The contact owns a 2020 Ford Expedition. The contact received notification of the federal safety agency Campaign Number: 25E070000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that he lived near a School Zone and was concerned that the failure could occur, causing the vehicle to strike and injure children on the road. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and advised the contact that the vehicle was safe to drive because the recall was not a safety recall. The contact had not experienced a failure.
2020 Ford Expedition transmission complaints
Page 4 of 10: complaints 71 to 100 of 270, newest first, as owners wrote them.
I got a brand new transmission put in at the beginning of the year but my whole car spits and sputters and shakes going 45 and when I am backing up it throws me forward(almost in the car in front of me) instead of reversing and making a loud clinking noise
My 2020 Ford Expedition Platinum VIN [XXX] miles suddenly began harsh shifting violent kicking/jerking and lunging between gears while driving at highway speeds 65-80mph. The vehicle slams into gear unexpectedly and has nearly caused loss of control on multiple occasions. Dealership diagnosed CDF drum failure in the 10R80 automatic transmission requiring full transmission replacement at a cost of 8,057 (TSB 25-2132 and prior TSBs). This is a known widespread safety defect affecting thousands of 2018-2022 Ford vehicles equipped with the 10R80 transmission. Ford has issued multiple TSBs and is currently facing class-action litigation over this exact failure. Despite the clear safety implications and identical cases being approved for 100% goodwill coverage, ford is refusing full repair coverage in my case. This defect presents an unreasonable risk to motor vehicle safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Transmission stalls, shifts hard, shutters,. Had the transmission rebuilt about four months agoand similar issues are already starting with the rebuilt transmission.
The transmission failed. It is being rebuilt when the dealership can get to it. So it's available until then. The transmission would slip, lag shifting or slam into gear sporadically and unpredictably. This caused inconvenience at best and erratic vehicle behavior that endangered myself and other drivers at worst. This has been confirmed by the dealer who recommended a rebuild with improved parts to correct this know condition/failure. Yes the Ford dealer inspected the transmission. There we never any warnings or messages to indicate anything is wrong. The symptoms progressed for a couple days before I brought it to Ford.
2020 Ford Expedition FX4. Towing a four wheeler and motorcycle on the expressway. The suv was in tow / haul mode and on cruise. The car downshifted to go up a incline and made a booming noise and then composed its self. Shortly after, I tried to pass a car, and the trans downshifted, made a couple of loud clunks, shuddered, lost all power. After a couple terrifying seconds it composed itself, found gear and maintained speed, acceleration was not possible as the trans would go out of gear. Further down the road, it did the same thing, clunk, clunk out of gear, no power. There were NO warning lights. I took it out of tow mode and tried both sport and standard settings, both had similar issues. This was the scariest situation I have ever been in with a car mechanical issue. Note: We were ~120 miles into the 160mile trip. The OAT temperature was ~45 degrees. Trans temp showed 250 degrees when acting up, and dropped to 220 by the time the trip ended. Odometer shows ~77k. CPO, dealer maintained.
While overtaking another vehicle on the interstate at 75 mph, a loud clunk was heard and drive power was temporarily lost as the car slowed by 20 mph. The transmission subsequently reengaged, enabling the vehicle to regain speed. At that time, there was no traffic behind. No warning lights appeared, and the dashboard gauge indicated normal transmission temperature. The transmission fluid had been changed approximately 5,000 miles earlier during the 100,000-mile service. Since this event occurred late Friday afternoon, I was unable to contact the dealer.
I am writing to bring attention to what I believe is a serious and ongoing issue related to the design of my vehicle’s transmission system. I recently contacted Ford Motor Corp. regarding this matter and was assigned a case number; however, the case was open and closed within a 5-minute conversation. I was informed that there are currently no known issues or recalls related to the transmission in my vehicle. Despite this, there is a problem I continue to experience recurring transmission problems that raise significant safety concerns while operating the vehicle at various speeds. Erratic and unreliable shifting, the transmission often feels like it is “floating” between gears, shifting abruptly, or sometimes not shifting at all. Slipping gear, there are frequent instances many of which I would consider close calls where the transmission slips during acceleration, causing a sudden and unexpected loss of power. These issues make it extremely unsafe to perform routine driving maneuvers such as pulling out from a stop sign into moving highway traffic, crossing busy intersections, merging onto highways, or responding quickly to changing traffic conditions. The inconsistent vehicle response under normal driving conditions puts not only my family, but others on the road, at significant risk. Based on my own experience and further research, I am concerned that this may be a broader, well-documented issue that has not been adequately addressed by the manufacturer. The ford dealerships are aware of this problem and are so inundated that the current dealership cannot even see my vehicle for over a month and i am told have parts delay due to the repair demand. Given the nature and potential danger of these transmission problems, I respectfully urge a thorough investigation into this matter. Thank you for your attention to this serious concern.
