Vehicle has a rattle upon starting. Also the vehicle is shifting harshly and slipping. Sometimes the vehicle will occasionally stop accelerating in the middle of the road. The RPMs will rise but the vehicle stops having power. After a minute it finally jerks and the vehicle will go again. I have had the vehicle examined by a technician and have been told that it is the cam phasers, CDF drum/transmission, and torque converter.
2019 Ford Expedition engine complaints
Page 3 of 6: complaints 41 to 70 of 135, newest first, as owners wrote them.
The contact owns a 2019 Ford Expedition. The contact stated that there was a ticking sound coming while starting the vehicle. The contact stated that the ticking sound was consistent. The vehicle was taken to the dealer where it was diagnosed; however, the vehicle was not repaired. The contact related the failure to Customer Satisfaction Number: CSP - 21N03 - Supplement 4. The manufacturer was contacted and made aware of the issue and a case was opened. The failure mileage was 80,000.
Catalytic converter has gone bad error code Po430
The contact owns a 2019 Ford Expedition. The contact stated while the vehicle was parked, the contact noticed that coolant was leaking underneath the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the heater hoses had failed and needed to be replaced. The vehicle was repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 117,000.
I was on the freeway going between 65-70mph when I felt a hard shift and lost all acceleration. The truck started to slow down and the wrench light came on. I was able to coast to the shoulder and turn my hazards on while the wrench light and warnings were going. I parked the truck and waited for my husband to help. The truck sat for approximately 20 minutes when it was turned back on. There were no lights on the dash and the wrench warning went away [XXX] husband was able to drive it home. I had my three kids in the truck and it was a terrifying experience. I took it to get scanned and it gave us a throttle body code. My vehicle supposedly isn't affected but this experience tells me that myself and my kids are in more danger than what is being claimed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My expedition was reprogrammed when I bought it due to the Cam phaser rattle. This did not help. I was told this was normal and would not effect the engine. I had taken it in a second time to be reprogrammed an given the same information. My Ford service says fifth cylinder misfire. The car shakes and idles hard. The spark plug and parts were replaced as suggested with no change. Took it to the shop and was told I now need a new engine due to an internal failure of the engine. I called Ford and they said there is no recall on this year. The Cam phaser reprogram was a customer satisfaction and not a recall. I asked if they would offer assistance since now I need a new engine. They will not. I called about ordering a new engine. Iwas was told there is over 250 people waiting for an engine as they are backordered by the Ford service department. It will be $10,000 plus 1200 for the core plus install. There are no availble engine due to the backorder and you must pay for the parts to get on the waitlist. The earliest they will release them is in November. How are there this many people waiting for an engine and no recall? This is a safety issue as all cylinders are not firing and there is not enough compression to make the vehicle run correctly. The check engine light appears solid upon starting the car and then will start blinking. The vehicle was inspected by an independent shop as I took my expedition to Ford for 60,000 service and they put the wrong fluid in my differential and then I had to have this rebuilt by them. After telling them something was wrong multiple times after they gave it back. So I do not trust to take it back to them. The independent shop confirmed this is a problem with these engines. I took it in due to the check engine light and hard idle that was getting worse.
On three separate occasions, my vehicle lost the ability to accelerate. The first time I was attempting to pass slow moving farm equipment when my vehicle lost power, had a loud vibrating/rattling noise and multiple dashboard warnings flashed. Luckily, I was able to merge back into my lane and pull off the side of the road. I took the vehicle in for service and was told I needed new phasers. Once I got my vehicle back, I was still experiencing issues. Fortunately, the next two times my vehicle lost power I was driving at low speeds. I did have my kids with me on one occasion and it scared them quite a bit. I am not sure what the loud noise is but they stopped riding with me after that. Thank goodness I was not driving my family on the highway when experiencing a power failure. My vehicle is back at a dealership waiting for a new transmission.
The contact owns a 2019 Ford Expedition. The contact stated that occasionally while her husband drives at various speeds, the vehicle would fail to accelerate as intended when depressing the accelerator pedal. In addition, the contact stated the rear truck door had fallen on her husband's head a few times in the past and would only open halfway. Minor injuries were sustained but medical attention was not sought. No warning light illuminated. On occasion, the contact mentioned that the automatic step on the front passenger side would not lower as intended and would remain up while pressing the switch. The contact also stated that the front hood does not remain open independently and would shut. An appointment with the dealer was scheduled to inspect the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the extended warranty would not cover the failures. The failure mileage was approximately 65,000.
