Check a VIN

2002 Ford F-150 fuel system complaints

Page 3 of 4: complaints 41 to 70 of 86, newest first, as owners wrote them.

See the summary of 2002 Ford F-150 fuel system problems: which part fails, at what mileage and related recalls.

Filed Jul 16, 2011 · Fuel system · 160,000 miles · MA

Fuel tank straps rusted out causing fuel tank to breakaway from the vechicle . Fuel tank dragged on the highway spilling entire 25 galons of fuel. Fire department was called to remove the tank before the truck could be towed. Fuel tank is damaged beyond repair needing replacement.

Filed Jul 13, 2011 · Fuel system · 138,125 miles · NJ · fire · 1 injury

Tl* the contact owns a 2002 ford f-150. While the vehicle was parked the contact stated it caught fire . The police and fire department were notified of the fire. The fire department extinguished the fire. A report was filed. The vehicle was destroyed and towed. There was damage to the roof of the building where the vehicle was parked. A consumer who occupied the building observed that the vehicle was on fire, suffered smoke inhalation and was treated at the scene. There was a recall under the federal safety agency campaign id number: 06e056000 (fuel system, gasoline) that may be related to the failure. The manufacturer was not made aware of the failure. The approximate failure mileage was 138,125.

Filed Jul 8, 2011 · Fuel system · 122,000 miles · PA

Tl* the contact owns a 2002 ford f-150. The contacted stated that while driving 5 MPH he heard a loud banging noise and noticed that the fuel tank was dragging on the ground. No fuel leaked out of the tank. The vehicle was towed to the dealer where the contact was informed that the straps which held the fuel tanks in place fractured due to corrosion. The vehicle was not repaired. The failure and the current mileages were 122,000.

Filed Jul 5, 2011 · Fuel system · 116,210 miles · IL

I was traveling on rt. 64 heading east toward rt 59 in west chicago when I suddenly heard a thud followed by a scraping noise coming from what I first thought was the bed of my 2002 f150. I pulled off the road to check and didn't see anything wrong from the suspected area. I drove a little longer and when the noise wasn't stopping, I pulled over again and noticed one of the brackets holding my gas tank was dragging and the front half of my gas tank was on the ground. The bracket was rusted through and fallen away on one side. I was absolutely shocked at this problem because I had just had my truck in the shop a few months before and there was no mention of any rust issue with the bracket from the shops I had been in. I had the fuel pump and filter replaced in jan. 2010 and there was no mention of rust issues with the bracket then.

Filed Jun 30, 2011 · Fuel system · 166,867 miles · OH

The straps holding the gas in place on my 2002 f150 failed on the expressway causing the tank to drop to the ground at 65mph. By the time I was able to stop, a rip in the tank caused all of the fuel to leak out. Luckily no sparks of fire. I was never informed of a potential problem from the dealership I regularly get serviced at. I researched this issue online, and found many similar complaints. This could have been tragic/fatal, for me and all the other people driving around me. I am not one to write complaints, but I am upset at the danger this put me in and the time and cost of this failure.

Filed Jun 27, 2011 · Fuel system · 99,500 miles · ME

My 2002 ford f-150 has very badly rusted fuel tank straps, why is the recall only up to 2001 f-150's. Ford definitely used some cheap metals while making these f-150's is it possible to include 2002 as well?

Filed Jun 21, 2011 · Fuel system · 118,000 miles · NY

Gas tank straps broke, gas tank fell onto pavement. Had my truck towed to my ford dealer where they replaced the straps for about $200. If this had happened 5 minutes later, I would have been going 60 MPH! Updated 09/14/11 *bf *tr the tank fell to the ground, while the vehicle was sitting. There was no fuel spill. The dealer replaced the straps. Updated 09/21/11

Filed Jun 16, 2011 · Fuel system · 122,000 miles · MI

I heard on the radio about a possible upcoming recall on ford f150 pickup trucks (1997-2001). This is in relation to gas tank straps getting rusty and breaking. I then decided to look under my truck which is a 2002 ford f150 and discovered two gas tank straps completely rusted through/off with the tank no longer being supported by straps. The truck is only a 2002, but I think the problem goes beyond the 2001 trucks per the potential recall.

Filed Jun 14, 2011 · Fuel system · 81,180 miles · ME

The front gas tank support hanger broke due to corrosion. The rear hanger held the tank in place until I was able replace both units. The rear hanger did not break but was severely corroded also. I don't know what would have happen if I would have lost both units together while driving down the road.

