2018 Ford Expedition suspension problems

Filed Oct 16, 2026 · Brakes, Suspension · SC

MacPherson Strut assemblies leaking large amounts of hydraulic fluid which spills into/on the brakes. Decreased fluid in the MacPherson Strut results in excessive rebound, decreased braking, at times no braking when fluid has spewed onto brakes, followed by a sudden grab of the brakes that feels as though the anti-lock system might engage. This defect poses a serious risk of accident, injury, or even fatality of loss of control occurs at the wrong time. Ford has been made aware of the problem, and is side-stepping the repair under the guise of calling the component a "shock absorber" (it's quite clearly mounted inside a spring with a STRUT MOUNT at the top). Their parts catalog calls it a STRUT ASSEMBLY section, but they skirt around claim denial on the grounds that it's a "shock absorber" (simply because they don't offer the complete STRUT assembly). Ford needs to pull these defective and unsafe components (note that ALL FOUR have breached seals on my vehicle) and address the serious potential for unsafe handling or accident when fluid is suddenly dumped into/on brakes. I'm now faced with a vehicle I cannot operate because it is unsafe, and even though it's covered by an extended Premium Protection Plan, will not be repaired by Ford.

Filed Sep 22, 2026 · Steering, Suspension · KS

This is a widespread problem across the Ford expedition. I've read forum after forum, facebook group after facebook group and have seen that many expeditions are affected by this. The front end of the Expedition; primarily the steering and suspension components, cause a strong vibration when approaching 70-75 miles per hour. I have replaced the tires on my Expedition and had them mounted and balanced by Ford, only for the problem to still exist. I mentioned this to Ford directly and they told me that there is no way for them to replicate the problem because they won't take the vehicle over the local speed limit. However where I drive all across the country for work, the speed limit is approximately 70 -75 miles per hour. This is a severe issue as Vibrations could easily cause an accident.

Filed Jan 5, 2026 · Suspension · AL

While driving on to a rough area such as a bridge crossing the vehicle exhibited excessive bouncing and caused the direction of travel toward the next lane. Repairs to the front struts were made at the dealership where the vehicle was originally purchased. The repair part was described as JL1Z 18124 E Shock Absorber Asy. The service advisor said struts are described this way due to the way it is listed in the parts catalog. Since this repair the vehicle has increasingly repeated the same bouncing and driveability to the extent that another service call is required.

Filed Jun 12, 2025 · Engine, Suspension · MN

With only 53500 miles the gears stopped working. The gear shift pulls and hesitates when changing gears. The engine pulls when excelerating even at low speeds while struggling to shift. The Cam is also causing issues with loud start up sounds.

Filed Oct 4, 2024 · Suspension · MD

Front struts faulty. Drivers side blew and all the fluid leaked out and the passenger side was leaking. Unknown safety issue but the vehicle only has 42,000 miles and has never been off road. Still has original tires, shouldn’t struts last longer than tires? The problem was confirmed by my local Ford dealer. I paid $1467.72 to have them replaced which is ridiculous for a vehicle with such low mileage. In my research I have found that this may be a widespread problem but there has been no recall. No warnings.

Filed Aug 2, 2024 · Suspension · 70,000 miles · MI

The contact owns a 2018 Ford Expedition. The contact stated that on several occasions when the vehicle was started, there was a rattling sound coming from the engine compartment. The contact stated while driving on several occasions at various speeds, the body of the vehicle had shifted. The vehicle was taken to a dealer where it was diagnosed and determined that the passenger’s side front axle seal needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

Filed Mar 7, 2023 · Suspension · CO

All 4 struts failed at approximately 46,000 miles. It is available for inspection upon request but for safety reasons I will have it fixed as soon as possible. It had been riding rough for a while and started sending my children flying around the backseat particularly the third row and grew much louder and jostling with every bump in the road. Last oil change at 43,000 miles it was recommended to replace rear struts due to leaking but I was waiting for a second opinion. When I took it in for an alignment after new tires were put on I made no mention of this to see what they said and sure enough all 4 struts were leaking and needed replaced as soon as possible at 46,000 miles. No warning lamps or messages. Problems first appeared around July 2022 and progressively got worse.

Filed Feb 17, 2023 · Suspension · 17,000 miles · CA

The contact owns a 2018 Ford Expedition. The contact stated while driving 65 MPH, the vehicle started bouncing without warning. The contact stated that after several seconds, the vehicle stopped bouncing. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the front shocks were leaking, and that both front shocks needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the contact was referred to the federal safety agency hotline to file a complaint. The failure mileage was 17,000.

Filed Oct 11, 2022 · Suspension · TX

At approximately 30,000 the vehicle's suspension failed, leading to a very rough ride like a boat hitting waves, and at speed affects the ability to control the vehicle. The Ford dealer advised that all shocks needed replacing. The problem developed gradually over about six months. These or the original shocks on the vehicle, and their early failure is a defect and safety concern.

Filed Jun 30, 2022 · Suspension · WA

All four shocks leaking at 29000 miles. Replaced under warranty. Now at 35000 rear shocks starting to leak.