Tl* the contact owns a 2016 ford f-150. When the contact lifted the aluminum covering on the bed of the vehicle, he noticed a large hole. The dealer advised him to cover the hole with plywood or to pay for a bedliner. The manufacturer was made aware of the failure and promised to have a regional manager call the contact back. The failure mileage was 900.
2016 Ford F-150 body complaints
Page 8 of 8: complaints 191 to 199 of 199, newest first, as owners wrote them.
The bed of the truck is separated from the side wall of the truck , this is around the fender wells, allowing water and vapors into the bed area of the vehicle.
Driver door of 2016 ford f150 will not latch when closing. Problem primarily occurs after vehicle has been in use. After opening the door, the door will not latch in a secure position when attempting to close. Will occasionally latch when pressing the unlock button after opening. Driver can be inside the cab or outside the vehicle and problem occurs either way. I have contacted my local ford dealer and service center and they were not familiar with this issue. Operator has not been able to replicate the problem on any of the other doors - just the driver door. Vehicle is a supercrew model. Problem occurs when operator has truck off, opens the door, gets in vehicle, attempts to shut door (doesn't latch), starts vehicle and re-attempts (still doesn't latch), and will even occur with vehicle shifted into "d" (drive) and re-attempts (still doesn't latch). This owner and operators opinion that this is a safety issue as other operators may not realize that the door has not latched and may be putting vehicle into motion with an open/unlatched door.
Door catch is missing and miss drilled in cab frame. Ford wants to cut a section of the cab frame out and weld in new section. This truck had 86 miles when discovered. All cab interior needs to be completely removed down to bare metal and all glass and the cab needs to be removed completely from the truck frame to be repaired. How many trucks came off the assembly line and passed inspection like this I purchased a new truck not a chopped truck. Ted britt ford in fairfax va. Is zero help so far after 3 weeks. Was there a recall?
Seat headrest protrudes too much out of the seat and it pushes forward head of some drivers. The only adjustments available (slide up and down, tilt top forward) do nothing to alleviate the issue. The lack of ability to "scoot" the entire headrest backwards causes back and neck pain while driving for as little as 10 minutes. One solution people are resorting to is to re-insert the headrest backwards, but the tilting mechanism prevent the head from being stopped and sent backwards in the event of an accident. Another solution is to recline the seat back so much that your back is no longer supported. Again a safety issue. When hitting small imperfection on the road, even in dry weather, the vehicle feels as if it's about to fishtail. Some people have mention the suspension is too slow to compensate for bumps and thus the tire, for a small amount of time, does lose contact with the road. All of this complaints can be found in the f-105 forums: http://www.f150forum.com/f118/
Air leaking noises and high pitch whistles around doors when moving over 40 MPH. Ford says it's normal and I should get used to it.
Since 2015 ford has had an issue with the door locks not latching in cold weather. I have owned my vehicle for a month and a half and have taken it in for service twice now for the same issue. Moisture gets into the locking mechanism and then freezes. After opening the door there is no way of closing it as latches do not grab again or on the other hand they don't release. Twice now I have been out and about and had doors that would not latch. I had to drive around with my 18 month old son's door held closed with a ratchet strap to be able to get home safely. This is a major safety issue and ford needs to solve this.
When its cold only they will not shut the door will bounce back. Dealer try to duplicate problem in a warm garage and pu no problem found on work order. I have been to the dealer twice and no help.
This vehicle as described by the vehicle identification number has a drivers door latch problem, door will not close properly, will open by itself when making a right turn when the outside temp is below freezing. This vehicle is brand new sitting on the dealers lot, there is at least 20 other new vehicles on the lot doing the same thing. This issue should be investigated before someone gets killed. I have been selling fords for thirty plus years, one thing I have learned, the manufacturer will do nothing about it until someone gets hurt.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Ford F-150?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history