Filed Jun 13, 2011 · Fuel system · 130,000 miles · MA

I smelled gas fumes near my 2002 f150 truck. Looked underneath to inspect where smell was coming from and found the back brace on the gas tank broken off and rusted out hole in the tank where the brace was supposed to be.

Filed Jun 12, 2011 · Fuel system · 100,893 miles · IL

I had driven 4 to 5 miles at 40 to 45 MPH and was a 1 block from my destination. I had to stop for a stop sign and make a right turn. While making the turn I thought I hit something, but the street was clear? I turned the radio off and opened the window to here something dragging. I stopped at that time maybe 100 yards from where I last stopped. My speed was 20 to 25 MPH. I got out and looked under the truck and the gas tank was sitting on the ground.the front of the tank was on the ground the back was still elevated. The filler hose and fuel lines were the only thing holding the tank. Both hangers were broken, rusted thru. If I was driving at highway speed, I do not believe I would have a truck left. I also understand that 2001 and earlier f150's were recalled for the tank hangers and I would suggest it be expanded. Asap! My ford dealer 4 weeks earlier had inspected my vehicle at my request for regular maintenance and repairs before my vacation trips. The service tech never looked at my tank straps even knowing previous years had a problem? Ford should have caught this before it happened again. The biggest complaint after is the ford dealership told me it was not a part of any recall and they knew nothing about it. Which I do not believe! I have the straps if anyone cares to examine them from your office.

Filed Jun 10, 2011 · Fuel system · 77,000 miles · WI

Ford f 150 fuel tank bracket has rusted away year 2002.

Filed Jun 2, 2011 · Fuel system · 139,000 miles · RI · fire · 1 injury

Fuel tank dropped to the road while driving causing the truck to be engulfed in flames. Driver made it out with first and second degree burns. Two dogs in the back seat died in the fire. Initial investigation by the insurance investigator determined that it was the fuel tank straps that failed. There is an investigation (pe10036) by the federal safety agency for fuel tank straps on ford f-150s 1999-2001. The 2002 and 2003 f-150 use the same straps. Larry hershman of the federal safety agency has contacted me about this incident. Updated 06/13/11*bf & 06/14/11*bf updated 08/11/11 *bf updated 3/01/2012 *ln

Filed Jun 1, 2011 · Fuel system · 182,456 miles · LA

Fuel tank straps rusted out resulting in gas tank dropping. Updated 09/14/11 *bf the consumer stated the fuel tank was damaged and had to be replaced. Updated 09/16/11

Filed Jun 1, 2011 · Fuel system · 98,500 miles · PA

Tl*the contact owns a 2002 ford f-150. The contact stated while driving approximately 25 to 30 MPH he heard a loud dragging noise underneath the vehicle. He then pulled to the side of the road and noticed that both straps had fractured and were covered with rust. The tank fell off of the vehicle, but none of the fuel spilled. The contact was able to continue driving the vehicle and it was repaired by the owner. The manufacturer was contacted and advised him that there were no recalls. The failure mileage was approximately 98,500. Updated 07/08/11*lj upadted 11/04/11

Filed May 20, 2011 · Fuel system · 170,807 miles · MA

While driving at highway speed my 2002 ford f-150 dropped the fuel tank and the tank was dragged for approximately 1/4 mile wile I attempted to maneuver across three lanes of traffic to the breakdown lane. This created a hole in the tank as it was dragged against the pavement. I had just filled the tank and all 25 gallons was lost on the side of the highway. The vehicle was towed to the dealership and I am waiting for the estimate for repair.

Filed May 18, 2011 · Fuel system · 100,000 miles · OH

2002 ford f150 5.4l v-8 2-wheel drive, regular cab, 8ft bed... Broken gas tank strap...walked out and noticed my gas tank was hanging down...investigation revealed a broken gas tank strap...bound it back up with a ratchet-strap, and drove to the ford dealer...purchased a new strap and placed it on the vehicle in the parking lot...

Filed May 16, 2011 · Fuel system, Steering · 77,061 miles · OH

One gas tank strap was found to be rusted and the tank at an angle. It was inspected by a local ford dealer, who found that the gas tank was also rusted and leaking. The gas tank and straps were replaced. Because the model year was not in the date range of the recent recall, we had to pay $793. A power steering pump was also leaking and replaced. The gas tank was the major item of concern.

Filed May 15, 2011 · Fuel system · 105,000 miles · IN

2002 ford f150 fuel tank mounting straps failed due to corrosion and permitted fuel tank to drop to pavement while driving.

