I was driving at highway speeds and parking suddenly engaged forcing vehicle to lose all power. While I was able to get the vehicle off the road it could have ended much worse. Ford recognizes this as a recall but because it it is not officially active they will not fix it unless I pay for it. Manufacturer Recall Number26S48 the federal safety agency Recall Number26V402
2020 Ford Expedition transmission complaints
Page 3 of 10: complaints 41 to 70 of 270, newest first, as owners wrote them.
Vehicle has intermittent shift issues. Transmission will shift to neutral while in motion. Issue is not terrain specific. Poses extreme safety issue has been looked at and not found by mechanic. Ongoing issue since I took ownership in Nov. 2024.
The vehicle has experienced repeated critical transmission failures and currently has four active Federal Safety Recalls with no available remedy. The transmission has failed four separate times, requiring four transmission assemblies within approximately 68,795 miles. The latest failure produced DTC P07F7 (Gear 10 Incorrect Ratio) and was confirmed by the Ford dealer and an independent inspector as an internal transmission failure. Symptoms included harsh engagement, delayed shifting, hesitation, slipping, and repeated powertrain malfunction messages. The vehicle was out of service for 26 consecutive days during the most recent repair. A the federal safety agency VIN lookup shows four active unrepaired recalls: a transmission rollaway hazard affecting the parking system (26S48), two seatbelt pretensioner recalls involving inadvertent deployment or failure to retract (25S31 and 26S34), and a chrome trim recall involving sharp edges (26S38). All four recalls currently have no remedy available, with estimated repair dates extending into late 2026 and 2027. These defects affect critical safety systems including the power train, seat belts, and parking system. The rollaway hazard recall indicates the vehicle may move unexpectedly even when shifted into Park, creating a serious risk of injury or collision. The seatbelt pretensioner recalls involve components that may deploy without warning or fail to retract, increasing the risk of injury in a crash. The chrome trim recall involves sharp edges that may injure occupants. Combined with repeated transmission failures, these issues create multiple simultaneous safety risks. The problems have been confirmed by the Ford dealer and an independent inspector. Warning symptoms occurred before each failure, including harsh shifting, slipping, hesitation, and powertrain alerts. The combination of unresolved Federal Safety Recalls and repeated transmission failures makes the vehicle unsafe to operate.
When attempting to accelerate (gently) on the highway, the vehicle hunted for gears and shook violently and have zero acceleration. A wrench flashed on the screen of car. Felt like it went to neutral as engine rpm's increased rapidly accompanied with a loud thunk. Thankfully we were in a safe spot to just coast and exit the highway.
Failed Component & Availability: Ford 10R80 10-speed transmission (Power Train). Available for inspection upon request. Safety Risk: My family is put at extreme risk in two ways. 1) Sudden loss of motive power, slipping, and violent engagements at highway speeds create an imminent rear-end collision risk. 2) This exact vehicle is now under Safety Recall 26S48 (the federal safety agency 26V402) for unintended vehicle rollaway. Ford explicitly states a remedy is not available until Q2 2027, forcing us to drive an unfixable, inherently dangerous vehicle for another year. Confirmation & Inspections: Yes, reproduced and confirmed by Tomball Ford. The latest catastrophic internal failure was physically inspected and confirmed by an independent Old Republic Auto Warranty inspector. The Tomball Ford technician explicitly documented the cause as "outdated internal components" aligning with TSB 25-2476. Warnings & Symptoms: Violent shifting, delayed engagement, and "Powertrain Malfunction / Reduced Power" dash warnings. The latest catastrophic failure triggered hard fault DTC P07F7 (Gear 10 Incorrect Ratio). Cause Summary: Chronic manufacturing defect inherent to the Ford 10R80 / 10R60 transmission family. This vehicle has required FOUR (4) transmission assemblies in under 70,000 miles (repairs in Nov 2022, Feb 2023, and June 2026). During the most recent failure (May-June 2026), the vehicle was out of service for 26 consecutive days. Despite 4 failed transmissions and an active unfixable safety recall, Ford Corporate just denied our request for a replacement vehicle, abandoning my family in a documented rolling hazard.
