was an abnormal fuel odor coming from the vehicle. The contact was able to manually move the vehicle forward and noticed that there was a fuel leak under the vehicle. The vehicle was not included in the federal safety agency campaign number: 08v0570000 (fuel system, gasoline). The manufacturer was not notified of the failure. The approximate failure mileage was 170,000.

Filed Dec 16, 2015 · Fuel system · 90,000 miles · NJ · fire

Tl* the contact owns a 2007 ford expedition. The contact stated that while parked, the vehicle was not able to start. The failure occurred constantly. An independent mechanic diagnosed the vehicle and discovered that wires connected to fuel pump had melted and needed to be replaced. The manufacturer was not notified of the failure. The approximate failure mileage was 90,000.

Filed Nov 24, 2015 · Electrical, Fuel system · 108,689 miles · GA

Tl* the contact owns a 2007 ford expedition. The contact stated that while the A/C activated, there was a fuel odor entering the vehicle. In addition, the contact noticed that there was fuel leaking and both rear doors did not open. The contact stated in order to open the doors, the driver unlock button would had to be depressed. The vehicle was taken to an independent mechanic where the failure was undetermined. The vehicle was not repaired. The VIN was not included in the federal safety agency campaign number: 08v057000 (fuel system, gasoline). The manufacturer was not notified of the failure. The approximate failure mileage was 108,689.