2006 Ford F-150 technical service bulletins
56 technical service bulletins and manufacturer communications cover the 2006 Ford F-150.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This article supersedes TSB 22-2219 to update the Parts List and Service Procedure to clarify applicable...
- For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to
- Grinding/clicking/ratcheting noise from the front wheel area
- Grinding/clicking/ratcheting noise from the front wheel area
- This article supersedes TSB 19-2026 to update the vehicle model years affected
- This SKU is an Oil Dipstick
- Concern during or after programing the VSM. The programming may fail or vehicle symptoms such as...
- This SKU is a Transmission Oil Cooler Line
- Corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust
- Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may...
- When ordering a 2005 to 2008 remanufactured 5.4L 3v or 6.8L 3v engine, spark plug boots may be provided in...
- The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic...
- Some 2004-2014 F-150 and 2006-2008 mark lt vehicles equipped with four-wheel drive (4WD) may exhibit noisy...
- Lincoln/ford: when driving from idle up to 1200 RPM, there may be an intermittent rattle noise coming from...
- Ford/lincoln/mercury: may have sludge buildup in throttle body leading to less airflow or engine idling...
- Ford/lincoln/mercury: if battery was disconnected or dead, vehicles/trucks may experience hard starts and...
- Ford: there may be chaffing on a wire harness between the clockspring and driver airbag which cause the...
- Ford truck service campaign: in the case of the roushcharger for the F-150, the trucks calibration...
- Ford/mercury/lincoln: vehicles may exhibit one or more of the following symptoms: drive away hesitation,...
- Roush/ford: vehicles manufactured by roush with an intercooled roush charger have an opportunity for an...
- 1999-2008 7.3L/6.0L/6.4L/4.5L diesel f-super duty - clean the charge air cooler (CAC) system after certain...
- 4.6L/5.4L--MIL P0506 and/or P0505--HESITATION/loss of RPM/difficulty starting/low idle RPM
- Intermittent vehicle vibration--parking brake disengagement concerns
- Erratic fuel gauge operation - MIL on --dtcs P040/P0463 or instrument cluster module DTC B1201--VEHICLES...
- High pressure power steering line seepage-cold climates only (excluding heritage F-150)
- Some 1997-2008 vehicles equipped with a 4.6L 2V, 5.4L 2V, or 6.8L 2V engine--spark plug thread repair...
- Ford: some 2006-2008 F-150 lariat, xlt, and FX4 vehicles (excluding harley davidson and xl) may exhibit a...
- Rear axle tube fracture at center carrier
- Vibration from the driveline at highway speeds
- Erratic fuel gauge operation MIL/DTC P0460/1/2/3 and/or instrument cluster DTC B1201 or B1204 nj updated...
- Shudder/vibration on moderate to hard acceleration
- Un-commanded tcc apply on the 1-2 shift causing perception of hesitation and/or lack of power during shift
- Brake line interference with hanger plates on 2006 hd ford models
- Pids missing from diagnostic tools
- New door edge protector - built after 2/1/2006
- Vehicle/steering wheel vibration at 50 mph (80 km/h) or higher - steering wheel nibble at 65 mph (105...
- 1ST order vibration from the driveline at highway speeds
- Shudder/vibration on moderate to hard acceleration
- Neutral tow capability -- service kit requirements
- Vsm programming - service procedure update
- Neutral tow capability - service kit requirements
- 4X4 front differential bracket repair
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Buck/jerk or surge - 6.0L vehicles built before 8/22/2005
- Service procedure for repair or replacement of column shift cable
- Coolant degas bottle overflow
- Trailer brake controller applications
- Hard start, no start and/or other symptoms caused by a high pressure oil system leak - service tip
- 20 inch and 22 inch high performance tires may exhibit a vibration in steering wheel and/or seat while...
- Safety belt retraction speed
- Malfunction indicator lamp (MIL) on and/or various driveability conditions - 5.4L 3-VALVE engine -...
- Front tire wear on inside and/or outside edge
- Service wiring harness replacement guidelines - service tips
- 5.4L 3V with P030X and/or P0316 accompanied by spark knock
- Vibration diagnosis - tire/wheel runout
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Ford F-150?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history