The contact owns a 2020 Ford Expedition. The contact received notifications of the federal safety agency Campaign Numbers: 26V344000 (Seat Belts), 26V368000 (Structure), 26V402000 (Power Train); however, the parts for the recall repairs were unavailable. The contact stated the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that while driving at various speeds, the transmission started slipping. After releasing the accelerator pedal and slowing down, the engine made a revving sound, and the transmission failure was self-corrected and shifted to the proper gear. While starting the vehicle or while driving at various speeds, the transmission hesitated shifting into the intended gear. There was an unknown warning light flashing on the instrument panel. The contact stated that after purchasing the vehicle in March of 2026, the Carfax report stated that the transmission had been replaced, and the contact purchased the vehicle under the belief that the vehicle was equipped with a new transmission. In May, the vehicle was taken to a certified mechanic, who diagnosed the vehicle and determined that the valve body had failed and needed to be replaced. The vehicle was not repaired. The contact emailed the dealer about the diagnostic results and the needed repair. The dealer confirmed the failure. The dealer replaced the valve body, but the failure persisted. The dealer then diagnosed in June that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 88,467.
The transmission (10R80) in the 2018-2022 Ford Expedition and Ford F-150 vehicles are failing at an alarming rate. There are hard shifts, hesitation, and some vehicles, like mine, drop out of gear at highway speeds putting myself and my family at risk of a traffic collision. The repairs are in the many thousands and there are tens of thousands of transmissions that are failing. Something needs to be done to protect the consumer.
The vehicle at highway speed failed to accelerate or hold speed. Warning text came up on dash. Vehicle rpm increased yet vehicle failed to accelerate or hold speed. Vehicle felt like it went into nuetral. This happened several times. Vehicle driven to dealer for transmission repairs. Code P07E6 stored in ECM.
The contact owns a 2020 Ford Expedition. The contact stated that while the transmission was shifting in and out of eighth gear, the vehicle failed to respond as intended. The contact stated that the transmission occasionally failed to shift into eighth gear. While decelerating, the vehicle responded, and the transmission shifted roughly. The failure became persistent over time. There was an abnormal clunking sound coming from the vehicle. The transmission fault message was displayed. The local dealer was contacted and confirmed that there were no issues or recalls on the VIN related to the failure. The dealer informed the contact about a diagnostic test to determine the cause of the failure. The vehicle was taken to a transmission specialist who informed the contact about a transmission replacement and the cost to rebuild the transmission. The manufacturer was not contacted. The failure mileage was approximately 70,000.
Vehicle trasmisson will randomly shift into neutral and loose all power. It does pickup and go back into the correct gear within 5 seconds. Intermittent power loss at higher speeds and on busy roadways does cause safety concerns. Transmission oil has been changed and checked repeatedly. This has been a continuing problem since I took ownership 2 years ago. I have complained to ford directly with no response or remedy. The vehicle has been inspected multiple times but nothing seems to be a remedy. No lights come on and no vehicle notifications were given. The transmission temp did go up to 207F at the last instance and eventually cooled back down to 196F. This has happened while traveling on flat roads and up hill. There seems to be no difference on terrain or speed.
We purchased a used 2020 Ford Expedition Max Platinum, VIN [XXX] , from Deacon Jones dealership. The vehicle currently has 128,888 miles. At the time of purchase, we were assured the SUV was in “tip-top shape” because it had previously belonged to a manager’s friend and had supposedly been well maintained and serviced. However, within only two weeks of purchasing the vehicle, the transmission began slipping out of gear while accelerating, causing the vehicle to lose power and fail to move properly. This is an extremely dangerous safety issue, especially considering I travel frequently to doctors’ appointments and regularly transport my seven grandchildren in this SUV. In addition to the transmission failure, the main electrical system controlling the dashboard frequently glitches and malfunctions, even after Ford performed a software update. These ongoing electrical problems create additional safety concerns and make the vehicle unreliable. We immediately contacted the dealership after the problems began. Their only offer was $750 toward a transmission replacement that will cost over $5,000. We simply do not have that kind of money, especially while continuing to make monthly payments of $850 on a vehicle that is unsafe to drive. We have also since discovered the vehicle had previously been involved in an accident that was never reported to us before the sale. What is most concerning is that this vehicle appears to have received an inspection sticker despite clearly not undergoing a proper inspection. A transmission that slips out of gear and significant electrical malfunctions should never have passed inspection. This places not only my family at risk, but also everyone else on the road. We have written several letters to Ford regarding the safety concerns surrounding this vehicle and the danger it poses to our family. Unfortunately, Ford responded stating they would not assist us in any way. It is extremely disappointing INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 55
We have recurring safety issue with our car that has not been fixed despite multiple service visits to both Grieco Ford and Sawgrass Ford. They keep sending it back as “cannot duplicate”. We have contacted Ford Corporate and they also will not assist. We purchased this car used from Sawgrass ford and purchased an extended warranty with the car. The car issues include: Slipping into Neutral: The transmission unexpectedly loses gear engagement while merging or accelerating on the highway. • Hard Shifting/Clunking: Violent gear changes that cause the whole vehicle to jar physically. • Gear Hunting: The car hesitates and shifts up and down erratically instead of holding a gear. • Limp Mode: Sudden, dramatic loss of power where the car refuses to accelerate properly in traffic. These are serious safety hazards that put our family in harm's way. These failures happen consistently with our children in the car, and they have happened to our teenage son while he was driving. We purchased this car used from Sawgrass Ford. The earliest service documentation I currently have readily accessible showing that this vehicle was brought to Ford for transmission-related concerns is from February 2024—less than seven months after we purchased the vehicle from Sawgrass Ford. Since that time, there has been a significant service history related to this recurring issue.
