Once transmission gets to operating temperature it shifts funny between 8 9 &10, and when downshifting 7,6 and 5. It's really jerky when downshifting and goes into a kind of neutral on the highway when shifting into 10th
2021 Ford F-150 transmission complaints
Page 8 of 12: complaints 191 to 220 of 329, newest first, as owners wrote them.
Multiple times now while driving at low speed and usually making a right hand turn, the throttle becomes totally unresponsible to driver input. Pressing the throttle does not increase ICE rpm and does not accelerate the vehicle. This has occured while entering active roadways and has created a dangerous situation multiple times. Someone will be injured with these vehicles, it is only a matter of time if this failure to accelerate issue is not recalled and fixed. The date below is only the last incident. I now have over 120K miles and it has done this well over 50 times.
Ford refuses / is unable to resolve Safety Recall 23S65/23V896. Ford has stated solution will be available by 1st quarter 2025. It is now April 12, 2025 and Ford reports no solution date. Recall 23S65/23V896 is a Safety recall. Ford's description: Safety Risk This may initially result in a clicking noise as the bolt becomes loose and a rattle noise from the wheel cap if the bolt breaks. Vehicles with damaged axle hub splines may roll in park without the parking brake applied, or, alternatively, lose drive power, both of which may increase the risk of injury or a crash.
When driving the truck slips out of gear, most often when coasting at low speed, on at least 3 occasions while waiting for oncoming traffic to clear so I can make left turn across oncoming traffic.I ease forward and when coast is clear i hit the accelerator and the engine Revs up but truck does not accelerate until after I let off of the gas pedal and truck RPM go down and I press on gas again. The truck jerks and then the Transmission Grabs. Also when I'm driving and I Switch from normal mode to sport mode the truck says this option is not available and a little wrench icon shows up on the dash, this happened the first week I when purchased the truck, I took it back to the dealership I bought it from and they solved it. But now this(wrench warning) issue has started occur again and I get a message in my fordpass app. If piwertrain malfunction see dealer. When I take it to a Ford dealer they say that they can't reproduce the problem so in their eyes there is no issue, and a week later light comes back on, so I park the truck and make apartment with dealership but the next morning when I get in and start the truck the issue is gone the service power train light goes away. It happens at least 2 times a month lately, and I can't afford to pay the Ford Dealers $400.00 again just to tell me that they can't recreate the issue. Also my recall 23v896 has yet to be addressed and I think this(Powertrain)issue has something to do with it, im hearing the sound that the recall warns about. But all I get from Ford Dealers is a $400.00 BILL.
the bolt on the recall has completely broke. we need a safe vehicle to drive. as stated in recall if continue to drive with broken part it may result in a crash. Manufacturer Recall Number23S65 the federal safety agency Recall Number23V896
The contact owns a 2021 Ford F-150. The contact received notification of the federal safety agency Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2021 Ford F-150. The contact stated while driving 45 MPH, the vehicle made an abnormal knocking sound. The transmission warning light was illuminated. The contact stated that the vehicle was experiencing erratic transmission shifts and was making an abnormal knocking sound while driving. The vehicle was taken to a dealer, where the cause of the abnormal knocking sound could not be determined; however, the failure persisted. The vehicle was taken back to the dealer, where an unknown diagnosis was provided, and unknown repairs were performed. Additionally, the contact stated that the vehicle was difficult to start. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 109,000.
The contact owns a 2021 Ford F-150. The contact received notification of the federal safety agency Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
I’m reporting that this recall repair is overdue and not completed in a timely manner. I was first alerted to the recall in December 2023. There was supposed to be a fix by the first quarter of 2025 and I’ve heard nothing. I have been driving a truck with a defective axle for 4 years. Rediculous!
The contact owns a 2021 Ford F-150. The contact received notification of the federal safety agency Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
10 Speed Transmission has very harsh shifting when accelerating as well as when downshifting. Dealer has looked at it and have been told over and over that it is normal. When downshifting there are time where the shifting creates a lunge affect making you feel that you are going to hit the car in front of you.