Filed May 13, 2011 · Fuel system · 86,442 miles · MO

Tl* the contact owns a 2002 ford f150. The contacted was driving 65 MPH when both fuel tank straps fractured. The straps were rusted and corroded and also causing the fuel tank to detach from the vehicle. The fuel tank also caused the drive shaft to fail while the vehicle was in motion and the contact could not control the vehicle. The vehicle was towed to a local mechanic shop and was repaired. The dealer was not contacted and the manufacturer was not made aware of the failure. The failure mileage was 86,442 and the current mileage is 92,000. Updated 6/8/11 *cn updated 06/16/11

Filed May 12, 2011 · Fuel system · 109,000 miles · NY

1. There was not an event leading up to the failure. 2. Gas tank straps broke 3. I have not fixed yet, will most likely fix on my own.

Filed May 12, 2011 · Fuel system · 38,000 miles · MA

Tl* the contact owns a 2002 ford f150. The contact noticed that the metal strap for the rear fuel tank was fractured as a result of rust. The vehicle was taken to an authorized dealer for repair. The manufacturer was not made aware of the problem. The failure mileage was approximately 38,000. The VIN was unavailable.

Filed May 11, 2011 · Fuel system · 155,000 miles · NY

Tl* the contact owns a 2002 ford f-150. The contact was driving approximately 40 MPH when the fuel tank detached and fell from under the vehicle. The vehicle was pulled over and towed to the contacts home. The contact also stated that the brake lines were also damaged when the fuel tank detached. The vehicle was not taken to have the failure diagnosed or repaired. The failure and current mileage was 155,000.

Filed May 10, 2011 · Fuel system · 155,000 miles · MA

2002 f150 I had to have the gas tank straps replaced one failed, how come the investigation is only going to 2001.

Filed May 10, 2011 · Fuel system · 87,760 miles · PA

Fuel tank strap broke allowing fuel tank to drop and nearly break free from the vehicle.

Filed May 10, 2011 · Fuel system, Steering · 95,000 miles · PA

Tl*the contact owns a 2002 ford f-150. The contact noticed that the gasoline tank strap was covered with rust. The contact did not inform the dealer or manufacturer of the failure. The vehicle was taken to a private mechanic where they replaced the fuel tank straps. The current mileage was 97,000. The approximate failure mileage was 95,000. Updated 07/08/11 *bf the driver side tie rod was also replaced. Updated 12/28/11

Filed May 10, 2011 · Fuel system · 175,000 miles · FL

After hearing about the f150 fuel strap problem I decided to report a rusted and busted strap on my 2002 f150. A friend noticed the strap hanging down so I was able to fix it before it fell. Mi.

Filed May 10, 2011 · Fuel system · 150,000 miles · IL

We filled the gas tank of our 2002 ford f-150 and drove about three blocks away from the gas station. The fuel tank dropped off the bottom of the truck and dragged on the ground leaking fuel everywhere. We were lucky it was raining at the time as I believe otherwise the tank would have caused a spark on the road and we'd have had a large fire with my children in the truck. It cost quite a bit of money to repair the truck, pay the fire department for clean up and tow the vehicle. We called our local ford dealer after our mechanic told us he sees f-150's with the fuel tank straps rusted and broken pretty regularly. We were told there was no recall so we would not be reimbursed. Now (2 months later) I hear there will be a recall but it will include 1997-2001 trucks only. Ours is a 2002 with the exact same problem and I've read ford used the same fuel tank straps on 1997-2003 f-150's. Updated 08/05/11 *bf the consumer stated the rear strap broke and the front strap broke from the weight of the tank and they broke in the middle due to rust. Updated 08/15/11

Filed May 9, 2011 · Fuel system · 101,250 miles · RI

Straps that secure the fuel tank rusted. One strap rusted completely through and was hanging loose-- the other was very close to failure. I was able fortunately to get to a garage --and I had the straps replaced. I just recently saw the notice about other instances of this happening and I decided to file a complaint. My truck is one year newer than what is being looked at.

Filed Mar 10, 2011 · Fuel system · 148,000 miles · IL

The fuel tank dropped down from my truck as I drove. I stopped in the middle of the street, put my hazard lights on and got out to see what had happened. I didn't know what it was, it looked like maybe the end of the exhaust system, there was no liquid and no smell. I called for help and slowly pulled my car over at the nearest side street. When I got out, gasoline was pouring out and I could then tell that it was indeed the fuel tank that was hanging from the underbody of the truck. The fire department had to be called and I have to pay for the clean up of the fuel. The truck was towed to a repair shop and they said the straps that hold the tank up rusted out and failed. Total repair cost will be around $1500.

VIN decoder

See the problems and recalls for an exact car

Buying a used 2002 Ford F-150?

Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.

Check its history