2022 Ford F-150 Hybrid engine problems

Filed Aug 8, 2026 · Electrical, Engine · CA

Driving along I-15 in vegas. Ambient temp was 112 degrees F. Engine stopped, check engine light came on and a 'stop safely' indicator appeared. Had to have the truck towed from the interstate to a Ford dealership.

Filed May 19, 2026 · Engine, Transmission · CA

In the second year of ownership I noticed that occasionally I would get no throttle response from the gas pedal when trying to accelerate. After several occurrences I began to pay close attention as to when this was occurring. I found that this occurs mostly, not exclusively, when I am slowing the vehicle to a near stop, not a full stop and then accelerating to continue, like slowing to round a corner on a green light and getting into traffic. For example, I was exiting a Home Depot parking lot, the driveway exits to the roadway. As I approached the driveway to enter the roadway I slowed, preparing to stop. Seeing no traffic on the roadway I then pushed the accelerator to enter the roadway. The pedal was dead, I got absolutely no acceleration. I pushed the pedal down slowly, nothing. I pushed the pedal to the floor, nothing. The truck rolled out onto the road, I coasted to the side of the road. Had there been traffic I'd have been hit. This has happened 20 times in two years and 80K miles. The most recent event was this week with my wife present, very scary, dead pedal, not throttle response. If you research "Dead Pedal" on GOOGLE, you will get the following response: The "dead pedal" in the Ford F-150 PowerBoost—a dangerous lag or total loss of throttle response—is a widely reported issue, particularly when accelerating from low speeds, turning, or right after starting. [1, 2, 3] The cause can range from a software glitch to transmission issues or failing sensors. Ford said there was a TSB, however the work performed had no effect on the dead pedal on my truck. Invoice attached from March 2026, it just occurred again this week. I am going to trade the vehicle in but I doubt that Ford will disclose this flaw to the next buyer, it will be their's to discover, hopefully not by "accident". I am going to trade this vehicle in and I'm sure the new buyer will have no idea of this potentially deadly flaw.

Filed May 29, 2025 · Electrical, Engine · MA · fire

On Sunday, [XXX], my truck spontaneously burst into flames while parked in my front yard. I had just returned from doing a number of errands. The truck had been running fine with no indications of a problem. I was outside tending to my smoker when I heard a sort of popping/crackling noise. I looked up at my truck approximately 40 feet away and saw flames shooting out from the engine bay through the hood gaps. I called 911 and attempted to douse the flames with a powder fire extinguisher with no luck. By the time the fire department arrived 15 minutes later or so, the truck was fully involved and burnt to the frame. I didn't smell gasoline during the initial startup, but a strong smell of burning wires. The concerns are of course for my safety and that of my family. It was just luck that the truck was parked in the front yard rather than next to my house where it's normally parked. We were have a sidewalk put in and thus my normal parking space wasn't available. I could've been driving at the time and with the speed of this fire, I'm not confident I would've been able to get out. The truck has been seen by the insurance company and is being towed out of my yard sometime today May 29th, 2025. I don't know where it will towed to. I have pictures and videos detailing the fire and it's progression. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 24, 2025 · Electrical, Engine · PA · fire

After driving home from work on 12/20/24 the truck was parked at ~10pm. At ~1AM on 12/21/24, I was alerted that the truck was on fire. I found the vehicle fully engulfed in the hood and cab area. There was no prior indication of a problem or issue. The truck was fully destroyed and my home and Jeep were damaged. My home was damaged and only saved because I brought my garden hose out and sprayed the house until the local FD arrived. The local Fire Investigator and the Insurance Fire investigator could it definitively identify how/why the truck caught fire and burned up.

Filed Feb 6, 2025 · Engine · 58,000 miles · FL

The contact owns a 2022 Ford F-150. The contact stated that upon starting the vehicle, there was an abnormal sound coming from the rear end of the vehicle. The contact stated that upon inspection, the contact became aware of fluid leaking from a crack in the exhaust system caused by rust. The vehicle was taken to a local dealer to be diagnosed, and the contact was informed that the exhaust leak was a result of corrosion and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 58,000.