Transmission, hard shifting,shifting out of gear wrong when towing sometimes when not Transmission was already overhauled under factory powertrain warranty at around 42000 miles
Terrible hard shifting
While traveling on a local highway in the far left lane, the engine completely died (no engine light came on). I was trying to negotiate traffic while getting to the shoulder of the road, and the transmission began shifting itself into park. I grabbed the shift lever trying to prevent it from going into park; however, it did just as I reached the shoulder of the road. At this point, I had slowed to ~25 MPH, but it still locked the tires up and slid a few feet. After turning the key off, removing it from the truck, and opening the door, I was finally able to restart it and I went straight to my local mechanic. He attached a code reader; however, there were no codes displayed. He stated they probably cleared out when I restarted the truck. This happened a couple of months ago, but my wife has been fussing at me to report it.
Manufacturer Recall Number23S65 the federal safety agency Recall Number23V896 Recall StatusRecall Incomplete, remedy not yet available Mine has already failed once last year all the dealer did was put new parts in but said they still are not updated I tow a camper and it is soon time to tow and I am going on a long trip just want to see when the fix will be in
Whining or whistling noise at idle. Bangs when shifts to lowest gear.
The contact owns a 2021 Ford F-150. The contact stated that while driving at 40 MPH, the rear end of the vehicle started vibrating abnormally. No warning light was illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the alignment had failed. The vehicle was not repaired. The contact took the vehicle to an independent mechanic where it was diagnosed that the rear axle hub bolts were worn and had shifted. The vehicle was not repaired. The contact took the vehicle to the local dealer where it was diagnosed that there was a leak in the rear axle seals. The repair was pending. The manufacturer was notified of the failure, but no assistance was offered. The contact related the failure to the federal safety agency Campaign Number: 23V896000 (Power Train); however, the VIN was not included. The failure mileage was 28,000.
I received this recall December of 2023. I was originally advised that a fix would be ready during the 1st quarter of 2024. I inquired on two occasions about the safety of driving my truck with the axle bolt breaking issue recall. Two separate techs advised me that I could continue driving my truck until a fix to the issue is found but both techs advised not to tow a trailer until it's repaired. I mainly use my truck to tow and usually a couple hundred miles at a time, so this doesn't help me and its now mid-March of 2025.
The contact owns a 2021 Ford F-150. The contact stated while driving at an undisclosed speed, the transmission experienced hard shifting, gear grinding, and slipping gear while accelerating from a red light. The contact stated that the gear shift indicator showed that the transmission was in 10th gear and the vehicle started drifting backward. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 32,000.
The contact owns a 2021 Ford F-150. The contact stated that while driving on the highway at 35 MPH, there was a loud pop from the rear end of the vehicle, and the rear end of the vehicle started vibrating abnormally. No warning light was illuminated. The contact immediately parked on the side of the road to inspect the vehicle and became aware that the driveshaft had fractured in half. The vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was informed that the drive shaft had fractured in half and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 80,200.
Transmission suddenly downshifted from 7th to 1st gear when driving along a highway. This significantly slowed the vehicle down and almost caused a following vehicle to collide with me. The vehicle will also shift from 4th to 3rd violently, revving the engine then slammining into gear. This throws the heads of all occupants a d causes significant early wear and tear on power train components.
Rear axle failed while driving. Had vehicle towed to Malloy Ford in Winchester, VA. They replaced the failed components, at no cost. When I asked about reimbursement for towing, they were not able to assist me in filing my claim for towing reimbursement. I contacted FORD Customer Service, who said they only way they may help me is if I return the vehicle to Ford Service (must be in their possession) and have Ford Service contact them directly and ask for "reimbursement assistance" by 16 Jan. However, stated there is absolutely no guarantee they will reimburse towing. Are you able to assist me? The towing cost was $185.40
I was pulling out into traffic, I eased out to make the turn, when I pressed the accelerator in order to merge to traffic speed, the truck did nothing. It did not stall, the engine was running, but it would not go. The transmission did not act like it was in gear, it is an automatic. I could have been hit by other cars by having my truck sitting in the road. The problem has occurred twice, but I cannot force the issue. it occurs randomly. I am calling service center today 12/17/24 to have it looked at. Vehicle has had the transmission replaced by manufacturer at a factory authorized dealership. There were no warning lights or any indications that the truck was malfunctioning.