Transmission losing power while driving. This is a known safety hazard with this 10R80 10 speed transmission with a poorly designed CDF drum. Ford chooses to wait and hope for power train warranty to expire so can be fixed at customer’s expense. This is a safety issue. If I was entering a roadway and needed to accelerate and car had no power, a terrible accident could happen.
Transmission exhibits harsh shifting and slippage. One scary example is when accelerating at highway speeds, transmission will occasionally and suddenly drop into first gear causing complete loss of power to the wheels. On occasion will also display transmission warning on dash and lock into 4th gear, causing vehicle to exhibit downshift breaking and rapidly slow vehicle when in traffic at highway speeds.
While driving on the interstate (I-35) and attempting to pass a vehicle, the transmission went out of gear and felt like it was in neutral for a few seconds and then ‘clunked” back into gear finally. This happened 4 times that day. This happens almost every time we go on a trip with this vehicle and is extremely dangerous to my family as well as other drivers. This seems to be a common issue with this model/year. It’s been reported to our dealer multiple times and they attempt to reprogram but doesn’t change anything. They said there’s no other fix. I have extended warranty.
Transmission has exhibited harsh/delayed engagement and/or harsh/delayed shift during lane changes, almost causing me to crash on two occasions.
Ongoing problem already had 2 repairs done to transmission. Gears o not shift properly when the gears go from 3-4 and 6-7. If I am not careful when I press on the gas and try to accelerate it does not shift gears and gets stuck on and my truck will not move more than 5-10 mph while I am trying to get on the highway at times with trailers coming full speed ahead behind me. I have reported this issue many times. There has been no remedy. The gears get stuck and make a jerking motion and movement causing truck to slow and barely move. It is not just a one time thing so I cant give a specific date as it happens often.
Recall issue with Catalytic converters causing check engine light to come on. I took in for recall to reset check engine light. Repair did not do anything to vehicle as check engine light comes on for a few days and goes away for a few days and the cycle repeats up until this day it continues to happen. When they did the reset Ford let me know that they reset the check engine issue for recall but I would have to pay about $5k for getting new converters if I wanted to because light would still be one since it was diagnosed that converters were bad.
We own a Ford Expedition 2020. In 2023, we started noticing jerky, harsh, and aggressive “slips” when the vehicle was trying to change gears - upon multiple occasions. But, in 2024, we experienced three, major, different instances - all were extremely scary and it was miraculous they didn’t cause accidents, car pile ups, or worse! The first instance, the vehicle jerked and sputtered just as I was pulling out into a busy intersection. I thought it was going to die in the middle of the road. The second instance, several weeks later, it happened, again, as our family was driving in pouring rain down the interstate; it jerked so hard it felt like we hit a small wall. The third and final instance, we were on our way to vacation - 9 hours away with our family. It sputtered, jerked, and laid in 1st gear. Thank God, we were right at a hotel and able to pull in. We found a local mechanic to take the Expedition in and begin work on it. He was so kind to loan us his car to take on to PA to the Sight & Sound Theater so we wouldn’t lose our money on the tickets. We ended up losing 2 full days of our 4 day vacation; had to rent a vehicle to drive back home; and left our Expedition in VA for 6 weeks while they rebuilt a transmission and cleaned the catalytic converter. $12,160 to the mechanic + $1000 in car rentals. Here we are, now in August 2025, and there’s been a recall on the Powertrain Control Module and that’s being replaced. Lo, and behold, what does the PCM do? It acts as the vehicle’s main computer, managing and controlling various engine and TRANSMISSION functions (adjusting engine parameters like fuel injection, ignition timing, and transmission shift points) - imagine that!
