Vehicle purchased new, had a pinion noice in rear differential since purchased. Dealer changed rear differential and a week later it developed a leak due to blown axle seal. Rear differential then developed a noise when accelerating into a turn from a stoped position. Dealer added an additive to rear for limited slip unit. Noise is still there on turns but is very light. All this has occured since purchased new and 14,000 miles.
2002 Ford Explorer transmission complaints
Page 50 of 51: complaints 1,451 to 1,480 of 1,502, newest first, as owners wrote them.
Driveshaft area/rear noise-singing/hum.
Serious safety and operation issue with the 2002 year ford explorers SUV, the rear drive differential is failing, VIN#[xxx] is an example at 12,700 miles, serious interstate crash narrowly avoided due to the catastrophic failure of the rear differential.*ak information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Vehicle developed a loud whining noise in the rear end at approx 25000 miles. Noise occurred at all speeds. It went away when accelerator pedal was released. Dealer replaced the differential. Noise returned immediately, but only at speeds between 48mph and 68mph. Dealer is now replacing the entire driveshaft. One service assistant indicated other explorers had similar problems. According to dealer, ford has issued service messages. Sounds like a recall.
The rear axle leaked. Which was caused by the rubber seal eating into the metal of the axle per mechanic. *ak the rear axle failed between 17k miles and 30k miles and had to be replaced 3 times. *scc
2002 ford explorer purchased feb. 2002 new. Vehicle now has 17,000 miles. Several automatic transmission problems. When shifting out of park into drive the shift lever pops as if it never engaged. The car lurches forward or backward 1-2 feet after shifting into park, engaging emergency brake, and getting out of car. Vehicle drifts backward several feet when stopped on a hill and trying to accelerate from a stopped position. At 17,000 miles, and about 1 month after a normal scheduled service, started to experience a loud whining sound coming from under the vehicle and only on acceleration (not when coasting). The whining would come and go. The overdrive light started to flicker and then when out. The next day, transmission started severe slipping, especially at low speeds. Immediatlely took it to ford garage and they said it needed a total transmission overhaul. They also explained that ford will not replace with new transmission if it can be overhauled for under $2100. Also, there is no place to check transmission fluid. Manual states that it should be checked periodically by ford dealer and especially if slipping or other problems are noticed.
Vehicle has a resonance humming/ringing noise coming from the rear differential that increases with speed. Also has what appears to be slight drivetrain vibration as well. This problem was also noted in an editors review of the 2002 explorer for edmunds. Rear differential was replaced in may 2003, but the problem has persisited. Was told by the rear end technician at the ford dealer that it was being caused by the gears not meshing properly. Appears to be a defect.
I purchased my '02 explorer new. From the begining the same problem persists. With your foot on the brake, if you place the vehicle in park and remove your foot from the brake the vehicle will roll foward approx 1-2 ft. It concerns me. There have been many instances when purchasing fuel that I have nearly rolled into a pedestrian from a dead stop. I have asked the dealer about this problem only to be told it is nomal for this vehicle. I don't think any vehicle should make that pronounced a roll when removing your foot from the brake.
Vibration and drone/roar sound at speeds of 64mph and greater. 4 attempts made to repair, problem still exists. Rear end assembly replaced as well as two axle shafts and drive shaft reindexed.
Noted "clicking" noise when wheel turned at slow speed, assumed cv joints were going bad. However, dealer said that lug nuts were loose, and when tightened the noise stopped. What is notable is that the wheels have never been off, so this condition originated at the factory. Dealer says owner at fault and charged for the repairs. Owner says this a factory defect and a significant safety item and insist it be covered under warranty. At impass.
Consumer states while parked vehicle jumped into gear and rolled down a hill.
4 failures of the transmission. Common problems have been miss shifts from 2-3 and 3-4, delayed shifts from 2-3 and 3-4, and severely hard shifts in all gears. Transmission has been rebuilt twice and replaced once. Ford has bought the vehicle back after arbitration under the lemon law. The vehicle also has severe problems with the rear differential and right half shaft. I have had 6 total failures of the rear end. Warning signs have been a whine from the right rear the grows louder over time and then a vibration in the right rear. Ford knows of these problems as they have issued maintenance instructions to the servicing dealers of the order of repair attempts to be made. A recall may in order.
