1996 Ford Explorer recalls
There are 6 safety recalls on record for the 1996 Ford Explorer, covering 5,543,470 vehicles in total across all the models in each campaign. Newest first.
All recalls
Vehicle speed control
- What is wrong
- Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). The scds may leak internally and then overheat, smoke, or burn.
- Risk
- A vehicle fire could occur with or without the engine running.
- Remedy
- Ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the ABS control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on october 27, 2009. Owners may contact ford at 1‑888‑222‑2751.
Recall number 09V399000 · Recall details
Suspension
- What is wrong
- Vehicle description: sport utility vehicles. Under certain conditions, a front sway bar link can fracture.
- Risk
- Vehicle handling could be affected, increasing the risk of a crash.
- Remedy
- Dealers will replace both the left and right front sway bar links.
Recall number 00V402000 · Recall details
Structure: body: hatchback/liftgate: support device/strut
- What is wrong
- Vehicle description: multi-purpose passenger vehicles. The liftgate assist gas cylinder bracket on the right hand bodyside outer panel was incorrectly welded.
- Risk
- The gas cylinder bracket may not properly support the liftgate increasing the risk of personal injury.
- Remedy
- Dealers will reinforce the bracket attachment with two pop rivets.
Recall number 97V137000 · Recall details
Vehicle speed control
- What is wrong
- Vehicle description: multi-purpose passenger vehicles equipped with 5.0l engines originally sold or currently registered in the states of alaska, idaho, iowa, maine, michigan (upper peninsula only), minnesota, montana, nebraska, new hampshire, new york, north dakota, south dakota, vermont, wisconsin, and wyoming. These vehicles, when operated for extended periods of time at highway speeds and temperatures below -20 degrees farenheit, do not return to idle due to ice in the throttle body.
- Risk
- Although the vehicle can be controlled by either applying the service brakes or shifting the transmission to neutral, increased brake pedal efforts or some increase in stopping distance can result.
- Remedy
- Dealers will install a revised pcv system with water heated vacuum source.
Recall number 97V074000 · Recall details
Equipment: other: labels
- What is wrong
- The certification labels on the involved vehicles has incorrect rear tire inflation pressure designations. This does not comply with fmvss no. 120, "tire selection and rims for motor vehicles other than passenger cars."
- Risk
- Incorrect inflation pressures could cause premature wear of the rear tires. .
- Remedy
- Owners will be provided with correct certification labels and instructions for installing these labels. Dealers can install this label if the owner so desires.
Recall number 96V161000 · Recall details
Latches/locks/linkages: doors: latch
- What is wrong
- When in the secondary latched position, the driver door latches may open when subjected to transverse loads less than that specified in fmvss no. 206, "door locks and door retention components."
- Risk
- The driver's door, when closed only to the secondary latched position, may not sustain a 1,000 pound transverse load.
- Remedy
- Dealers will inspect and, if necessary, replace the driver door latch.
Recall number 96V070000 · Recall details
Questions about the 1996 Ford Explorer recalls
How do I check if my 1996 Ford Explorer has an open recall?
Enter your VIN in the VIN decoder on this page to see the recalls for your exact model and year, then confirm with any dealer of the brand or the manufacturer, who can tell you whether the repair was already done on your car.
Do I have to pay for a recall repair?
No. Safety recall repairs are free at any authorized dealer of the brand, even if the car is out of warranty or you are not the first owner.
How many recalls does the 1996 Ford Explorer have?
6, covering vehicle speed control, suspension and structure.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1996 Ford Explorer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history