1. My Transmission failed and the car came to a complete stop in the middle of the highway, ford could not assist in replacing the Transmission and I have heard so many complaints about the 10 speed transmissions failing just after reaching 100,000 mileage. Mine failed under 108,000 mileage and this has been going on for years and consumers end up spending thousands of dollars on a $70,000 vehicle. This issue needs to be addressed. I paid over $8,000 to replace the transmission. 2. Ford Expeditions and F150 have a trim piece on the center console that's covered by an aluminum wrap which pops off and it's very sharp, so many ford owners have been cut by that piece and ford only replaces the whole center console if the vehicle is under warranty as there's no other solution to replace only the trim but you get to replace the whole center console which's Expensive. 3. For 3.5L engines have continued to have cam phaser failure for the past few years but Ford doesn't seem to address this issue which cost customers millions of dollars every year, we the customers do know that Ford benefits from selling parts and Ford 100% knows how expensive it's to replace a cam phaser which cam cost anywhere from $4,000 in parts and labor. We hope that the federal safety agency can step up and have ford address these issues.
2019 Ford Expedition transmission complaints
Page 5 of 9: complaints 101 to 130 of 224, newest first, as owners wrote them.
When driving down the interstate or crossing traffic the transmissions in these vehicles will slip causing you to be immobile. Possibly causing death
The contact owns 2019 Ford Expedition. The contact stated that while accelerating between first and second gear, the vehicle jerked abnormally, and the RPM decreased almost causing the vehicle to stall. The contact stated that after the hesitation, the vehicle returned to normal operation. No warning lights were illuminated. The vehicle was taken to a local dealer to be diagnosed. The contact was informed that the transmission and clutch were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 101,671.
When driving on a highway we went to pass a slower moving vehicle. When pulling out into the oncoming lane to accelerate the automatic transmission slipped into neutral. This situation became dangerous because there was a vehicle coming at us and we had to break to get back behind the slower vehicle. However the transmission did go back into gear causing us to become a hazard to the vehicles behind us. Again this happened on the interstate when accelerating to get on the interstate. This is a known problem by Ford and has been documented many times. Ford claims that since the vehicle is past the warranty period they aren't responsible to repair.
The contact owns a 2019 Ford Expedition. The contact stated while attempting to start the vehicle, there was a rattling sound coming from the engine. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the cam phaser and the timing chain needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was referred to the federal safety agency Hotline for assistance. The contact related the failure to Customer Satisfaction Program: 21B10 (Powertrain Control Module Reprogram for Cam Phaser Rattle). The failure mileage was 121,000.
Ongoing transmission issue that ford has not recalled from the release of the 10 speed transmission until 2022 when they replaced the CSF drum
Vehicle has a rattle upon starting. Also the vehicle is shifting harshly and slipping. Sometimes the vehicle will occasionally stop accelerating in the middle of the road. The RPMs will rise but the vehicle stops having power. After a minute it finally jerks and the vehicle will go again. I have had the vehicle examined by a technician and have been told that it is the cam phasers, CDF drum/transmission, and torque converter.
The 10 speed transmission has harsh shifting, jerking, hesitation, slipping, delayed gear changes and lurching forward while driving. The issue is apparent typically between 3rd and 4th gear, and 6th and 7th gear. The dealership mentioned it was a computer programming issue and has reset it twice, but the car continues to have these issues. Apparently this issue is cause by the way the drum was manufactured according this Ford Technician: [XXX] If it's a known issue, and it was fixed in the newer models, I hope Ford does a recall to replace. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Rattles on every cold start related to cam phasers going bad
I was on the freeway going between 65-70mph when I felt a hard shift and lost all acceleration. The truck started to slow down and the wrench light came on. I was able to coast to the shoulder and turn my hazards on while the wrench light and warnings were going. I parked the truck and waited for my husband to help. The truck sat for approximately 20 minutes when it was turned back on. There were no lights on the dash and the wrench warning went away [XXX] husband was able to drive it home. I had my three kids in the truck and it was a terrifying experience. I took it to get scanned and it gave us a throttle body code. My vehicle supposedly isn't affected but this experience tells me that myself and my kids are in more danger than what is being claimed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
This appears to be a common problem when I researched it online. When trying to accelerate hard, the transmission will suddenly go to neutral instead of shifting. This causes a pause in accelerating when you need. It will then slam in to gear a few seconds later with various warnings about the transmission showing on the dash. I have had the vehicle inspected right after an incident that happened and there are no codes though you have warnings that temporarily show on the dash when it happens. The most recent incident was on the freeway while changing lanes to go around slower traffic and caused the person behind us to have to hit their brakes since the vehicles was unable to accelerate and even slowed instead for several seconds.