Shortly after purchasing this vehicle used in May 2024, we began experiencing hard and erratic shifting, particularly between 4th to 5th and 7th to 8th gears. On August 12, 2024, a Ford dealership performed a PCM update, which provided only temporary and partial improvement. The issue was never fully resolved. In January 2025, the vehicle was diagnosed with a failed CDF drum within the 10-speed transmission. We paid $4,610.13 out of pocket for this repair. Despite this repair, the same transmission issues have persisted. The vehicle continues to exhibit hard, delayed, and unpredictable shifting that affects drivability. Most recently, we were advised that additional transmission work may be required, potentially including a full rebuild or replacement estimated at approximately $9,200. We have also incurred additional diagnostic costs related to this repeat failure. The erratic shifting creates inconsistent and sometimes delayed acceleration, which raises safety concerns when merging into traffic, crossing intersections, or maintaining consistent vehicle speed. Based on our research and discussions with a transmission specialist, this issue appears to be common among 2020 model vehicles equipped with this transmission, suggesting a potential defect rather than normal wear and tear. This ongoing failure, even after a major repair, raises serious concerns about the reliability and safety of the vehicle.
On at least 5 separate occasions the vehicle has slowed significantly and failed to downshift in order to accelerate. This has been accompanied by high transmission temps and power train warnings. In one instance the vehicle slowed to below 40 mph on an expressway with a speed limit of 70. Eventually the vehicle will downshift with a harsh and erratic shift which will then accelerate the vehicle. I'm at the point where it does not feel safe to have the vehicle on the expressway.
SUV jerks when shifting, hard shifts, transmission fails to shift preventing driver to speed up resulting in hazardous driving condition when entering a highway. Metal shards recovered from transmission fluid checks. Occurs consistently when moving to higher speeds, i.e. acceleration from red light to green light. Or entering highways, freeways when acceleration is needed.
The transmission has now stalled in 2 situations within 7 days. Stops pulling for about 30 seconds, then a loud pop occurs as the transmission kicks back in to working. 53,000 miles on the vehicle, no warning lights came on or currently on.
While merging on to highway vehicle made loud clunk, transmission slipped and vehicle went into fail safe mode(limp mode). Vehicle would not accelerate when pushing on gas pedal for 8 seconds. Tractor trailer truck behind us slammed on its brakes as well as 3 other vehicles due to tractor trailer truck swerving in lanes to stop. Was almost rear ended by tractor trailer truck. Vehicle has TSB’s on 10 speed 10R80 transmissions but no recalls. Vehicle does not throw code so vehicle can not be assessed or repaired according to dealership and Ford motor company. This is a huge fatality risk and safety issue regarding multiple claims of the 10R80 transmissions in the newer ford expeditions.