The contact owns a 2019 Ford Expedition. The contact stated that the vehicle was making an abnormal rattling sound on cold starts. The vehicle was taken to the dealer, where the powertrain control module (PCM) was flashed under Ford Campaign Number: 21N03; however, the failure recurred. The dealer was contacted and informed the contact that the vehicle needed to be left with the dealer for three weeks for the cam phasers replacement; however, the contact declined because the dealer did not offer vehicle rental assistance. The contact stated that the failure progressively worsened. The contact stated while driving at various speeds and depressing the accelerator pedal, the engine misfired. The check engine warning light was illuminated. The dealer was notified of the failure and informed the contact that the vehicle was no longer covered under warranty. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 20,000.
I am being told that the Cam Phasers need to be replaced. This is a well known issue to Ford. They did a programming adjustment in 2021, and then did replacements only if you had continued issues up until Jan 2023. I have issues now, and they are telling me I am not covered. The cam phasers have been redesigned so they know they installed poorly designed parts originally. This is an almost $4,000 repair.
The vehicle has the known cam phaser issue commonly reported on 3.5L Ecoboost engines. It is a known problem, that the dealership is so aware of they were able to provide a repair quote on the spot. The engine had less than 50,000 miles when the issue was first discovered. The safety issue is the engine failing while driving could place someone in an unsafe situation depending on how and when it failed.
After the engine would warm up a loud knocking started without warning lights. After driving it to the dealer they stated, "You need a new engine, it probably had a blown rear main". The engine has 154,550 nearly all freeway miles. Regular maintenance. No prior issues other that a deer strike, which was repaired.
The contact owns a 2019 Ford Expedition. The contact stated while driving 50 MPH and attempting to accelerate, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the failure persisted. The service engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 55,000.
The contact owns a 2019 Ford Expedition. The contact stated that on several occasions while driving at various speeds, the vehicle lost motive power. The contact stated that on several occasions, the power train and check engine warning lights illuminated but then disappeared. The vehicle was steered to the side of the road and idled until the RPM became normal. The vehicle was taken to a dealer where it was diagnosed that there was a leak in the turbo hose. The vehicle was repaired but the failure reoccurred a week later. The manufacturer was notified of the failure. The failure mileage was approximately 38,000.
Vehicle randomly downshifts into first gear and get stuck in higher gears, allowing no acceleration, causing serious traffic accident
The contact owns a 2019 Ford Expedition. The contact stated that there was an abnormal rattling sound coming from the vehicle while cold starting the vehicle. The contact stated that the sound went away after several minutes. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the local dealer for diagnostic testing and to the federal safety agency Hotline for assistance. The failure mileage was approximately 74,000.
The car will randomly downshift or not upshift, drastically changing the handeling. It will get stuck in gears (Like 7th) and then not accelerate in traffic from a stop. The shifts are harsh enought that the tires with loose traction in wet conditions... The car is unsafe to drive and the dealer can't find a solution, other than I pay for a new transmission. The problems started with a software update for shifting into 1st gear at speed. This happens too often!
My Variable Valve Timing Actuator is not functioning properly only after 60,000 miles. Jacob's Auto Repair in Sturgis, SD had confirmed the problem. There is already a case for this problem. But my VIN number is not listed in the case and it should be as it fits all criteria. My check engine light is on.
The contact owns a 2019 Ford Expedition. The contact stated that upon starting the vehicle, there was an abnormal rattling sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the cam phasers. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 73,000.
The contact owns a 2019 Ford Expedition. The contact stated while cold starting the vehicle, the vehicle was shaking and vibrating abnormally. The contact stated that after the engine had warmed up, the vehicle was running normally. The contact stated there was no warning light illuminated. The contact stated that the failure was intermittent but had become a recurring failure. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the cam phasers needed to be replaced. The vehicle was not repaired. The contact was informed by the dealer of Customer Satisfaction Program Number: 21N03 Cam Phaser Replacement (Engine and Engine Cooling); however, the vehicle was not included. The manufacturer was informed of the failure. The failure mileage was approximately 71,000.