The contact owns a 2019 Ford Expedition. The contact stated that while driving at various speeds and hitting a bump, the rear end of the vehicle shuddered violently. The contact also stated that upon starting the vehicle, the vehicle made an abnormally loud sound momentarily. Additionally, the contact stated that while depressing the accelerator pedal from a complete stop, the vehicle failed to respond. The contact stated that upon releasing and slightly depressing the accelerator pedal, the vehicle responded. Recently, the contact stated while driving at highway speeds, the front end of the vehicle would shake upon depression of the brake pedal without warning. The contact stated that the failure had been recurring while driving at various speeds, which required the contact to slightly depress the accelerator pedal several times until the vehicle progressively accelerated to the desired speed. There was no warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure and a case was opened. Additionally, the manufacturer informed the contact that the VIN was not included in a recall and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 120,000.
On three separate occasions, my vehicle lost the ability to accelerate. The first time I was attempting to pass slow moving farm equipment when my vehicle lost power, had a loud vibrating/rattling noise and multiple dashboard warnings flashed. Luckily, I was able to merge back into my lane and pull off the side of the road. I took the vehicle in for service and was told I needed new phasers. Once I got my vehicle back, I was still experiencing issues. Fortunately, the next two times my vehicle lost power I was driving at low speeds. I did have my kids with me on one occasion and it scared them quite a bit. I am not sure what the loud noise is but they stopped riding with me after that. Thank goodness I was not driving my family on the highway when experiencing a power failure. My vehicle is back at a dealership waiting for a new transmission.
The contact owns a 2019 Ford Expedition. The contact stated that the vehicle was making an abnormal rattling sound on cold starts. The vehicle was taken to the dealer, where the powertrain control module (PCM) was flashed under Ford Campaign Number: 21N03; however, the failure recurred. The dealer was contacted and informed the contact that the vehicle needed to be left with the dealer for three weeks for the cam phasers replacement; however, the contact declined because the dealer did not offer vehicle rental assistance. The contact stated that the failure progressively worsened. The contact stated while driving at various speeds and depressing the accelerator pedal, the engine misfired. The check engine warning light was illuminated. The dealer was notified of the failure and informed the contact that the vehicle was no longer covered under warranty. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 20,000.
I own 2019 Expedition had a powertrain malfunction happened to me around 48k miles a few years back on the I35 by Pauls Valley, OK and we all most got ran off the road. Scary. Was able to get home which was 30 minutes away on back road going about 35mph. Next morning no, light vehicle was fine. I did report this to my local Ford dealer, Charles Allen Ford in Chickasha, OK. Was advised it was most likely due to condensation within a sensor or weather change. I trusted them on their assessment since it hasn’t happened again. This past Monday coming from sons football game which is 26 miles away it happens again, vehicle stalling and we almost got hit by a Semi truck. I currently have 84k miles Next morning was fine. No codes showing and vehicle ran as usual. I told Jim Allen who owns the Charles Allen Ford about this when I seen Tuesday at the local YMCA. he advised probably weather change within a sensor. Told me to bring it for a check and they would take care of me. I didn’t as I don’t have the money to do that, especially after hearing other stories how the dealership kept the vehicle for weeks to months without finding an issue. So I took to my neighbor owns a diesel mechanic shop so we put on lift and check transmission fluid, clear and no flakes. Check lines although I do have a coolant / water hose leakage, which I order the part for. Ford needs to address this issue. I’m a [XXX] who depends on my vehicle to go to much needed VA appointments in Oklahoma City. Please help. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
With our expedition on numerous occasions the transmission will be acting as normal and then go into a false neutral which will leave the vehicle unable to accelerate or be moved over to safety, it has happened while trying to merge and nearly causing a accident and then on another occasion crossing a non divided highway only to leave me stranded unable to make it move with oncoming traffic, very dangerous situation .. the problem is very hard to replicate for dealers to diagnose
Our car is only 2 months out of warranty and has 52,000. I have the 10R80 or 10-speed transmission that is all of the internet. My symptoms include very hard jerks when slowing down while driving, Loss of power when accelerating, and a delay in power when accelerating from a complete stop. I drive 4 kids around and it feels like I am being rear-ended sometimes. The dealerships are well aware of this problem with these cars but will not take action.
I am being told that the Cam Phasers need to be replaced. This is a well known issue to Ford. They did a programming adjustment in 2021, and then did replacements only if you had continued issues up until Jan 2023. I have issues now, and they are telling me I am not covered. The cam phasers have been redesigned so they know they installed poorly designed parts originally. This is an almost $4,000 repair.
After the engine would warm up a loud knocking started without warning lights. After driving it to the dealer they stated, "You need a new engine, it probably had a blown rear main". The engine has 154,550 nearly all freeway miles. Regular maintenance. No prior issues other that a deer strike, which was repaired.
The transmission has been repaired previously with the valve body replacement. It seems to be better but has hesitation or lag with upshifting still.
The contact owns a 2019 Ford Expedition. The contact stated while driving 50 MPH and attempting to accelerate, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the failure persisted. The service engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 55,000.
