The contact owns a 2021 Ford Expedition. The contact state while driving 55 MPH, there were abnormal sounds coming from the engine and the transmission. The temperature gauge warning light was illuminated. The vehicle was taken to a Chevrolet dealer twice to be diagnosed. The contact was informed that the transmission needed to be replaced. The transmission was replaced, and the vehicle was repaired. After the second repair the contact noticed that the engine was overheating. The vehicle was taken to a Ford dealer and the transmission was replaced another time. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 89,035.
2021 Ford Expedition transmission complaints
Page 4 of 5: complaints 71 to 100 of 114, newest first, as owners wrote them.
The contact owns a 2021 Ford Expedition. The contact stated that while driving at various speeds, the vehicle would hesitate upon the depression of the accelerator pedal without warning. During one failure, the contact shifted the vehicle from drive(D) to park(P) and the vehicle began to roll backward as though the vehicle were in neutral(N). The contact then shifted the vehicle back to drive(D) and the vehicle resumed normal operation. The vehicle was taken to a dealer where the contact was informed that the only way to diagnose the problem would be to duplicate the failure. The manufacturer was also notified of the failure and the contact was given the same information as the dealer. The contact was then referred to the federal safety agency Hotline to file a complaint. The vehicle had yet to be diagnosed or repaired. The failure mileage was approximately 41,000.
When stopped, the auto start stop comes on and the engine turns off. Suddenly a warning comes on and says that the vehicle has to be put in park and push the start button to start the engine again. It will not start automatically when the brake pedal is released. This has happened a number of times. I have not been to the dealer.
At 40,000 miles Transmission skips gears going from 3-4 4-5 and 7-8. Transmission jolts hard when put into reverse. Valve body was replaced which fixed the issue for a couple of months and now the same issues are occurring.
Transmission slams into gear when coming out of park, into drive
The Powertrain control system has detected an internal PCM communications error PCM will invoke failure mode effect management.
Shifting from park to drive on a level surface, the transmission will sporadically slam into gear so hard that the vehicle lurches forward. By the time I got to the dealership, it would not duplicate the problem. This vehicle has had the transmission rebuilt/replaced 4 times for this issue (among other issues), and there is less that 40,000 miles on the vehicle. The transmission also slams into gear on 3rd, 5th, and sometimes 6th (upshift and downshift). It will sporadically downshift when at highway speeds regardless of changes in speed or incline.
The power train failed to accelerate and completely disengaged. While trying to avoid being t-boned by another car, the vehicle failed to accelerate when required. The RPM gauge showed the acceleration demand but it did not transfer to the power train. Luckily the car running the red light swerved to miss us because we were not able to proactively avoid the collision. Ford first replaced the transmission plate, after recurrence is now offering a transmission rebuild under warranty. Now out of warranty, concerned issues will continue as Ford dealer not forthcoming on the repairs being done stating multiple issues are not related.
Expedition has roughly 33,000 miles on it. I took it into the dealer for service b/c the transmission was acting jumpy. By the time it got to the dealer for service, Pacifico Marple Ford deemed it undrivable and it needs a new transmission. I don't think the transmission should have went that quickly.
The transmission in this vehicle has been consistently needing repair. It is available for inspection. Concerned transmission will fail and leave family stranded. The problem has been reported to the dealer and the manufacturer 8 times over the past two years and they are still unable to fix the transmission. The vehicle has also had error messages about the problem.
The contact owns a 2021 Ford Expedition. The contact stated that while at a four-way stop, the vehicle failed to move, and downshifted to first gear. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was contacted and referred the contact to the federal safety agency Hotline. The failure mileage was approximately 115,000.
It started with transmission issues and has since been nothing but trouble. Car has been in and out of shop, now the ac is out. Ford takes no accountability
When driving at interstate speeds, the transmission locked into 7th gear and refused to change gears with changes in speed. This was especially dangerous when I exited the interstate and had to drive in traffic at city speeds. Starting from a stop in 7th gear was extremely dangerous and made me a hazard to myself and other cars around me.
Vehicle loses acceleration. When I attempt to pass someone on the interstate, the vehicle does not accelerate. When I push the gas the engine revs, but does not engage. I have to take my foot off the gas for 10-15 seconds for it to go back into gear. Error reads "stuck in park". It has been to Ford numerous times with the same result, they can't duplicate the problem.