The power liftgate system appears to be malfunctioning. The vehicle intermittently displays a warning that the liftgate is open when it is fully closed and secured. When this occurs, the liftgate will not open using the exterior handle, interior button, or key fob. Additionally, the false “liftgate open” alert triggers the vehicle’s alarm system to activate unexpectedly without any attempt to access the vehicle. The issue occurs randomly and without warning. This malfunction creates a safety risk because the liftgate cannot be opened when needed, which could prevent access to emergency supplies, child safety items, or the spare tire in an urgent situation. The false alert also causes the vehicle alarm to activate randomly, which can startle the driver and others nearby, potentially causing distraction while driving or in traffic areas. Additionally, the system incorrectly indicates that the liftgate is open, creating uncertainty about whether the vehicle is secure and safe to operate. A malfunctioning liftgate could present a hazard if the vehicle incorrectly detects an open door while in motion. Yes, the issue has been reproducible at Bluebonnet Ford in New Braunfels, TX. No, alerts prior to it happening, when I does alert all lights in the vehicle turn on, as well as notifications on the Ford Mobile app
The 10-speed automatic transmission has harsh/ erratic shifting, clunking, hesitation and power loss. We were turning on to a 4-lane highway. The expedition lost power and would not go. A vehicle almost ran into the back of the expedition. When we tried to accelerate the transmission made a clunking/ grinding sound and finally went into a gear. Yes, the problem has been reproduced by the ford dealership. It is scheduled to be inspected this week. There were no warning lamps or messages or other symptoms of the problem. The problem started a week ago.
Transmission clucks when changing gears
Component/System Failure: The vehicle is experiencing a catastrophic transmission failure (specifically the 10R80 transmission) beyond what is described in Ford TSB 24-2101. The transmission slips significantly and loses all power transmission while in motion. Safety Risk: My safety and the safety of other motorists are at extreme risk. While driving at highway speeds (approx. 65-70 MPH), the vehicle suddenly loses the ability to maintain speed or accelerate. This causes an immediate, unexpected deceleration in high-speed traffic, nearly resulting in rear-end collisions. The system takes several seconds to "reset" or catch a gear, during which time I have zero control over the vehicle's propulsion. This is an intermittent but recurring failure that makes the vehicle unpredictable and life-threatening to operate in traffic. Confirmation/Inspection: The problem has been confirmed by a Ford dealership service center and a secondary certified independent mechanic. Both confirmed the transmission is failing and cited TSB 24-2101 as the diagnostic path. The Ford dealership inspected the vehicle and confirmed that a full transmission replacement is required, but stated they would not provide financial assistance as the vehicle is just past the default warranty, despite the TSB acknowledging a known manufacturing defect. Symptoms/Warning Lamps: Symptoms began approximately August 2025. There were no warning lamps prior to the first failure, although it flashes lights temporarily when the problem occurs. The primary symptom is a sudden "free-spinning" or rattling engine sensation followed by a complete loss of forward momentum. The issue has grown progressively worse over the last months and as such is not safely drivable.
I am filing a safety complaint regarding my 2020 Ford Expedition, which is currently subject to Recall (24E13) related to the Powertrain Control Module (PCM)> Despite multiple repair attempts, the vehicle continues to experience dangerous transmission and drivability issues. While driving , the vehicle: Loses gears unexpectedly Engine RPMs rev excessively high before the transmission finally engages Hesitates and has delayed acceleration Randomly makes loud clunking noises during shifting Emits a noticeable burning smell during acceleration These issues create serious safety concerns, particularly when merging into traffic, crossing intersections, or accelerating from a stop. The delayed acceleration and gear loss place me and my passengers at risk of collision. The vehicle has been brought in multiple times for the same recall-related issue, yet the problem persists. The repair attempts have not resolved the unsafe condition. I am requesting immediate corrective action to ensure the vehicle is safe to operate. This ongoing defect presents a clear safety hazard.
While driving my 2020 Ford Expedition at approximately 50-60 mph, the vehicle experienced a sudden, unintended downshift without driver input. The dashboard gear indicator abruptly dropped to "1st gear." This caused rapid deceleration and a mechanical "chattering/popcorn" noise as the transmission struggled to find a gear. The loss of power in traffic created an immediate safety hazard and risk of a rear-end collision. A certified Ford dealership (River View Ford - Oswego, IL) has diagnosed this as an internal Transmission failure.
My Ford Expedition (2-wheel drive) is experiencing jerking at variety of speeds, (changing gears, slowing down) and will sometimes get stuck in gear when I press the gas. Today, as I was entering the freeway, I pressed the accelerator and the transmission did not engage—there was no power at all until I released the gas pedal and pressed it again, at which point it finally engaged. This issue happens intermittently and is a serious safety concern, especially because I cannot predict whether the vehicle will hesitate or fail to respond when accelerating.
Transmission will randomly jump while accelerating and downshift to the point that we have to get to the interstate shoulder. This has happened many times.