The contact owns a 2020 Ford Expedition. The contact stated that while depressing the accelerator pedal, the vehicle failed to respond as intended and the vehicle lost power. A dealer was contacted. The vehicle was taken to a dealer to be diagnosed; however, the diagnostic result was not provided. The vehicle was not repaired. The manufacturer was not notified on the failure. The approximate failure mileage was 106,000.
Driving and transmission gear bumping hard when shifting gears. Have pulled out twice to pass and transmission made hard bump and I could not go anywhere. The last time this happened was 7/29/25 and it made a lot of clanking noise and the faulty light came on. I let off the gas and it went back in gear and I made it home and have not drove it since. Ford dealership said there was no recall on transmission but I have read alot of complaints from other 2020 Expedition owners about this problem I have 70,000. plus miles and have taken extreme care of this vehicle.
Failure of transmission, leading to unsafe operation on roadway.
Info sent to Ford in working with cust service w/o action: Our 2020 Expedition had 4 separate instances of slipping out of gear during a road trip (2 instances on 7/11 and 2 on 7/19). During each incident, the vehicle slipped gear at highway speed, RPMs maxed out on the dial, lost all acceleration and significant speed, and the vehicle remained unresponsive for several (3-5) seconds until finally accelerating after the unresponsive period. It goes without saying that completely losing gear at highway speed while navigating traffic is a serious life and safety issue. Having that occur four times on a single round trip presents unreasonable risk. We documented the mileage and engine conditions by taking a picture of the dash after recovering from each occurrence. Those details were shared with the Krieger Ford service center on 7/22. That Ford service team was not able to recover fault codes from this information. Without being able to identify a root cause based on lack of fault codes, Ford Service performed a transmission relearn on 7/22. The service team confirmed this step is an initial measure due to lack of codes and not being able to see inside the sealed transmission. Abandoning further assessment in favor of a potential but unlikely quick-fix may be appropriate with an inconvenience issue, but not acceptable on one with such serious consequences. I recognize that further assessment will require additional cost. The assessment cost relative to the risk associated with not properly addressing the root cause of this dangerous issue is clearly justified. I’ve previously communicated this same situation to Ford when it occurred on a road trip in July of 2024. We contacted the dealership (Germain Ford of Dublin) and were deferred multiple months due to Ford's transmission tech backlog. The codes were not available by the time a service appointment was open. Without error codes and a single occurrence at that time, Ford service was unable to investigate further.
Hard downshift, loss of power.
The contact owns a 2020 Ford Expedition. The contact stated that while driving at various speeds, the vehicle failed to accelerate properly while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to a dealer; however, the dealer failed to duplicate the failure. The contact stated that after several visits to the dealer, the dealer acknowledged the failure, and a valve body replacement was performed. The contact stated that the failure returned, and the failure became more frequent. The vehicle was taken to a dealer, and the ignition coils and spark plugs were replaced. The vehicle was valeted back to the residence, and the valet informed the contact that the failure was still present. The valet brought the vehicle back to the dealer, where it remained. The vehicle was diagnosed with a defective transmission, and the contact was informed that the vehicle was no longer covered under warranty. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 60,000.
The contact owns a 2020 Ford Expedition The contact stated while depressing the accelerator pedal, the vehicle failed to respond as intended. The contact stated that the gear shifter operated independently. A dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was notified on the failure and transferred the contact to the federal safety agency Hotline to report the failure. The approximate failure mileage was 127,000.
See attached document for complaint.