Filed Jan 2, 2025 · Electrical, Engine · MA

on January 20, 2024 I serviced my F-150 due to a malfunction. The DTC code came back as P0A1E-00. This is for the Starter/Generator Control Module. The belt and starter were reaplaced. The code appeared again on 12/21/24 2 times, 12/25/24, 12/26/24 2 times. I brought this back to the dealer on 12/19/2024. 12/26/2024, 12/27/2024. Somehow there was a TSB which I cannot acces that information, but this mentioned to test the battery. My battery failed. I paid for the diagnostics and battery. Then 3 hours later on 12/26 my Tuck went into a powersave mode. This time I brought it back on 12/27/2024, and got a call form the dealer on 12/31 that the replacement battery was defective. This was replaced. I am trying to find out why my battery died after only 2 years. Also since my DTC is related to the charging system, this could ptentially damage my battery. And they also replaced it with a defective battery. Ironically, there is a current recall of over 20,000 batteries being defective from Ford. I mentioned all of this to dealer and Ford directly, and no one can give me a straight answer of what it says to fix my issue.

Filed Sep 30, 2024 · Acceleration, Engine · RI

Loss of Acceleration in 2022 Ford F-150 PowerBoost Hybrid I am writing to report a safety issue with my 2022 Ford F-150 PowerBoost Hybrid, which has been experiencing acceleration lag and loss of power during regular driving conditions. Component/System that Failed: The powertrain system, specifically related to the integration between the electric motor and gasoline engine, appears to be malfunctioning. This issue primarily affects the vehicle's ability to accelerate after a stop or during turns. Safety Risk: The loss of acceleration poses a significant safety risk to both myself and others on the road. The delay in throttle response has caused the truck to remain in a low gear for several seconds, even with the accelerator fully pressed. This issue has occurred while merging onto highways, when moving through intersections, where quick acceleration is necessary to avoid collisions and a simply stop signs taking a turn where I'm not able to accelerate after. The delay increases the likelihood of rear-end collisions and creates dangerous situations, especially in heavy traffic. The problem has been reproduced by a dealer and many other owners have reported the same issue. I'm hoping that Ford has releases Powertrain Control Module (PCM) update aimed at addressing this, but the issue persists for many, including myself after recent PCM updates. The vehicle has been formally inspected by my local Ford dealership. They will be applying a PCM update on 10/10/2024. There were no warning lamps or error messages that appeared before or during the incidents. The problem occurs unexpectedly, usually when I press the accelerator, particularly in Eco or Normal driving modes. The issue has been less frequent in Sport and Tow/Haul modes, but this results in increased fuel consumption, which negates the advantages of the hybrid system.

Filed Jul 7, 2024 · Electrical, Engine · FL

Reduce power warning, instrument cluster is black, extremely loud pulse noise from radio that can not be turned off , catalytic converter issue ( ck engine light ) stalled in traffic. and horrible fuel mileage. Nothing resolved from the dealer.

Filed Mar 7, 2024 · Engine · FL

After coasting or turning I lose all ability to accelerate for a short period of time. When trying to merge the truck fails to speed up causing a dangerous situation where traffic jams up behind you

Filed Feb 27, 2024 · Electrical, Engine · VA

Vehicle's engine will not start. When attempting to start, it will turn on all usual electrical components, but will immediately show an warning message to "Stop Safely Now" along with an engine light of a red outlined truck with exclamation mark. Followed by a message of accessory mode on, however the engine will not start with no access to power steering or shifting gears. Normal attempts to jump start or charge the battery will not work. All fuses and harness connections appear to be normal. After researching Ford community forums, this appears to be a common complaint in the Powerboost Hybrid 2021-2022 Ford F-150s. Extremely inconvenient as this situation has left us stranded several hours from home with no reasonable solution other than to tow to a dealership. We hope our message helps encourage Ford Motor to continue researching the issue and come with a reasonable solution for all effected.