Vehicle has roughly 64,000 miles on it. As we were actively driving, vehicle suddenly lost power and completely shut off. This was a sudden stall. Vehicle would not crank back up but starter would engage. Upon scanning the trouble codes, multiple codes came up in regard to the fuel pump issue that is currently under investigation. (P008A, P00C6, P0304) This issue poses a serious risk as while actively driving, could cause an accident and should be an active recall for this year make and model.
Ford Expedition fuel pump problems
130 of the 9,415 owner complaints about the Ford Expedition describe fuel pump failure, most of them for the 2007 model year.
- owner complaints
- 130
- worst model year
- 2007
- typical repair cost reported
- $1,000
- typical mileage
- 105,000
Is there a fix? There are 4 recalls for this area of the car. See below
By model year
Often reported together
Stalling 45Won't start 24Loss of power 16Check engine light 15Power steering loss 12Engine failure 6Wipers 2Transmission failure 2
Trouble codes mentioned
P0231 3P0627 2P00C6 2U0109 1P0304 1P025A 1P008A 1
What owners say
While stopped at a traffic light, my 2021 Ford Expedition began running rough. When the light changed and I accelerated through the intersection, the vehicle experienced a severe loss of engine power and barely made it through the intersection. After I pulled off the roadway and released the accelerator, the engine stalled. I was able to restart the engine once while applying approximately one-quarter throttle. It continued running rough and stalled again when I released the accelerator. The vehicle was taken to Robinson Brothers Ford/Lincoln in Baton Rouge, Louisiana. The Ford dealer documented the rough running, low power and stalling and diagnosed the "fuel pump inop." The dealer removed the fuel tank and replaced the fuel pump/sender assembly. The replacement part listed on the dealer invoice is Ford part JL1Z-9H307-G. Vehicle mileage was approximately 79,390. Several months before the complete failure, during very cold weather, I also experienced one brief incident of unusually low engine power shortly after starting the vehicle. I do not know whether that earlier incident was related. I am concerned that this failure may be related to the low-pressure fuel pump failure condition addressed by Ford Safety Recall 25S75 / the federal safety agency Recall 25V‑455, which includes certain 2022 Ford Expeditions. My 2021 Expedition is not currently included in that recall. The loss of power occurred while I was crossing an intersection and created a serious safety risk. I am submitting this complaint so the federal safety agency can evaluate this fuel pump failure along with failures involving other vehicles excluded from Recall 25V‑455.
This vehicle has 70K miles and the fuel pump died, confirmed by Dick Smith Ford in Columbia, SC. There were no warning lights or messages via our Ford app. There were no symptoms prior to failure. The vehicle just died in the middle of the road on a train track with our family in danger. We could have been hit by cars behind us or stuck on the train track with a train approaching. We were in the middle of the road on a train track in Columbia, SC, 2.5hrs away from our home. Our family waited 2.5hrs for the vehicle to be towed and then had to take a $200 Uber from Columbia, SC to Charleston, SC to get home. The quoted cost to repair the vehicle just to get it back home is $2,000. Ford has recalled all the Ford trucks for 2021 that use this same engine. Ford has recalled the 2022 Expedition which is identical to the 2021. Ford has recalled the 2021 Lincoln Navigator that is the same platform as the Expedition only aesthetically upgraded. I believe they didn't recall the 2021 Ford Expedition due the the volume of cars that would be recalled.Â
While driving on the highway, my 2022 Ford Expedition suddenly lost acceleration. The gas pedal stopped responding completely and the vehicle gradually lost power until it shut off. It had to be towed and the battery was fully drained afterward. It was later diagnosed as a fuel pump failure. This was a sudden loss of propulsion in traffic and created a serious safety concern. Police pulled over and were able to get me towed to the nearest safe stop as my car stopped on a bridge with no shoulder.
Down to 3 gallons gas stopped and added to half a tank. Left vehicle running while filling. Pulled out of gas station and vehicle started to sputter, drove 50 more feet and vehicle died and would not restart. Confirmed unleaded and station had no reports of bad gas. Towed to repair facility where dead fuel pump was diagnosed and replaced. Ford recall 25S75 includes some 2022 expeditions but not this 2021 with only 43,000 miles and no previous issues.