On several occasions the engine has slipped/stalled. Vehicle has only 27k miles on it, single owner. When moving from a stoplight the engine "slipped", all lights came on "service alert" or something similar. Vehicle recovered but I am very uneasy as I am a [XXX] female usually [XXX] and often on a very busy section of [XXX]. (This has occurred multiple times) When increasing speed, as to pass a vehicle or otherwise, vehicle is unresponsive or lags. To be clear this happens at speeds of 40-50 mph. It is unpredictable when this will occur nor why. I will likely sell this vehicle due to this safety issue. I spoke with a service rep at the local ford dealership who was able to look into the vehicle computer remotely but there was no record of the "Alert" or otherwise. I took the vehicle to my local mechanic who drove it and was able to replicate the danger/slipping. I was advised to do "zip code" driving only. I believe this "engine slipping" is related to the Recall just issued except the 2020 Ford Expedition is not included in this recall. Others have noted this issue as well with the federal safety agency. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
What component or system failed or malfunctioned, and is it available for inspection upon request? The Powertrain Control Module (PCM), which manages engine-transmission communication and regulates cooling system performance, malfunctioned, resulting in a cascade of related failures: Transmission system: Delayed shifting, hesitation, and eventually a “transmission stuck in park” code. Cooling system: Repeated overheating that led to a ruptured radiator. These issues stem from the faulty PCM referenced in Ford Recall 24E13, issued on April 25, 2025. Yes, the failed components remain in the possession of Harbin Motor Company in Scottsboro, AL, where the vehicle is still located. The vehicle has not been repaired and is available for inspection upon request. How was your safety or the safety of others put at risk? This vehicle was operated while exhibiting documented powertrain and overheating symptoms—including while transporting children. Harbin Ford repeatedly instructed continued use despite: Diagnostic scans on April 10, 2025 confirming PCM-related failures including “transmission stuck in park” and overheating. A coolant leak that occurred without warning lamps, leading to the radiator bursting. These failures put occupants at serious risk of breakdown or fire, especially in high-traffic or high-temperature driving conditions. Operating a vehicle with a malfunctioning PCM increases the likelihood of gear slippage, sudden deceleration, or complete transmission failure. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The issue has been repeatedly confirmed by Harbin Motor Company, an authorized Ford dealer: On April 10, 2025, a scan identified “transmission stuck in park,” overheating, and a third unidentified code. On May 15, 2025, the service manager Craig Davis confirmed the transmission had an internal issue requiring a full rebuild and located a coolant leak. These confirmations were documented via servi
I’ve owned my 2020 Ford Expedition for just over a year. Initially, the transmission performed flawlessly. However, over time I’ve noticed a few concerning issues: At low speeds, the transmission shifts very hard. While accelerating at interstate speeds, it feels like the transmission is slipping. When I shift the vehicle into gear, it makes a loud clicking or knocking sound.
I was driving pulling off an exit incoming to a highway that needed me to speed up to catch a 65 MPH traffic while I was going 35MPH the car while on D for drive somehow engine REV went up to 5500 RPM no power to drive vehicle slow down to 30MPH and all of the sudden a Violent engine and all the body clunk as if another gear or Park all of the sudden! Tires stop spinning as you can hear tires screeching and this lasted a second and then transmission caught up again and started to accelerate again normally. We were almost hit from a moving truck behind us with 3 small kids in the car! This already happened 3 separate times while we are out traveling out of our hometown. 98 degrees outside dry conditions flat surface in Florida Got it all on Dash Camera on VIDEO and Audio Hope to get this fixed before someone gets KILLED!
Transmission hesitated when entering traffic almost causing accident. This is not the first time this has happened. After the first incident I addressed the issue with the service manager. He said it’s common that this model transmission shifts rough, and has some hick ups but, nothing to worry about. It also randomly shifts into neutral randomly.
The transmission is consistently hesitating to switch gears, very jerky gear shift, and will sometimes completely fall out of gear. You could so easily lose control if this happened on the highway. Thank goodness we weren’t on a busy street. This isn’t the first reporting according to a simple search online and there should be a recall for safety reasons. This could be life or death for someone driving on the highway.
The contact owns a 2020 Ford Expedition. The contact stated while driving 40 MPH and attempting to overtake a semi-truck, the vehicle shuddered, lost motive power, and made an abnormal clunking and winding sound. The contact stated that the failure had occurred several times while driving and depressing the accelerator pedal and while driving from a complete stop. The check engine warning light was illuminated. The vehicle was taken to the dealer; however, failure could not be duplicated. The contact stated that the failure reoccurred. The vehicle was taken to Krapohl Ford (1415 E Pickard St, Mt Pleasant, MI 48858), where the transmission shifter cables were reset through a computer update; however, the failure persisted. The vehicle was taken back to the dealer, where the cause of the failure could not be determined; however, the dealer recommended the transmission be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2020 Ford Expedition?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history