Transmissions quickly break down. First signs are hard/loud gear shifting followed by slipping gears then eventual inability to accelerate. Regular transmission drains find metal contamination indicating breakdown of gears. Ford Motor Company is aware of this issue and will replace the transmission with the same failing transmission. Their proprietary system makes it difficult to diagnose and repair leading consumers to have to buy a replacement after 60k miles (which just so happens to be the extent of their warranty).
The contact owns a 2021 Ford Expedition. The contact stated that while driving at various speeds, there was a grinding sound coming from the transmission while changing gear. The contact stated that the failure had occurred while upshifting from second to third gear and while down shifting from fifth to fourth gear. During the failure the vehicle experienced hard jerking. The vehicle was later towed to the local dealer who diagnosed that the transmission was faulty and needed to be replaced. The vehicle was not yet repaired. The VIN was not available. The failure mileage was 20,000.
When driving down the road and it does not matter what speed I am going, is when this issue is happening to most. I will be driving and out of the blue the tachometer will just drop to zero (0) and I lose all power and the vehicle starts shaking vigorously back and forth until it decides what gear the transmission wants to be in. It is doing this every single day, and it almost made me wrecked the other day. I do not even have 70,000 miles and it will be three years old in April 2024. I have called Ford and reported the issue as well. I have researched the issues, and many other Expeditions are having the same issue years 2020-2022. I am asking for Ford to take a serious look at all the car crashes from this exact issue. I do know the F150 are recalled with the exact transmission that is in the Expeditions. The transmission on Thursday 2-22-24 after driving and parked, put the car in drive then it did not want to get out of parked and do into drive or reverse.
I keep getting a hard transmission shift around 8th gear when cresting a hill and letting off the gas. Ford can’t replicate the issue because it’s intermittent.
The transmission is a major issue. I have had it in the shop 3 or 4 times now and still experiencing issues. The vehicle goes in and out of gear, doesn’t always accelerate when giving it gas, jerks when slowing down/downshifting. Makes a loud noise during downshifting at times, and the list goes on. Ford knows there are problems and refuses to address the issue, applies a computer update to bandaid the issue, and sends customers on their way to only be faced with the issue a short time later.
My car has stopped accelerating in the middle of a highway going 75 and wrench light pops up. Ford is looking into it but apparently it needs to be recalled. I hope they extend my warranty. This is so scary. My kids and I almost suffered an accident as our car stopped in the middle of passing on the freeway
I own the 2020 Expedition. We were traveling on Interstate 287 yesterday. I was in the right lane and was stuck behind a slow moving semi-truck. I put on my blinker and waited for an opening in traffic to move into the middle lane. When an opening presented itself, I pressed down on the gas pedal to accelerate into traffic. While the truck should have down shifted and accelerated, instead the powertrain completely disengaged; a total loss of power. The RPM jumped way up to redline, over revving, but the truck was slowing down. I took my foot of the gas pedal and as the RPM came back down, the transmission slammed back into engagement with a loud audible clunk that jolted the whole vehicle. At this point, I was finally able to accelerate. While this was all happening, I had just moved into the middle lane of traffic, which was bearing down on us. All the vehicles behind us were slamming their brakes and honking their horns. I thought for sure we were going to die. Thank God it wasn’t an 80,000 lbs Peterbilt bearing down on us, or we would be dead, by the grace of God we’re not. Upon returning home I went onto the Ford truck owners website I belonged to. I came to learn this is a known issue with Ford’s 10-speed transmission that Ford has failed to address. That there are pending lawsuits and that the federal safety agency is aware of the issue. One of the member suggested that I file a complaint with the federal safety agency, that was my impetus for writing you today. This is a dangerous condition that Ford needs to remedy.
The contact owns a 2021 Ford Expedition. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to coast to the side of the roadway, and after restarting the vehicle, the vehicle returned to normal functionality. The contact stated that the failure had since become a persistent failure. No warning lights were illuminated. The vehicle was taken to the dealer but was not yet diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 43,000.