My vehicle shutters like it’s is going to die/shit off. When will this issue be resolved with the fuel pump system failure? I will be doing some research with the BBB to find out if this will be an actionable lawsuit. Most consumers who own these types of SUVs are mothers! This needs to be resolved asap!
Ford has a recall on the low pressure fuel pump but no fix yet. My fuel pump failed and I am being charged to fix it. But that also puts me back on the road with an unsafe vehicle. They will not provide me a rental until the recall has a solution or fix.
My truck stopped working in November 2025. I was told I needed fuel pump and filter. I replaced those and still didn't crank. I was then told I needed a circuit box. Purchased a circuit box and had it put on. Got my truck back February 2026. March 08,2026, truck went out again. I kept my truck maintenance and don't understand what's going on with it. I was told it is a recall on electrical parts and engine coils and spark plugs.
Low fuel pump pressure please can you fix it recall on this vehicle it’s been over 7 months I been waiting and no parts is available please let me know when will be available July 2026? Or longer?
The contact owns a 2019 Ford Expedition. The contact received notification of the federal safety agency Campaign Number: 25E070000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the transmission was slipping while driving and shifting into gear, and an unknown warning light was flashing. Additionally, the contact stated that while driving at various speeds on uneven pavement or over a minor bump in the roadway, the rear of the vehicle was jumping and the vehicle became slightly unstable, causing occupants or items in the rear passenger’s seats to bounce. Additionally, the contact stated that the vehicle made an abnormal rattling sound at start-up. The contact stated that the fuel pump was only pumping fuel at 33% and DTC: P00C6 was retrieved. The vehicle was taken to the dealer, where it was diagnosed and determined that the timing chain was stretched, and the valve cover was leaking. Additionally, the vehicle was diagnosed with the left catalytic converter, rear shocks and struts, timing chain, valve covers, fuel pump, and transmission failures. The parts were replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 105,000.
Related recalls
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
- Risk
- An engine stall increases the risk of a crash.
- Remedy
- Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 25S75.
Recall number 25V455000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2018 Ford Expedition, F-150, and Lincoln Navigator vehicles equipped with 3.5L GTDI V6 engines. These vehicles have high pressure fuel pump assemblies with welds that can fracture, which may cause an oil or fuel leak.
- Risk
- A fuel leak in the presence of an ignition source may increase the risk of a fire.
- Remedy
- Ford will notify owners, and dealers will replace the high pressure fuel pump and associated components, free of charge. The recall began July 17, 2018. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 18S17.
Recall number 18V392000 · Recall details
Fuel system, gasoline: fuel injection system: fuel rail
- What is wrong
- Ford is recalling 57,199 my 2006-2007 e-150, e-250, e-350, and my 2007 expedition and lincoln navigator vehicles equipped with 5.4l engines. The fuel rail cross-over hose may contain weak areas. As a result, the hose may crack, which could cause a fuel odor and/or fuel leak.
- Risk
- Fuel leakage in the presence of an ignition source could result in a fire.
- Remedy
- Dealers will replace the fuel rail assembly. The recall began on march 3, 2008. Owners may contact ford at 1‑800‑392‑3673.
Recall number 08V057000 · Recall details
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
- What is wrong
- Vehicle description: sport utility vehicles. The fuel line assemblies may have been damaged by the supplier during manufacturing, allowing leakage.
- Risk
- Fuel leakage in the presence of an ignition source can result in a fire.
- Remedy
- Dealers will inspect these vehicles and, if necessary, replace the front and rear fuel line assemblies.
Recall number 98V312000 · Recall details
Questions about the Ford Expedition fuel pump
Which Ford Expedition years have fuel pump failure problems?
The model years with the most reports are 2007 (26 complaints), 2003 (25 complaints) and 2005 (15 complaints).
How much does it cost to fix fuel pump failure on the Ford Expedition?
Owners who mentioned a price put the repair at about $1,000 (median of 16 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Ford Expedition?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history