High pitch whinning noise in rear end of 2002 ford explorer. Dealer says rear differential gears have defect and I have to pay $1200. Because warranty expired!
I bought a 2002 eb explorer in july 2002 and have been having chronic transmission problems since oct/nov 2002. The transmission shifts between 2-3 and 3-4 are rough and it jerks into gear. The first time into the dealer, they "verified" my concern and did about $1,000 in repairs. It was ok for about 3 weeks and started again. It has gradually gotten worse, and the dealer claims they can not find a problem. They have updated and reprogrammed the system many times, and nothing helps. I am now on my third trip to the dealer for this. With all of the complaints and ford's service bulletins that list the exact problems I am having, I do not understand why ford is not doing something about this!!
I have had my vehicle into the ford dealer for the same problem at least 4 times with no success it is still under manufacturer warranty and is a 2002 ford explorer.
Transmission on 2002 ford explorer 4.0 liter slips and or jerks at times. At times upon entering a intersection the transmission will slip and then several seconds later the transmission will jerk into gear. On 03/04/03 we had a close call upon entering the intersection when this situation occurred. This problem continues in spite of taking the vehicle into ford numerous times.
The vehicle rolled back, when the consumer took his foot off the brake. The vehicle did not stop rolling until the consumer placed his foot back on the brake. The transmission was replaced.
The transmission slipped. Ford recommended a replacement with a rebuilt transmission. The vehicle was out of warranty. Scc
It was during the fast freeze when this incident took place. We went from 45 degrees to 20 degrees with in 2-3 hours. It was raining at first then switched to ice & snow. We put the 2002 ford explorer in 4x4 drive due to the weather conditions. As we were entering the express way we loss control of the truck only going 28 miles per hour. We spun out of control and hit the guard rail. It was as though we had no 4x4 drive. We called the police to get a accident report for our insurance. We then took the truck a week later to martin buick to fix the body damage to the left side of the truck. They took the truck to lasko ford across the street to work on the 4x4 system. They took the clutches out and drained the transmission fluid. They found damage to the clutches. These parts were blackened and glazed over. They said that this looks like wear and tear for this truck and that the truck was not maintained. We regularly changed fluids and the manual states that the truck does not need maintenance until 150,000 miles. I asked how could a new truck have so much damage to the 4x4 and they said that it must have been in 4x4 wheel drive for a long time. I know and so do my passengers that this is not true. The dash board always indicated 2 wheel drive not 4x4 unless I put it in 4x4. The automatic 4x4 never turned on the 4x4 drive I have always had to put it in 4x4 if I needed to use it, which has only been one other time. So for a truck that is one year old and only been driven in 4x4 wheel drive twice there seems to be an awful lot of damage to my clutches and my fluid so burnt. The four wheel drive on this truck. I will have the module that controls the "control trac" 4x4 wheel drive system tested to see if it fails to activate or de-activate the 4x4. Then I would like ford to fix the problem out of their own expense and stop giving their clients the run-a-round and to reimburse me for my time and expenses.
Ford told me I need a new transmission in my 2002 ford explorer that only has 50,000 miles. The is unacceptable for such a costly purchase. They offer no assistance or excuse for this type of defect in their product.
Vehicle transmission has a shuttering feeling when under moderate acceleration between 25-40 miles per hour. Dealer has been told about problem and said everything was fine after a reprogram of transmission.