After owning the car a year and about 15,000 miles I started having transmission rough shifting and lurching motions when shifting - violent lurching. I took it in to the dealership and they reset the adaptive learning component for the transmission. Nothing changed. Brought it in again and drove with technician and was able to reproduce issue. They replaced the transmission and the problems continued and actually increased with losing all acceleration on the freeway (floppy pedal) and then completely losing 10th gear when trying to pass another car. Luckily I was able to pull over and I did not cause an accident. It also threw a code/warning light at that time. I took it back to the dealership. They assessed and reset adaptive driving module. It then lost accelleration and wouldn't engage 10th and started smoking. Took it back to dealership and they claimed all that was due to over full transmission fluid. Original problems of rough shifting, lurching, clunking still existed. I filed a report with Ford and got a case number with the concern department. This resulted in the rear end of the car being replaced??? Car still has transmission issues, with all the above mentioned issues, and now delayed acceleration in the lower gears. Enough is enough fighting about fixing it for a year, it has been in for repairs 7 times, and over 49 days of rental cars . The vehicle does not cause warning lights at any point with the rough shifting, lurching, or lack of acceleration. All have been experienced at various times by the dealership. No solution to date.
I’ve been having issues from day one with shifting gears, the vehicle makes a loud “thunking” noise and practically stops my vehicle in the middle of the road
Transmission is slipping and hard shifting or fails to shift. I noticed it at hot temperatures but does it now constantly. Airbag is starting to come out of the perforation below the Ford symbol on the horn. I'm concerned it will deploy while driving and cause a traffic accident/injury/death.
The 10R80 transmission, even after rebuilt by the dealership continues to shift in unexpected ways (hard shifts, not picking the right gear, hesitation under acceleration). It doesn't happen all the time, and isn't reproduceable at will. When the problem occurs, it is very noticeable. The vehicle will hesitate and not accelerate when pushing on the gas pedal, and then all of a sudden jump forward unexpectedly. The dealership has examined it after the transmission was rebuilt, and states that it is operating normally, but we were unable to duplicate the problem at that time. The next day, it happened again while driving on the highway when merging into traffic. Pressed on the gas pedal, but the car did not accelerate as expected (long hesitation), and then the transmission decided to change gears, and experienced hard shifts to the point the whole car jerks abruptly (this was NOT because of extreme pressing of the gas pedal). Just normal pressure on the gas pedal, and it will randomly decide how it will shift.
The contact owns a 2021 Ford Expedition. The contact stated while driving 80 MPH, the vehicle began to shake forcefully. The contact stated that the check engine warning light was illuminated before the vehicle stalled. The contact was able to park on the side of the roadway, restart the vehicle, and continued driving. The contact took the vehicle to the local dealer who was unable to duplicate the failure. The contact continued to experience the failure within 24 hours. The contact took the vehicle back to the local dealer, where it was diagnosed with needing the fuel injectors to be replaced. The vehicle was repaired but experienced the failure a third time. The contact stated the catalytic converter, and the transmission warning lights were illuminated. The contact took the vehicle a third time to the local dealer, diagnosed, and it was determined that the catalytic converter and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was unknown.
10-Speed transmission frequently shifts hard, and sometimes misses a shift entirely resulting in no power for a few seconds while the transmission tries to "find" the right gear. This has occurred in busy intersections which obviously presents a major safety risk. Awkward shifting started about 2 months ago, complete loss of power has occurred 3 times in that time period. Vehicle is currently sitting in a Ford dealership service department awaiting diagnoses and repair since 5/29/23.
Severe transmission slippage/failure at all speeds. Gear disengages randomly during acceleration. No Ford dealer wants to take the responsibility to repair or fix it. Per the dealers, the computer doesn’t log the occurrences. Hard to believe that and hard to believe there is a major class action lawsuit in CA regarding this.
The contact owns a 2021 Ford Expedition. The contact stated while driving 25 MPH, the vehicle lost motive power with a messaging to restart the vehicle being displayed. The contact restarted the vehicle and the vehicle started operating normally. The vehicle was taken to the dealer and the dealer stated that no failure was found. On another occasion, the contact contacted the dealer and the dealer stated that the failure was a known issue however, there was no recall for the failure. The manufacturer was contacted, and the manufacturer stated that the vehicle needed to be diagnosed. The contact was referred to the federal safety agency Hotline to file a complaint. The failure mileage was 4,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Ford Expedition?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history