Vehicle Safety Complaint – 2021 Ford Expedition My 2021 Ford Expedition has experienced longstanding transmission problems, including hesitation during acceleration, becoming stuck between gears, harsh shifting, and rolling backward on hills. Despite numerous dealership visits, the problem was not diagnosed until the vehicle was out of warranty. The transmission was replaced in August 2026, but the vehicle continued to exhibit the same symptoms. Recently, while traveling approximately 20 mph trying to accelerate from left turn out from side street to main road, a dashboard warning appeared referencing "LOW" gear. The vehicle unexpectedly shifted into Park while moving, jolted significantly, and experienced reduced steering capability. I had to repower the vehicle to restore operation. Fortunately, surrounding traffic had stopped, preventing a potential collision. The dealership attributed the incident to Ford recall 26S48 but advised that no remedy is currently available and suggested I continue driving the vehicle. I am extremely concerned about the risk of a serious accident. I am requesting the federal safety agency investigate this incident, particularly given the vehicle's history of transmission failure, recent transmission replacement, and apparent manifestation of the recalled safety defect.
The worst 2021 Ford Expedition problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Transmission114
- Engine61
- Electrical25
- Visibility23
- Fuel system14
- Acceleration11
- Body11
- Brakes6
- Driver assistance6
- Seat belts4
- Airbags3
- Lights2
- Steering2
- Locks1
- Seats1
- Suspension1
Specific symptoms reported on the 2021 Ford Expedition
Harsh shifting 32Transmission failure 28Jerking 24Loss of power 19Stalling 13Slipping 12Check engine light 11Fuel pump 10Wipers 9Hesitation 8Backup camera 7Grinding brakes 7Won't shift 6
Recalls 12
Power train: automatic transmission
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
- Risk
- Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
- Remedy
- Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on on June 26, 2026.
Recall number 26V402000 · Recall details
Structure: interior panels: center console
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2018-2024 Expedition vehicles. The chrome plating on the center console may bubble and peel, resulting in sharp edges.
- Risk
- Vehicle occupants may contact the center console's sharp edges, increasing the risk of injury.
- Remedy
- Dealers will inspect and replace the center consoles as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 16, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 26S38. Vehicle Identification Numbers (VINs) involved in this recall became searchable on on June 10, 2026.
Recall number 26V368000 · Recall details
Seat belts: pretensioner
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2018-2022 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
- Risk
- Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
- Remedy
- Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 8, 2026. Additional letters will be sent once the remedy is available, anticipated in August 2026. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 26S34. This recall replaces and expands previous the federal safety agency recalls 24V099 and 25V197. Vehicles previously inspected or repaired under the prior recalls will need the new repair completed.
Recall number 26V344000 · Recall details
Visibility: windshield wiper/washer: linkages
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.
- Risk
- Windshield wiper failure can reduce visibility, increasing the risk of a crash.
- Remedy
- Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on on April 1, 2026.
Recall number 26V204000 · Recall details
Visibility: sun/moon roof assembly
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
- Risk
- A detached wind deflector can become a road hazard and increase the risk of a crash.
- Remedy
- Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on beginning October 30, 2025.
Recall number 25V729000 · Recall details
Back over prevention: software
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
- Risk
- A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
- Remedy
- Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 25S72.
Recall number 25V442000 · Recall details
Back over prevention: sensing system: camera
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2021 Expedition, 2021-2022 Super Duty F-250, F-350, F-450, F-550, F-600, and 2020-2022 Lincoln Corsair vehicles. The rearview camera may display a blank or distorted image.
- Risk
- Rearview camera failure can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
- Remedy
- Dealers will replace the rearview camera as necessary, free of charge. Owner notification letters were mailed September 18, 2025. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 25S05.
Recall number 25V048000 · Recall details
Equipment: other: labels
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
- Risk
- Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
- Remedy
- Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 24C39.
Recall number 24V852000 · Recall details
Equipment: other: owners/service/other manual
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
- Risk
- Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
- Remedy
- Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 23C20.
Recall number 23V420000 · Recall details
Engine
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2021 Expedition and Lincoln Navigator vehicles. An engine compartment fire may occur while driving or parked, even with the ignition in the "Off" position.
- Risk
- A vehicle fire increases the risk of injury.
- Remedy
- Owners are advised to park their vehicles outside and away from structures and other vehicles, until the remedy is performed. Dealers will inspect and replace the battery junction box, as necessary, and remove a ground wire. On models equipped with standard-duty radiator fan motors, dealers will also install an auxiliary electrical box with a wire jumper. Repairs will be performed free of charge. Interim owner notification letters informing owners of the safety risk were mailed May 25, 2022. Owners will receive a second letter once the remedy is available. Currently the remedy is available for vehicles equipped with heavy-duty radiator fan motors, and those letters were mailed July 21, 2022. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 22S36.
Recall number 22V346000 · Recall details
Visibility: windshield wiper/washer: linkages
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
- Risk
- Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
- Remedy
- Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 22S26.
