2014 Ford Expedition problems

Filed Sep 2, 2026 · Tires · 162,749 miles · AR

The contact owns a 2014 Ford Expedition equipped with Cooper Tires, Tire Line: Discoverer AT, Tire Size: 275/55/R20, DOT Number: UTV11R9 4221. The contact purchased four new tires. The contact called Walmart for assistance. The contact became aware that there were large blisters on the sidewalls of the tires. The tire was 80 percent worn. The second and third tires were at 50 and 80 percent worn. The blister was about six inches long. The blister was located on the passenger’s side rear tire; the driver’s side rear tire and the driver’s side front tires had blisters. The contact was able to stick a finger between the blister and the ball joint. The contact was concerned about a blowout. An attempt was made to contact the tire manufacturer, but there was no response. The tire failure mileage was unknown. The vehicle failure mileage was approximately 162,749.

Filed Jun 30, 2026 · Transmission · NC

I bought this 2014 ford expedition. I didn't know at the time the Triton 5.4 had a transmission Lead Frame defect. I asked them to cover it under the federal safety agency 26V237 but they refused because they dsaid it wasn't part of the recall although this vehicle shares the same exact components. I also asked them to cover it under Safety Recall 26S28. I ended up having to pay $1842.00 to get this fixed.

Filed Apr 27, 2026 · Acceleration, Transmission · AL

While driving on interstate at highway speeds (70mph), the transmission experienced sudden downshift, which increased the engine RPMs to redline and rapidly decelerated the vehicle. Occupant safety was put at risk while other drivers were forced to quickly avoid collision due to our much slower speed. Transmission would not select proper gear which made it difficult to proceed to a safe pull-off point. After restarting the vehicle, the situation repeated itself several times while attempting to drive home. Reoccurring problems include rapid deceleration and high engine revs when transmission suddenly shifts at high speeds, or stalling & lack of acceleration when transmission shifts improperly at low speeds (which makes moving the vehicle safely from the roadway difficult). Researching the problem, it appears to be an issue with the leadframe internal to the 6R80 transmission. Apparently there are safety recalls for other Ford SUVs and trucks with the same leadframe part all related to unexpected transmission shifts.

Filed Mar 23, 2026 · Acceleration, Transmission · TX

While driving the truck will shift into 1st gear. It will also shift back and forth between gears randomly. When this happens, the wheels may lock up or just skid. The service engine light will come on, the speedometer will drop to zero while still moving and the "miles to empty" will show at zero miles. Sometime the tire indicator will turn on as well. This may/may not reset when the vehicle turns off and back on. Other times the vehicle will stick in first gear when leaving from a stop. It will also stick in 3rd or 4th gear as well. There have been times where it seems to stick like it was on cruise control but will disengage when the brake it tapped. This all occurs anywhere between a stop position and 50 MPH. The problem has been confirmed by a shop as the "Molded lead Frame" in the 6r80 transmission.

Filed Oct 22, 2025 · Body · UT · crash

Minor side impact. All repairs were make and no issues noted

Filed Sep 15, 2025 · Electrical, Engine · NE

Was driving 80MPH down the highway when instantly the rear wheels locked up, green wrench came on dashboard and my car came to a screeching halt. Complete loss of power, and am VERY lucky it did not create a major pile up on the highway! Had to "bunny" hop it over 4 lanes of traffic and barely survived the most terrifying experience of my life. Had it towed and the mechanic shop said the throttle body/actuator had magnetic problem which is VERY common, ARE YOU KIDDING ME?! But there are no recalls on it, and they had to replace the entire unit, and now I am scared to death to drive the vehicle ever again. I am also very lucky it did not happen on snow, ice, or rain!!!!! SO DANGEROUS and SO SCARY!!!! And I could barely hop it out of oncoming traffic.... How can a vehicle go from 80MPH to ZERO in .02 seconds due to a faulty part and there is no recall???? SO GRATEFUL TO BE ALIVE!!!! Ford needs to take some responsibility before there are deaths from a very simple preventative measure due to a part completely failing. After looking it up online I read hundred's of people having the same issue.

Filed Sep 14, 2025 · Driver assistance · MN · crash

Backup camera intermittently blacks out or becomes distorted.

Filed Jun 18, 2025 · Transmission · NC

While driving at highway speeds very quickly the speedometer went to 0 , the fuel low warning came on , the transmission locked up dragging the rear wheels and engine goes to high rpm , this has happened numerous times , I’ve checked with local ford dealership and they tell me there are no updates for my vehicle , when this situation happens I pull over to the side of the road and shut vehicle off , count to ten and restart , drive away and wait for the next instance. I have read where earlier ford products have had this same issue. One additional item on this unit , it has a sporadic 1.5 amp drain that will kill the battery sometimes , very sporadic. Myself and two others have tried to find this drain but unsuccessfully , took to dealership and $500 later still same issue so I found a electronic battery shutoff with a key fob that disconnects the battery to prevent battery draw , but doing this prevents codes from storing , I have recently started leaving vehicle hooked up to automatic tricle charger to prevent battery from being drained so I can get codes stored up for dealership to troubleshoot at a cost to me off $150 to plug up and read codes. Does that come with lube or will that cost extra ?

Filed May 12, 2025 · Engine, Transmission · 148,000 miles · IL

The contact owns a 2014 Ford Expedition. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted. The contact stated that the check engine and Advancetrac warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the transmission lead frame needed to be replaced. The contact researched and was became aware of an unknown recall; however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 148,000.

Filed Apr 11, 2025 · Electrical, Visibility · 212,000 miles · MI

The contact owns a 2014 Ford Expedition. The contact stated that while driving 55 MPH, the contact noticed an abnormal burning smell while the blower motor was engaged. There was no warning light illuminated. The contact stated that the failure was related to a recall that did not include the year of the vehicle. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and informed the contact that the VIN was not included in a recall. The failure mileage was approximately 212,000.