Last summer (july 2002) during a military move from ga to az I noticed that my windshield had a large piece of glass missing on the outter right edge that you could not see until you actually got right up on the windshield. Part of it was visible to and part of it was hidden behind the rubber seal that is around the windshield. This windshield was actually installed with this piece missing from it when the vehicle was built and sent to the dealership. Also, the rear glass hatch, gas shock twisted from its original position and caused the window to be off center by about an inch or more. After fixing it three times it had to be replaced. Both of these problems (the windshield and the gas shock) have been fixed by my local dealership and thus far have held up. There are numerous other complaints that I have on my vehicle that include the elecrical system not functioning properly. When you turn the truck on sometimes all the dashboard lights stay on as well as the interior lights and you have to shut the truck down and back on several times in order for them to go out. The truck will sometimes stall at take off or will lurch while shifiting into a higher gear and has totally shut down while driving down the road on a few occasions. The trim paint on the doors, both front and passenger has faded there are rusted spots in the paint on the top of the vehicle, and the hood has a very bad orange peel effect on it with grit in the paint. The left rear speaker has busted and the panel on the rear hatch below has broken loose as well as one of the plastic bracket covers on the back of the passenger seats. Pe04045.pco
The transmission started to slipping. The dealer recommended that new/rebuilt transmission is needed. The vehicle was out of warranty. Ph scc
Since the vehicle purchase, the transmission has performed erratically, and has degraded over time. There are three main issues, first the vehicle tends to function like it drops into neutral during light acceleration. Secondly, and more of a concern, the vehicle creeps many feet when placed into 'park', with the engine off and the key out of the ignition, when parked on a grade. Finally, it takes upwards of 30 seconds when shifting from 'park' to any gear for the transmission to engage. When it does finally engage, it gives the feeling of 'slamming' into gear. This vehicle has been on the road since 5/01, and has been brought back to the dealer many times for these complaints. The dealer indicated that this behavior is normal. The concern is that there is a strong potential for property damage and personal injury should this vehicle creep downward.
2002 ford explorer can slip from park into reverse, causing a roll-away accident. The gear shift is loose enough that a driver can shift the truck into "p" on the gear shift, but the truck is not actually all the way in park. When this happens, it can slide into reverse. This is what happened to my wife and daughter. She put the car into reverse and backed up the driveway. She left the vehicle in park on the level driveway to run a bag of groceries inside. She opened the rear gate, went inside, dropped them off, then heard a loud crash. The truck had slipped out of park and into reverse, causing it to crash into the house. I can reproduce this behavior easily. I took it to bob tomes ford of mckinney, tx and spoke with maureen pollack of ford's consumer affairs. They said that they could find no defect (of course). I believe that they found nothing out of the ordinary because all 2002 ford explorers have ambiguous gear shifts. I urged her to have ford issue a recall or a service bulletin at the least. She declined, saying that the technician at the dealership said it was ok.
Excessive problems with transmission jerking, and shifting problems, purchased vehicle as brand new after 4 months contacted dealer where care was purchased regarding problem. Brought vehicle in at least twice before problem was found.the transmission was replaced has since had the same problem along with other problems, vehicle stalling while driving, cd player power shuts off. Rattling when hitting brakes. Filed a complaint dealer refuses to buy car back ask me to trade car in with more money down. The dealer repair persons confirmed that they have had replaced at least 10 transmissions on the same style vehicle prior to my visit and recognized a pattern. But nothing has been done!!
Consumer stated that while driving and without warning the vehicle will stick in park and will not shift gears causing a distraction to the consumer. Dealer notified. Ts
While driving approx. 40 MPH, vehicle suddenly went into 4 wheel drive low range. Occupant was wearing seat belt and car came to an abrupt stop. Accident was avoided due to light traffic this day. Car is @dealer 4 repair. Dealer claims computer that sends signal to 4 wheel drive transfer case failed due to cold weather and sent faulty signal to engage 4 wheel drive into low range. Temp was 40 deg. That day. I am concerned about the stress put on all of the internal drive components due to this sudden engagement. Dealer says they checked for outside damage, but damage will most likely be internal I.e. Transmission, transfer case, shafts, engine, drive assemblys. The day b4 we traveled on the interstate at speeds between 60-70 MPH. If this had occured at this speed it would have been much worse. Wife went forward during engagement and strained her shoulder. She was wearing her seat belt though. Dt
Consumer states that while driving at any speed and no warning the vehicle will stall and it will be hard for the consumer to control the vehicle. Dealer notified ts
Consumer states that transmission hesitates excessively and vehicle lurches forward when shifting between gears.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2002 Ford Explorer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history