The contact owns a 2021 Ford F-150. The contact stated that while driving on a neighborhood street at approximately 25 MPH, a faint whistling sound could be heard from the rear passenger side, and when accelerating the sound progressed. The sound was also present while turning. No warning lights were illuminated. The contact took the vehicle to a tire shop where it was inspected and informed that there was a bolt and washer that had been sheered off causing further damage to the axle of the vehicle. The contact was advised that the vehicle was not safe to drive. The vehicle was then taken to a local dealer where it was diagnosed that the federal safety agency campaign number 23V896000 (POWER TRAIN) was a probable cause for the failure. The contact has stated that the dealer and manufacturer have not been very transparent with the process of remedying the vehicle and received a loaner vehicle. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 62,000.VIN tool confirms parts not available.
The contact owns a 2021 Ford F-150. The contact received notification of the federal safety agency Campaign Number:Â 23V896000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 35 MPH when a loud grinding noise was emitting from underneath the vehicle. The contact had lost power causing the vehicle to drift to the right. The vehicle ended up hitting a trash can nearby before it came to a stop. The air bags did not deploy. There were no injuries or medical attention needed. A police report was not filed. The contact had to place the vehicle in 4-wheel drive mode to be able to continue driving. The vehicle was taken to the dealer who was not able to diagnose the vehicle at the time. The manufacturer was made aware of the failure. The manufacturer had referred the contact to the federal safety agency Hotline to file a safety complaint. The failure mileage was 86,000. VIN tool confirms parts not available.
The contact owns a 2021 Ford F-150. The contact stated that upon starting the vehicle, the Brake warning light illuminated and the "Parking Brake Limited Function - Service Required" message was displayed. The contact immediately drove to a local dealer where the vehicle was diagnosed. The contact was made aware of the federal safety agency Campaign Number: 23V896000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The dealer provided a temporary fix allowing the contact to continue driving the vehicle safely; however, the vehicle had to receive the temporary repair three times. The contact stated that the failure consisted of crunching while shifting gear which occurred after shifting to drive, with a ticking sound progressively becoming worse as the vehicle shifted into the higher gears or in reverse. The manufacturer had provided a loaner vehicle each time the vehicle was taken for temporary repair. The manufacturer was not notified of the failure. The failure mileage was approximately 42,210.
The contact owns a 2021 Ford F-150. The contact stated while driving at an undisclosed speed, the contact heard a loud noise. The contact stated that the gear shifter failed to function as intended. The contact stated that the gear shifter failed to shift into drive or reverse. The contact exited the vehicle and performed an inspection of the vehicle. The contact stated upon inspecting underneath the vehicle, the contact noticed that the driveshaft was fractured. The vehicle was towed to the dealer where it was diagnosed with a fractured driveshaft. The contact was informed that the driveshaft needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the repair was not covered under recall or warranty. The manufacturer was made aware of the failure. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 60,560.
At 30k I noticed the transmission start shifting hard especially when down shifting. I called the dealer and expressed by concerns when doing my normal oil changes. The dealer said it was normal. Now at 42k the truck skips 2nd gear and when shifting between 3rd and 4th it hits hard. Also an independent mechanic shop said the engine is making a weird winding sound. Sounds like the barring in the turbos are going. Again I tell the dealer and they said it's normal for the 3.5 ecoboost to sound like that. Currently it's at the dealer getting the transmission worked on. I know I will be having engine issues, that sound is not normal. I want it on record that it started happening around 30k.
Wheel end hub bolts. Rear axles
Cam Phasers went bad, had to get replaced.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Ford F-150?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history