2001 Ford F-150 lights problems

Filed Apr 6, 2021 · Brakes, Electrical · 164,000 miles · CA

We purchased our 2001 f150 supercrew used. I am a mechanic, so the first thing I do when buying a used vehicle is inspect it thoroughly. There were a few minor issues, but one stood out as a major safety hazard. Upon further research, it seems to be extremely common to all 1997-2003 f-150s. Symptoms - this issue mainly affects the rear left and right brake lights, turn signals, and hazard lights. These lights, particularly brake lights, can cease to function entirely, intermittently and unknown to the driver. Cause - there is a wire harness which connects to the "multi - function switch". This wire harness is pulled when the steering wheel is tilted down. As a result, the connector or individual terminals can become loose or disconnected. This problem is most prevalent with the steering wheel in the down position, but once loose can happen at any position and any driving situation. Solution - repair or replace with motorcraft part# wpt607, and ensure the harness has enough slack to allow steering wheel tilt without tension on the harness. In our case, I replaced the connector and pulled the wires enough to allow slack for steering wheel tilt. There are numerous reports of this issue online, and it is well documented by f150 owners. I have pictures but the file sizes are over 5mb.

Filed Jun 19, 2017 · Lights · 90,000 miles · OK

Tl* the contact owns a 2001 ford f-150. While driving approximately 70 MPH, the low beam headlights went out and then illuminated again after a few seconds. There were no warning indicators illuminated. The contact stated that the same failure occurred twice previously. The dealer was not contacted. The manufacturer was notified of the failure. The vehicle was not repaired. The approximate failure mileage was 90,000.

Filed Sep 4, 2012 · Electrical, Lights · 138,000 miles · MT

Rear lights, including brake, turn signals, and hazard lights quit working. This issue can be found on many online ford f-150 forums. The steering column wiring is too short, and breakage in the wire, or connectors can occur with the tilt steering mechanism. The tilt steering mechanism and short wiring has caused the connection to break inside the steering column trim on our vehicle, which caused the lights to stop functioning properly. I inspected the problem, and found the connector can move freely. I feel this is an issue since I am able to locate many others that have had the same issue from 1997 up to 2001 ford f-150s.

Filed Apr 10, 2012 · Lights · 43,000 miles · OR

Tl* the contact owns a 2004 ford f-150. The contact stated that the headlights stopped illuminating whenever the turn signals were activated. The failure occurred when using both the lowbeam and highbeam headlights. The vehicle was taken to the dealer, where the contact was informed that the turn signals needed to be replaced. The vehicle was not repaired. The VIN was not available. The failure and current mileages were 43,000.

Filed Jul 22, 2011 · Lights · AR

Tl* the contact owns a 2001 ford f-150. The contact stated that the amber lights were completely defective. The dealer and manufacturer advised the contact of the federal safety agency campaign id number: 06e023000 (exterior lighting:headlights) but the contacts VIN was not included in the recall. The vehicle was not repaired. The failure mileage was unavailable and the current mileage was 193,000.

Filed Jun 25, 2007 · Lights, Locks · TX

Ford f150 crewcab, the interior light does not shut off which causes the doors not to lock . This is a security problem for my wife. After calling ford to report this problem they couldnt help me. Also, a problem in the 1995 ford ranger. But the part were very expensive.

Filed Mar 17, 2005 · Acceleration, Brakes · 35,000 miles · WV

Take a look a my vehicle history, I baby my truck - never used off-road. I have replaced several items that I feel should have been fixed by ford. I had to buy a warranty that cover most of the stuff. Some parts with defects that were replaced. Most replaced at 40,000-80,000 miles 1.) transmission completely replaced 2.) rearend replaced 3.) I'm on my third set of all 4 ball joints 4.) tie rods, tie rod ends (replaced twice now) 5.) coil 6.) headlight housing (3-4 times) 7.) brakes, numerous things worked on and replaced dealership was never able to stop the thumping noise that is still there, said it was normal (not) 8.) idler arm (replaced twice) 9.) sunroof switch replaced twice, reported loud bang when opening. A&b kia said it was normal - no, now it is completely broke and will barely open and have to force closed. 10.) sideview mirrors vibrated 11.) ABS sensor replaced 12.) keyless entry replaced 13.) steering bearings replaced 14.) back bumper is rusting these are just some of the things I can remember right off hand. I've got all receipts. I take care of this truck - wash and wax once a week by hand (unless really bad weather) then I just take it to the car wash automatic or actual people washing. Keep inside just as nice. If you want to check out a vehicle for safety/recall information you should start with mine.

Filed Apr 12, 2004 · Lights · 200 miles · KY

I have 2001 ford f-150 pickup truck. The problem is with the turn signals. They cancel after you turn them on if you turn the wheel to the left or right. It takes very little movement of the wheel to cancell the turn signal. If it would only cancell if you turned in the direction of the turn it would be okay.

Filed Oct 22, 2003 · Lights · VA

When driving at night and without warning headlights shut off, causing driver to pull off the street.

Filed Oct 21, 2002 · Lights · TN

The fog lights are all cracking, due to design. They are full of water and may short out my head lights . Dt