We bought this truck new. When accelerating in “normal” transmission, mode, it would downshift and the turbos would kick in at the same time giving an unwanted surge of power. I found that driving in “sports” mode would give me more normal acceleration. Another issue I had as it got older was getting a big clank from the transmission when putting it in gear, especially in the morning when cold. I described it as hitting an anvil with a hammer. I took it to our local Ford dealer in Carthage, Missouri in early January 2025. The Service Rep said this was normal and I should let the truck warm up before shifting into gear. I told him I parked in the garage and that was not possible. He did not schedule an appointment to check it. About two weeks later on February 5, 2025 with 57,796 miles I returned to the dealer and insisted they check it before the warranty expired. They found nothing wrong. On the weekend from [XXX], I drove approximately 700 miles. During this weekend when accelerating to pass cars at highway speeds the truck would lose complete power like the transmission had shifted into neutral. This happened at least three times. I took the truck back to the Ford dealership on August 7, 2025 with mileage of 66,683. They said the transmission needed replaced. My cost was $9914.95. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2020 Ford Expedition with 38,094 miles started having delayed and rough shifting a few days after my warranty was out on December 12th. 2024. I had looked up the issue before I took it in and found all these complaints and was worried mine was having this same issue. Took to our ford dealer and it was confirmed that my 10R80 transmission had failed and my CDF drum is worn and quoted 5600 to fix! They refuse to cover the cost knowing I and 1000's of others have had this same issue. FORD refuses to acknowledge it and the consumer is left with bill. I have owned 2 ford Explorers and 2 Expeditions in my driving life and feel like they have screwed me over. This needs to be resolved. They need to be held accountable! I am at a loss here and cant afford this fix so does a practically new ( by mileage terms ) car just sit in the yard and rot now??
My transmission started jumping gears and slipping at 65k miles. I had it checked out then and the mechanic said that these transmissions shifted rough, but they were not really sure why and that they reprogrammed the computer and that should fix it. It went on intermittently for the next 6 months to a year and I took it in again and was told they couldn't get the transmission to shift rough or skip so I would have to come back once it got worse. The longer I drove it, the worse it got until I would regularly lose all power to the wheels even at high speeds as the transmission failed to find a gear to engage. I finally took it back to the dealer again and this time they found that the front differential had failed and was full of metal shavings, the transmission was shifting really hard and missing gears and the driveshaft seal had failed and begun leaking as well. The vehicle had approximately 90k miles on it, and Ford didn't even recommend a transmission service/fluid change until 100k. I drive almost exclusively highway, rarely use 4WD, and had only towed twice with less than half it's capacity. I pressed the Dealer and Ford on how it's possible that a transmission fails before it's first recommended service. They said it shouldn't have and offered to replace my transmission with a remanufactured one for the low price of over $9,000. I had the transmission rebuilt at a local shop who said they are regularly rebuilding these expedition transmissions and that they fail frequently. The vehicle losing all power to the wheels, with no warning lights and searching for gears with no warning is incredibly dangerous. After doing this several times, it did eventually throw the first loss of power blinking lights across the dashboard, and day transmission fault.
I am suggesting an investigation into the 2020 model Ford expedition relating to the 10 speed automatic transmission in this vehicle and others in previous and newer models. The problem is known and has been well documented that the transmission often fails and pops out of gear especially when accelerating and is extremely dangerous for obvious reasons while passing or climbing hills. There is not a recall for repair or replacement of these transmissions. The recommended service for this transmission occurs at 150000 miles according to the owners manual however failure often begins well before the first recommended service interval. The cost to repair or replace the equipment often exceeds $10000 and service managers are well aware of the issue.
The incident occurred while traveling at 75 mph on the interstate. The car felt like it tried to put itself in park and slammed forward violently, at that time it came up with a shift fault light on the display, it shifted to neutral so there was no movement of the vehicle it was free wheeling, then it slammed itself back in a low gear where the vehicle slammed hard and the car engine was redlined. The transmission then proceeded to shift back up into a higher gear. All this while traveling at 75 mph. My concern, if one of my kids were driving it, or the road conditions would have been wet or snowy we would of had a very different outcome. The vehicle was sent to a Ford dealer where they found a park shift failure and shift issues recommending a new transmission. Ford was not willing to warranty the transmission even with the issues experienced and forced me to pay 60 percent of the cost. I find this hard to believe since a family could've been severely injured or killed. Previous to this incident, there were no warnings, lights, or concerns, the issue came out of the blue.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2020 Ford Expedition?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history