2017 Ford F-150 wheels problems

Filed Aug 3, 2026 · Wheels · OH

While driving on the highway on several occasions, the transmission drops from 6th gear to a lower gear, either seeming to slip, or locking the wheels causing a bad jerk. i have an appointment in two days , but am concerned that there may be more damage to my vehicle that will show up later due to this issue. I had another dealership try to charge to to repair my truck. i am hopefull that the new dealership will do right by me.

Filed Jun 15, 2026 · Brakes, Wheels · GA

The contact owns a 2017 Ford F-150. The contact stated that while driving approximately 40–45 MPH, the brake pedal was depressed but responded slowly, resulting in reduced braking performance. The contact became aware that brake fluid was leaking onto the driveway. The brake warning light was illuminated. The contact was concerned about operating the vehicle with the braking issue. Additionally, the driver's and passenger's side front tires and rims were hard to keep clean due to the brake master cylinder leaking black fluid. The contact continuously cleaned the wheels and the rims to prevent the corrosive substance from damaging the tires and the rim. The contact received notification of the federal safety agency Campaign Number: 25V236000 (Service Brakes, Hydraulic). The local dealer was contacted and confirmed that parts were on backorder. The vehicle was not diagnosed or repaired. The manufacturer was contacted; however, no assistance was provided. The failure mileage was unknown.

Filed May 18, 2026 · Electrical, Engine · OH

While driving about 60 mph on the highway, all warning lights on the dash suddenly came on and the truck immediately lost power/shut down. The wheels sputtered or somethting like that, not sure how to describe it. I was able to safely get off the road and restart the truck. After restarting, it drove normally again with no obvious issues. I recently received a recall notice describing very similar symptoms related to the transmission/lead frame issue, but the notice stated no remedy was yet available. This created a serious safety concern because the failure happened unexpectedly at highway speed. Here is the recall info: Issue Date 2026-04-14 Campaign 26S28/26V237

Filed Dec 31, 2025 · Wheels · AK

12/31/2025 the federal safety agency, I am writing to formally report a serious safety issue involving my Ford F-150. On [XXX] in rural Alaska, my Ford F-150 experienced a flat tire in extreme winter conditions (approximately –15°F). I was traveling with my [XXX] child. When we attempted to change the tire, the lug nuts could not be removed using the factory tools provided with the vehicle. A tow truck was dispatched from the only available service on a holiday evening, which was 45 minutes away. The tow operator was then unable to remove the lug nuts with any of his professional equipment. We were subsequently informed that this is a known issue with Ford’s chrome-capped, two-piece lug nuts swelling or deforming, making them incompatible with standard sockets. As a result, what should have been a routine roadside tire change became a prolonged and dangerous situation for my child and me in life-threatening cold. We were stranded for 3 hours and nearly ran out of gas keeping the vehicle warm. It took a blowtorch provided by a passing Good Samaritan to complete the tire changeover. This failure created a significant safety hazard. A vehicle that cannot have a flat tire serviced during an emergency—especially in extreme weather—poses an unacceptable risk to occupants. This was not due to misuse, improper maintenance, or lack of tools, but rather an apparent design or materials defect that rendered the lug nuts unusable. Vehicle details: - Year/Model: 2017 Ford F-150 - VIN: [XXX] - Location of incident: Miles outside of Willow, Alaska This situation placed a minor child at risk in extreme winter conditions and should not occur in any Ford vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 6, 2025 · Fuel system, Transmission · MA

Purchased CPO Ford F150 in 2000 to replace Explorer in MA. Used 4 wheel drive in winter the past two seasons to learn after spending over $1000 and driving a vehicle with reduced MPG due to a known TSP 24-2188 that this is a defect that affects fuel efficiency by close to six miles per gallon. Called Balise Ford after learning updated TSB requires flashing of the onboard TCCM. They would not touch it without charging me. Why can a manufacturer design a flawed system that affects the MPG without providing a free fix? So now I drive a vehicle with a defect grinding metal to metal reducing fuel efficiency by 30% that will require all new parts to replace the parts I replaced in January 2025 for almost $1000 when and if I can ever afford to bring to a FORD dealership to have the TSB corrected at my expense. This also creates a noise that is grinding metal to metal occasionally that is confusing and creates concern about road worthiness and if a wheel will fall off.

Filed Jan 13, 2025 · Steering, Wheels · IL · crash

This is a MAJOR issue with Ford F150s. I am not sure how this was never a recall. Ford issues a TSB for this but NOTHING is the TSB fixes the issue. There is a major fault in the IWE system that causes the 4x4 to engage randomly causing the truck to have major steering issues. It causes grinding, like metal on metal grinding, the steering wheel locks in place at times and I personally almost dies several times from this.The locking steering wheel caused me to crash into a ditch because I could not bring the steering wheel back to center. This has randomly happened to me several times while driving, The TSB claims the issue to be intermittent, which it is due to the fault in this IWE system. FOrd needs to literally cover and replace the entire IWE system before someone gets hurt. Please look this up, this is a very known issue that deserves to be a recall and not a TSB. Please help save lives.

Filed Jan 9, 2025 · Wheels · ID

Lug nuts swollen and unable to remove with provided equipment

Filed Dec 30, 2024 · Engine, Wheels · NC

My 2017 F150 is 7 years old with 80K mileage. Engine problem: Cold start ticking/tapping/rattle noise. Ford claimed it sent a letter in 2021 but I never received. Googled and found there are large amount of the same complaints on 2017-2020 F150 with 3.5L EcoBoost engine. The Cam Phaser / VCT Units will fail. Vehicles may not restart after auto-start-stop. Ford issued Customer Satisfaction Program 21N03 and Technical Service Bulletin TSB23-2143. Those measures are not enough. Ford should recall all 2017-2020 F150 with 3.5L Ecoboost built before Nov 30, 2019. Lug nuts at wheels: Ford used cheap two-piece nuts. All the nuts were swollen in Dec 2024 and could not be removed by myself. I had to drive my F150 to Quick Lane and paid $140 to get all the nuts replaced with one-piece nuts. An employee of Quick Lane told me Ford used cheap two-piece nuts for long time, and it's a common issue on some Ford vehicles. Image if a tire is flat on highway while the nuts are swollen and the flat tire can not be changed! Ford should recall all vehicles using the cheap two-piece nuts. I still keep the old nuts as an evidence.

Filed Nov 6, 2024 · Wheels · 20,000 miles · FL

The contact owns a 2017 Ford F-150. The contact stated that while the dealer was inspecting the vehicle, an unknown dealer informed the contact that the lug nuts were faulty and needed to be replaced. The vehicle was taken to a certified independent mechanic, who replaced the lug nuts with after-market lug nuts. The contact stated that upon taking the vehicle to the unknown dealer for a tire rotation, the dealer informed the contact that the lug nuts had become faulty again. The contact stated that the lug nuts had been replaced three times. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was 20,000.

Filed Sep 24, 2024 · Wheels · SC

My 2017 Ford F150 crew cab listed has chrome wheels on it. Just replaced the original tires on the chrome wheels and the chrome chips off. According to the tire company and the Ford dealer, these wheels are defective and Ford knows about it. The dealer said that Ford has replaced these wheels because of the chrome coming off which makes the wheels weak. I contact Ford customer service and they did not see a recall. Ford recommended a contact national Highway traffic safety association. File a case.