The contact owns a 2019 Ford Expedition. The contact stated while driving on several occasions at various speeds, there was a thumping sound coming from the vehicle. The check engine warning light illuminated. The vehicle was steered to the side of the road and turned off. The vehicle was towed to the residence. Additionally on one occasion when the vehicle was shifted into reverse, the vehicle failed to respond as intended. The vehicle was taken to an independent mechanic where it was diagnosed that parts of the transmission needed to be replaced and an engine error code was retrieved. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 75,000.
The contact owns a 2019 Ford Expedition. The contact stated that while starting the vehicle, the engine was making an abnormally loud revving sound that was louder than normal. While attempting to accelerate, the vehicle was lagging and hesitated before accelerating. There were no warning lights illuminated. The vehicle had been taken to the dealer where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle had been repaired; however, the failure reoccurred. The vehicle was returned to the dealer where it was repaired a second time; however, the failure persisted. The vehicle was taken to an independent mechanic where it was confirmed that the cam phasers had failed and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and opened a case. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 40,000.
The contact owns a 2019 Ford Expedition. The contact stated that while driving at slower speeds, there was a rattling sound coming from the engine compartment. The check engine warning light was illuminated. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the cam phasers were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 67,000.
Since we bought our car, it has had a rattle upon startup. This was originally a recall, which we got repaired, but this repair did not make the rattle go away. I then had a transmission problem and had to have the transmission overhauled due to it having violent, jerky, unpredictable shifting between gears. When I mentioned the rattle again while they were fixing the transmission, they said that it’s a known problem with Ford cam phasers around our model year. They informed me that the fix offered in the recall was an electronic fix, but the actual parts need to be replaced and the recall didn’t cover that. The parts replacement was almost $4000, and from my research, not replacing these parts can cause the engine to stop functioning properly over time. In the past two weeks, I have been getting safety notices from my car that there are timing issues that need to be serviced. Contacting Ford did not help as there is no active recall for this problem. From my research, there is an active lawsuit open against Ford for this cam phaser problem with my year model car. Overall, cam phasers play a critical role in enhancing the efficiency, performance, and reliability of 10-speed engines by enabling precise control over the engine’s valve timing. However, after just replacing my transmission we cannot afford to pay another $4000 for this error. Ford said they cannot help unless there is a recall on the vehicle.
The contact owns a 2019 Ford Expedition. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was taken to the dealer where it was diagnosed with a failed VCT phaser, a failed cam shaft sensor, O2 sensors, and a failed catalytic converter sensor. The contact was informed that the VCT phaser, cam shaft sensor, O2 sensor, and catalytic converter sensor needed to be replaced. The vehicle was not repaired. Additionally, the contact stated that the failure had occurred previously in March of 2024 however, the independent mechanic was unable to duplicate the failure. The manufacturer was made aware of the failure. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 118,000.
The contact owns a 2019 Ford Expedition. The contact stated that there was a rattling sound coming from the vehicle while attempting to start the vehicle causing a delay while starting. The vehicle had been taken to a certified mechanic where it was diagnosed that the timing chain and cam phasers had failed and needed to be replaced. The mechanic informed the contact that the failure was related to a TSB: 21B10-S3/the federal safety agency ID Number: 10201643 (Electrical System). The dealer was contacted and confirmed that the VIN was not included in a recall. The vehicle had not been repaired. The manufacturer was made aware of the failure and informed the contact that the VIN was not included in TSB: 21B10-S3/the federal safety agency ID Number: 10201643 (Electrical System). The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was 130,000.
Loud knocking from engine. No check engine light came on. Dealer found the cam phasers faulty and could possibly lead to engine failure if not repaired which would put occupants in danger. Banner Ford in Monroe Louisiana performed repair at owners expense.
Ford issued a recall on the cam phasers for some vehicles this year make and model. Ours was never recalled but obviously faulty as we are having to replace the motor at 80000 miles.
Transmission and shifting problems under 70,000 miles. Also the ac compressor and blower has gone out.
The contact owns a 2019 Ford Expedition. The contact stated when the vehicle was started, there was an abnormally loud rattling sound coming from the engine. The contact stated that while driving at an undisclosed speed, the vehicle stalled. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed as a failure with the cam phaser. The contact was informed that the cam phasers needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 111,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Ford Expedition?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history