2023 Ford Explorer electrical problems

Filed Oct 14, 2026 · Electrical, Visibility · UT

I am filing this complaint because the federal recall remedy performed on my 2023 Ford Explorer failed, and the Ford dealership that performed it refused to correct the failure. About a year after I purchased my 2023 Ford Explorer (used, from an independent dealer), I received Ford's federal recall notice for the rearview camera software defect (recall 23S02, the federal safety agency campaign 23V‑022). My vehicle had no problems at that time, but I took it to the authorized Ford dealership in [XXX], and had the recall software update installed as instructed. About seven months later, my vehicle developed the exact defect the recall was supposed to prevent: the backup camera stopped functioning and the infotainment screens went completely black, disabling multiple vehicle functions. This created a safety hazard because the vehicle no longer provided any rearview image while backing up. I returned the vehicle to the same dealership and asked them to correct the failed recall repair. Instead, the dealership claimed the problem was not recall-related, diagnosed a failed APIM module, and quoted about $1,600 for replacement plus a $300 diagnostic fee. The dealership then refused to release my vehicle until the $300 fee was paid, holding it for approximately two months. I took the vehicle to an independent repair shop, which confirmed the APIM was fine - the software had simply become corrupted - and repaired it by reinstalling the software. I paid $530.29 for that repair plus $313.79 for a replacement battery (the original died while the car sat at the dealership for two months). Ford was sent a formal demand letter on XXX, with a 10-day deadline, and never responded. NOTE: The incident date entered in this form is my best estimate only; the exact date is approximate. I am asking the federal safety agency to investigate this dealership's failure to honor a federal recall remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 24, 2026 · Electrical, Engine · AK

Vehicle: 2023 Ford Explorer ST VIN: [XXX] I am reporting ongoing safety-related powertrain and drivability defects that continue despite numerous repair attempts, including complete engine and transmission replacement. Since approximately June 2025, my vehicle has experienced delayed acceleration, hesitation, erratic RPM behavior, harsh shifting, loss of power, and intermittent warning lights. The vehicle has also stalled, jerked during acceleration, and exhibited transmission shuddering and lurching. The problems have been repeatedly reproduced, documented, inspected, and repaired by Kendall Ford of Anchorage, Alaska, the sole servicing Ford dealership involved. Repairs have included replacement of fuel injectors, cylinder heads, a complete engine assembly, and a complete transmission assembly. Despite these repairs, the safety concerns remain. Current symptoms include: • 1-4 second delay in throttle response. • Vehicle may fail to accelerate below approximately 30 mph. • Engine RPM rises significantly without proportional vehicle acceleration. • Erratic shifting, surging, and harsh jolts. • Intermittent check engine lights, FordPass alerts, and electrical warnings. These conditions create a significant safety risk because the vehicle may fail to accelerate when entering the highway, merging into traffic, crossing traffic, making left turns, or avoiding hazards. The delayed throttle response and sudden acceleration after the delay increase the risk of a crash. Attached service records document stalling, misfires, loss of propulsion concerns, and repeated powertrain failures requiring replacement of both the engine and transmission, yet the drivability concerns continue. I believe this may involve a defect in the powertrain, transmission controls, engine management system, electronic throttle control system, or related vehicle control modules. I respectfully request that the federal safety agency investigate these recurring safety-related defects. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C

Filed Jun 23, 2026 · Electrical · 61,000 miles · MI · fire

The contact owned a 2023 Ford Explorer. When the contact’s husband activated the air conditioning system after the vehicle had been parked for several hours, a fire started underneath the console inside the vehicle. The driver pulled over to the side of the road, where onlookers assisted with extinguishing the fire with a fire extinguisher. The contact’s husband received burns on his fingers. Medical attention was not needed. The Fire Department was not contacted. The vehicle was towed to the dealer to be inspected; however, the cause of the failure was not determined. The vehicle was deemed a total loss. The contact was provided with photos of the vehicle and became aware that the wiring was burned. The manufacturer was not made aware of the issue. The failure mileage was approximately 61,000.

Filed Jan 3, 2026 · Electrical, Transmission · OH

While in moderate snow attempted to go from backing up to drive and the vehicle stopped, parking brake auto engaged, powertrain (wrench) trouble light illuminated. The trouble light did not shut off after sitting overnight.

Filed Aug 21, 2025 · Driver assistance, Electrical · 3,000 miles · TN

The contact owns a 2023 Ford Explorer. The contact received notification of the federal safety agency Campaign Number: 25V442000 (BACK OVER PREVENTION). The contact received Customer Satisfaction Program (CSP): 24B47 in August 2024. However, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Most recently, the contact stated that when the vehicle was started, the navigational system displayed a black screen, compromising the functions on the screen. No warning lights were illuminated. The contact stated that the Ford App on the cellphone failed to sync with the vehicle as intended. The message "Unable to Connect" was displayed on the App. While attempting to remotely start the vehicle, the message "Temporarily Unavailable – Unable to Connect" was displayed. The vehicle was taken to the dealer several times to be diagnosed, and it was determined that the software and screen had failed. The vehicle was not repaired. The manufacturer was notified of the failure and sent an Over-the-Air software update; however, the sync failed to connect as intended. The failure mileage was approximately 3,000.

Filed Aug 6, 2025 · Electrical, Seats · CA

drivers side second row captain seat makes ticking noise under the seat. if I put weight on seat it stops. it is intermittent. Im concerned it might be electrical. I have a video but unable to download. I can send if there is an email to send to.

Filed Jul 23, 2025 · Electrical · 44,500 miles · SC

The contact owns a 2023 Ford Explorer. The contact stated that while driving at an undisclosed speed, the steering wheel became inoperable. There were several unknown warning lights illuminated. The vehicle was taken to the dealer, where the vehicle was diagnosed and determined that the wiring harness located on the passenger’s side of the vehicle needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 44,500.

Filed Jul 8, 2025 · Electrical · 33,000 miles · OH

The contact owns a 2023 Ford Explorer. The contact stated while his wife had parked and remained in the vehicle, and while driving at various speeds, several unknown warning lights illuminated. The contact stated that a dealer was contacted. The vehicle was taken to the dealer and the contact was informed that the Cross-traffic monitor and Blind Spot monitor had failed. The contact was informed that the software was updated; however, the failure persisted. The vehicle was not repaired. The manufacture was notified of the failure and opened a case. The contact was referred by the manufacturer to the federal safety agency Hotline to report the failure. The approximate failure mileage was 33,000.

Filed May 1, 2025 · Driver assistance, Electrical · WI

Error codes such as blind spots detection with traffic and a couple other codes that is stored in view status area in oasis

Filed Nov 7, 2024 · Electrical · 10,000 miles · NY

The contact owns a 2023 Ford Explorer. The contact stated while driving 15-20 MPH, the vehicle stalled on several occasions. The vehicle was restarted after fifteen minutes. The vehicle failed to unlock from inside or outside with the key. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the ground wire had caused the failure. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 10,000.