The contact owns a 2019 Ford Expedition. The contact stated that on several occasions while driving at various speeds, the vehicle lost motive power. The contact stated that on several occasions, the power train and check engine warning lights illuminated but then disappeared. The vehicle was steered to the side of the road and idled until the RPM became normal. The vehicle was taken to a dealer where it was diagnosed that there was a leak in the turbo hose. The vehicle was repaired but the failure reoccurred a week later. The manufacturer was notified of the failure. The failure mileage was approximately 38,000.
Transmission is shifting hard around 4th or 5th gear. It is lagging as well causing the car not to accelerate when needed causing safety concern while driving in traffic. It will randomly have high rpms like it is shifting out of gear when not needed. There are no lights or codes. It hasn’t been inspected by dealer. It is a common problem on ford expeditions. My friend is having the exact same problem and you can find it all over the internet of other consumers have the same problem as well. It is dangerous to drive if it malfunctions while on the road with traffic especially with children in the car.
The contact owns a 2019 Ford Expedition. The contact stated while operating the vehicle, the transmission experienced hard shifting with the transmission slipping between gears third and fifth gear, causing the vehicle to decelerate. Additionally, the vehicle failed to properly accelerate while depressing the accelerator pedal. The vehicle was taken to the local dealer who diagnosed that the clutch was faulty, and that the transmission needed to be replaced or rebuilt. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approximately 99,000.
Vehicle randomly downshifts into first gear and get stuck in higher gears, allowing no acceleration, causing serious traffic accident
The cam phasers on my vehicle need replaced, and the vehicle is available for inspection upon request. I took the vehicle to Ford initially and was told "they didn't have a mechanic" that could address the issue on a Saturday, and completely dismissed the concern and only changed my oil. I have since had two separate mechanics diagnose the problem, and each independently determined the cam phasers are the issue. My safety isn't at risk, as I understand it the cam phasers aren't a safety issue. I was told by Ford that they couldn't answer my questions or help me, and was directed to contact the federal safety agency with my concern. There are no warning lamps or messages; the problem was identified by the audible noise presented at start up. I contacted Ford after I became aware that there were CSP's issued with regard to the CAM phasers, but Ford stated my VIN wasn't assigned to the CSP. However, the CSP identifies a specific build plant, and build date, both of which my vehicle falls under. So there is no plausible explanation for how they did not assign my VIN to the CSP, therefore I was not notified back in 2022 or 2023 of the issue, so I had no chance to rectify the issue when the problems occurred, nor was I made aware that this issue might arise.
My Ford Expedition Max started to make a rattling noise after I start the vehicle, if the car was running for a while I could turn it off and on again and wouldnt hear the noise, but if the engine was cold it would make a rattling noise when started. Then if I do not let the SUV warm up long enough and start driving it would have a point where it would do a random hard slow down before it would kick into gear and then it would feel like it was running fine. This started a few weeks ago the I was driving on the highway and while i was doing about 55MPH the suv made a loud noise that made the vehicle change speed dramatically it cause me to be whiplashed forward before the engine seemed to catch back up to its orevious actions, it did not actually cause an accident at that point (but it very well could have if the road was busy as it was a dramatic chnage in speed as well as the noise it made). I pulled over to inspect but there was nothing in the road and nothing that was being done that seemed to cause the traumatic issue. The next day when I brought the car to the mechanic and explained the issue he was able to diagnose an issue with the timing chain. Upopn some resaerch there many complaints and issues with my that make/models particular engine and parts that have had issues but the dealer would not assist saying there is no formal recall and at 69K miles I am over the warrenty. My car doesnot have any codes or warning lights and has all regularly scheduled maintenance and repairs done regularly but the car is clearly not driving correctly, This issue is causing the SUV to dramatically change speed while driving which is likely to cause an accident and severe injury.
While driving on the highway, and the vehicle tries to downshift, the transmission makes a loud clunking sound and shifts into neutral, causing the vehicle to slow rapidly while driving. Warning lights appear on the dash as this occurs, and the vehicle sits in neutral for 15 to 30 seconds, leaving you without acceleration while stuck on the road. This has happened 3 times in a short amount of time, and has put us and our cars children in an incredibly dangerous situation each time. On the third time, while trying to figure out what happened, we realized this is a known issue that Ford has recalled on other models (F150) but has fought recalling on the Expedition. Both the F150 and the Expedition use the same transmission, and Ford has admitted to a design flaw that causes the shifting issues. We would like to request that Ford be held responsible for the safety issue that affects all vehicles with their 10 speed transmission, not merely just the F150 because it is their most popular model.
cam phasers need to be replaced AGAIN, which is only 2.5 years since the last time they were replaced. had them replaced the first time under warranty. and then 2.5 years later was told they need to be replaced again, and it will cost $4,000.
The contact owns a 2019 Ford Expedition. The contact stated that while driving at various speeds, the vehicle had experienced transmission failure, causing the vehicle to hesitate during acceleration and unintendedly decelerate. The vehicle was taken to an independent mechanic who was unable to identify the cause of the failure. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 82,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Ford Expedition?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history