Recall number 22V250000 · Recall details
Air bags: sensor: side impact
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
- Risk
- An air bag that does not deploy properly during a crash increases the risk of injury.
- Remedy
- Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 21C26.
Recall number 21V805000 · Recall details
See all 12 recalls for the 2021 Ford Expedition
Defect investigations
NU Car rental of vehicles with open recalls
the federal safety agency is opening this Audit Query (AQ) to investigate NU Car Rentals (NU Car) for compliance with the requirements of the National Traffic and Motor Vehicle Safety Act.The Safety Act requires that a rental company shall not rent a vehicle subject to a safety recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i). the federal safety agency is in receipt of information that indicates NU Car rented at least two vehicles to consumers without having performed required recall repairs. The Vehicle Owner Questionnaires (VOQ) related to this investigation can be found on by searching for ID number 11730449 and 11504655. Accordingly, we are opening this audit query to seek additional information concerning this issue.
AQ26001
Technical service bulletins for the 2021 Ford Expedition 142
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- New vehicle delivery hold
- For Various Ford and Lincoln vehicles, if diagnostics lead to the replacement of the front seat cushion...
- "Updating SYNC" message on the vehicle center display screen after an over the air (OTA) update
- New vehicle delivery hold
- For 20212026 vehicles equipped with the 10R80 transmission, a new Transmission Clutch Circuit Leak Test...
- Various 2020-2026 Ford and Lincoln vehicles equipped with blind spot information system (BLIS) may...
- Advance Notice – Customer Satisfaction Program 25N17 Certain 2015-2025 Model Year Multiple Vehicle Lines...
- For 2021-2026 vehicles equipped with the 10R80 transmission, a new Transmission Clutch Circuit Leak...
- Various connectivity concerns with The Ford App Lincoln App including but not limited to: missing...
- Special Field Action 25L02 Certain 2017-2024 Model Year California Emissions-Certified Vehicles...
2021 Ford Expedition fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 3.5L 6‑cyl | RWD | 17 | 23 | 19 |
| 3.5L 6‑cyl | 4WD | 16-17 | 21-22 | 18-19 |
What 2021 Ford Expedition owners say
Most recent owner complaints, unedited.
I was making a right hand turn and had loss of power and a clunk sound. I also experienced loss of power between 65-75 mph on the freeway. I ran a forscan report and it's pointing to the transmission even though the fluid and a tcm update has been performed. There is about 40k miles on the fluid.
The chrome plating on the interior center console trim is bubbling, wrinkling, cracking and peeling along the console edges, including the vertical corner by the cupholder, leaving sharp metal edges. This vehicle is covered by Ford recall 26S38 / the federal safety agency campaign 26V368 for this exact defect, but no remedy is available (remedy expected Q1 2027) and Ford has provided no interim cover, guard, repair, or instructions to make the sharp trim safe. Two injuries have occurred from the sharp peeling chrome trim: 1. On approximately March 12, 2026, the owner's right pinky finger was cut on the outside of the finger by the sharp peeling trim. It bled heavily, took a long time to heal, and left a permanent scar. No medical treatment was sought. No crash. 2. On October 15, 2026, the owner's right middle finger was cut on the same peeling trim. It was painful and would start bleeding again when bumped for several days afterward. No medical treatment was sought. No crash. Photos attached show the peeling trim and both injuries. The component is available for inspection upon request.
Power problems and the light was on. I took it to the ford place and they didn’t fix it.
Wiper switch not working for auto, because switch itself is broken. When accelerating to pass a car the transmission skips/slips and car pauses and gas pedal won't work for 10 seconds. Car basically stalls. Could have caused accident if unable to pass or slide back over behind the car trying to pass.
While driving at highway speeds, specifically during sudden acceleration and lane-change maneuvers, the vehicle experiences a severe dynamic mechanical binding event. The transmission briefly forces a sudden "halt" or engine-braking downshift, causing the vehicle to unexpectedly slow down in active traffic before entering a temporary limp mode. This sudden loss of propulsion and unexpected deceleration creates an immediate rear-end collision hazard on the highway. This happened to my wife while merging onto a highway almost causing an accident. Diagnostic and Mechanical Verification: The vehicle was taken to an authorized Ford dealership for evaluation. The dealership officially scanned, verified, and documented diagnostic trouble code P0786 (Shift Timing Solenoid "A" Range/Performance). Following an advanced diagnostic review, the certified Ford technician officially diagnosed a failed transmission park solenoid (parking pawl solenoid). Direct Relation to Active Safety Recall: The component failure (park solenoid), diagnostic code (P0786), and severe dynamic highway-speed binding symptoms are identical to the safety defects outlined in Ford Safety Recall 26S48 (the federal safety agency Campaign 26V402). Reason for Filing / Manufacturer Action: Despite an authorized Ford dealership verifying the exact failure mechanism of this active federal safety recall, Ford Corporate are currently refusing to cover 100% of the repair costs. They state that my specific VIN has not yet been "activated" in their database due to Ford’s phased tranche rollout schedule extending through 2027. I am being forced to pay out-of-pocket for an active, dealer-verified, federally recognized safety hazard. We cannot drive the vehicle with this significant safety risk. I am paying mostly out of pocket to cover the repair.
