2020 Ford Explorer wheels problems

Filed Aug 21, 2026 · Wheels · 57,065 miles · CA

The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed on a six-hour trip, the low tire message was displayed, and the tire quickly deflated. The contact slowed down and pulled into a service center and inflated the tire. The vehicle was then driven without failure. While pulling into a parking lot, the driver's side rear wheel detached from the vehicle. The previous tire lug nut had been factored out for installation at a tire center. The towing company became aware that all five bolts had sheared off, and some of the bolts were in the parking lot. The vehicle was inspected by the local dealer, and it was determined that the rear passenger’s side wheel was missing lug nuts as well. The contact stated that three of the five lug nuts had sheared off. The failure recurred. The manufacturer was not contacted. The failure mileage was approximately 57,065.

Filed Jul 29, 2026 · Suspension, Wheels · TX

I keep feeling a clunk or thump towards the back of the car at random times, towards the back axle. Sometimes it's when i stop and drive forward, other times it happens while I am just driving normally, usually at slow speeds around 5-45mph. I have an extended warranty and the ford dealer has said they can;t replicate it and want to give my car back until it gets worse, and then try fix it. I am highly concerned about this process....

Filed Jul 2, 2026 · Body, Electrical · IN

My driver window won’t stay up once it gets to the top it goes back down. The underbody is starting to detach. It is shifting hard and makes a loud noise. Worse at low speeds and applying brakes . The tire pressure sensors all went out at one time

Filed May 20, 2026 · Steering, Wheels · NJ

When putting the car in reverse and moving backwards start to feel the vehicle look drive power and knock sounds. Sounds likes and feels like gear teeth or not aligned. When putting the car into drive the vehicle jumps a little and you hear a lout pop noise.

Filed Mar 6, 2026 · Wheels · NJ

Wheels / Tire Pressure Monitoring System The tire pressure monitoring system (TPMS) on my 2020 Ford Explorer intermittently fails to detect the tire pressure in one or more tires. The system will show missing pressure readings or fail to display a reading for a tire. The vehicle may operate without accurate tire pressure information being displayed to the driver. This creates a potential safety risk because the driver may not be alerted to a low tire pressure condition. The vehicle had approximately 56,000 miles when this began, and the issue appeared without prior warning. The vehicle is scheduled for inspection by a Ford dealership.

Filed Aug 26, 2025 · Wheels · NC

Tire pressure sensor fault. A rear tire pressure sensor has defaulted more than once. As this is built into the wheel assembly, I believe this is a safety issue

Filed Jul 14, 2025 · Wheels · GA

The tire pressure monitoring system has failed. Per the dealership, each tire needs a new battery, which run around $150/each. The first sensor went out approx 1 month ago, with the other 3 going out shortly after. While this does not pose an immediate risk for the driver, it does appear that numerous other 2020 explorers are having the same issue. If the batteries provided are faulty, a recall should be issued.

Filed Jun 19, 2025 · Transmission, Wheels · FL

I am filing a complaint regarding a safety issue with my 2020 Ford Explorer that was not properly addressed during a recall repair, leading to a dangerous situation. Vehicle Details Make: Ford Model: Explorer Year: 2020 Recall Repair Details In January 2024, I took my vehicle to Coconut Point Ford in Estero, FL, for a recall repair related to the rear axle horizontal mounting bolt, which was at risk of fracturing. The recall required the replacement of the subframe bushing and rear axle bolt to prevent driveshaft disconnection. Incident Description Recently, while driving under normal conditions, the bolt fractured, causing the differential to nearly detach from the vehicle. This failure could have resulted in a catastrophic accident. I am now facing a $6,000 repair bill for an issue that should have been resolved under the recall. Safety Risk The failure of the bolt and the near detachment of the differential posed a severe safety risk, as it could have led to a loss of control of the vehicle, especially at highway speeds. Dealership Response When I brought this to the attention of Coconut Point Ford, they stated that "bolts are not covered under the extended warranty." However, since this is a recall-related issue, I believe Ford is obligated to cover the repair costs. The service writer, Steve, has been helpful, but the resolution has been delayed. Additional Context I am aware of class action lawsuits against Ford regarding this defect, which allege that the recall fix does not fully address the issue and that the design is inherently flawed. Request I request that the federal safety agency investigate this matter to ensure that Ford is held accountable for properly addressing this safety recall and to prevent similar incidents from occurring to other vehicle owners. Thank you for your attention to this serious safety concern.

Filed Feb 10, 2025 · Transmission, Wheels · MI

1. Component: AWD system – Front Axle Disconnect Actuator / Intermediate Shaft • Failure Type: AWD system failed, preventing power transfer to front wheels • Availability for Inspection: Yes, diagnosed and confirmed by Zeigler Lincoln Ford 2. On Thursday, [XXX], while driving in a snowstorm with my two children, my 2020 Ford Explorer AWD system failed completely, leaving us stranded on an icy hill with no traction or ability to move. • My vehicle lost all AWD functionality, causing it to become immobilized on an active roadway in hazardous conditions. • We were trapped between two semi-trucks that were also stuck, creating a high-risk situation where a collision or multi-vehicle pileup could have occurred. • With freezing temperatures and no way to move, we were at risk of hypothermia while waiting for a tow truck. This was not an isolated issue. Ford acknowledges this AWD system defect under TSB 23-2174, meaning this failure can happen to any driver under similar conditions, creating a major safety hazard. 3. Yes. The issue was diagnosed and confirmed by Zeigler Lincoln Ford, who determined it was covered under TSB 23-2174. • Ford has officially acknowledged this defect but has not issued a recall. 4. Yes. The vehicle was inspected by Zeigler Lincoln Ford, and the AWD failure was confirmed as a front axle disconnect actuator/intermediate shaft defect. • Ford issued TSB 23-2174 to address the defect, proving that this is a known issue. • However, instead of issuing a recall, Ford is making owners pay for repairs out of pocket, despite the serious safety risk. 5. Yes. Prior to the AWD failure, I received a wrench icon warning (Powertrain Malfunction Indicator) on my dashboard. • Error codes C0631 and C0633 were later retrieved by the dealership, confirming AWD disconnect failure. • I had experienced intermittent AWD traction loss in winter conditions, but the system failed completely during the snowstorm incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 30, 2025 · Wheels · MO

The tire pressure system for all four tires has completely went out on the monitoring system. It originally started where it was only on one tire then it happened to two then the final monitor keeps going in and out.