At approximately 12:10 p.m. on October 5, 2026, we had just washed the Expedition and I was going to move it over to put it in the middle bay of the garage that is attached to the house. I put the vehicle in reverse and it took off like it was going 100 miles an hour. I crashed into the garage behind us and the tires were still screaming. I then put it in drive to pull forward and it screeched the tires going forward. I had my foot on the break and it was roaring;burning rubber, it crashed through the garage door, hitting the Explorer in front of it which pushed into a wall of our house. It was an unexplained prolonged period of engine racing. I have a video that I would like to send you showing everything that happened, but it’s too large to attach.
My 2021 Ford Expedition MAX XLT with the 10R80 automatic transmission has experienced repeated momentary “neutral-out” events while driving. The transmission/park-system components are available for inspection upon request. The most serious incident occurred in September 2026 while I was driving at highway speed near Charlottesville, Virginia, with six children in the vehicle. I was not towing or placing the vehicle under unusual load. The vehicle suddenly behaved as though the transmission had shifted into neutral, the RPM/engagement became abnormal, I heard loud thumping, saw smoke or fumes from the rear of the vehicle, and observed a transmission temperature of 261°F. The vehicle later re-engaged. This created a serious safety concern because I temporarily lost normal propulsion/acceleration capability while traveling at highway speed with other traffic. This problem has previously been confirmed by my Ford dealer. In February 2026, I reported that the vehicle would “neutral out and rev up,” hesitate for several seconds, and then go back into gear. The dealer documented that no diagnostic codes were stored but followed Ford TSB 23-2249. During diagnosis, the dealer found physical wear/damage involving the transmission parking pawl area, rear output shaft, and cam. The transmission was removed and disassembled and multiple park-system components were replaced. The neutral-out condition returned after that repair. In July 2026, I again reported that the vehicle would intermittently neutral out for several seconds and then re-engage. The dealer was unable to reproduce it and again found no diagnostic trouble codes. In September 2026, after the 261°F highway incident described above, the dealer again scanned the vehicle and found no codes and was unable to reproduce the condition during approximately 100 miles of testing. There have been no transmission warning lamps, transmission messages, or
Vehicle has 84,000 miles at it. It started to jerk when putting it into a gear. I thought it was due to the colder mornings no. I was taking the kids to school and It was skipping gears. I was very leary of driving but had no choice. It would not get up to speed the rpms was suffering. I stopped at a parts store to run the code after the warning popped up. When leaving because I was 30 mins from home it jerked when I placed into gear, I was scared to pull onto the 4 lane due to not being able to get up to speed and being in a high traffice area. Very unsafe. Now the vehicle is at the dealership needing a $7,000 transmission and ford will not assist. I am still financing it through a dealer and there is no Goodwill from Ford. This is known issue that they documented.
Both second-row captain’s-chair seat-belt buckle assemblies are separating. The driver-side buckle has separated enough that it will no longer latch, and the passenger-side buckle is beginning to separate in the same manner. These are inflatable second-row seat belts. The vehicle has not been involved in a crash and the restraint system has not deployed. Ford replacement parts JL1Z-7860045-FF and JL1Z-7860044-FF are reportedly discontinued or on indefinite backorder, leaving no available repair for these occupant-restraint failures on a 2021 Ford Expedition. Because both buckle assemblies are showing the same failure, I am concerned this is a common safety defect.
Compare the 2021 Ford Expedition
Expedition vs Chevrolet TahoeExpedition vs Chevrolet SuburbanExpedition vs GMC YukonExpedition vs Toyota SequoiaExpedition vs Nissan Armada
Other model years
19911993199419951996199719981999200020012002200320042005200620072008200920102011201220132014201520162017201820192020202120222023202420252026
Questions about the 2021 Ford Expedition
Is the 2021 Ford Expedition reliable?
Owners have filed 243 complaints about the 2021 Ford Expedition, close to a typical Expedition model year.
What is the 2021 Ford Expedition year score?
The 2021 Ford Expedition scores 65 out of 100 (average). The score compares it with the other model years of the Ford Expedition: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2021 Ford Expedition?
Transmission and drivetrain, with 114 complaints, typically around 65,000 miles. Next is engine (61).
How many recalls does the 2021 Ford Expedition have?
12 recalls, covering power train, structure and seat belts.
Was there a recall on the 2021 Ford Expedition transmission?
Yes, 1 recall: 26V402000. Check your VIN to see if your car still needs the free repair.
What year does the Ford Expedition have bad transmission?
The Ford Expedition model years with the most transmission complaints are 2020 (270 complaints), 2019 (224 complaints) and 2018 (150 complaints).
What gas mileage does the 2021 Ford Expedition get?
Official estimates for the 2021 Ford Expedition range from 18 to 19 mpg combined. The most efficient version (3.5L 6-cyl, RWD) gets 17 city and 23 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Ford Expedition?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history