2024 Ford F-150 brakes problems

Filed Aug 2, 2026 · Brakes, Lights · WA

Purchased new vehicle May 2024 primarily for towing my recreational vehicle (2024 Ford F150 Pickup). June 2024 took vehicle to dealership indicating that I was intermittently getting a "Trailer Disconnect" warning while driving (loss of trailer brakes, lights etc.). Dealer indicated no issue found. Subsequently returned to dealership on 6 other occasions over 2 years after continuing to experience the failure. Replaced 7 pin connector on trailer and dealer has replaced the 7 pin on vehicle and Trailer Control Module (TCM) but problem persists. Early 2026 dealership performed a recall on TCM software - did not resolve the issue (vehicle intermittently indicates the trailer is disconnected while driving or manually activating the trailer brakes). Issue seems to occur typical on startup after several hours of driving with a trailer (heat related), and every time activate the trailer brakes manually. I get a "Trailer Disconnect" warning by activating the manual trailer brake even without a trailer attached. Working with Ford Customer Service Team and the dealership for 7 days, no solution was discovered. The dealership indicated (in writing) that it is normal operation to disconnect the trailer when the TCM is activated manually (while driving or stopped).

Filed Apr 20, 2026 · Brakes · TX

White smoke coming out of rear wheels when driving 80mph. Engine kicks at the same time reducing the speed. Strong smell of brakes at the rear wheels when pulled over. Likely the brakes are engaged at that speed.

Filed Apr 13, 2026 · Acceleration, Brakes · 13,290 miles · NY · crash · 1 injury

The contact owns a 2024 Ford F-150. The contact stated that while his wife was in the process of parking the vehicle on the side of the street, the driver released the accelerator pedal; however, the vehicle failed to stop as intended, jolted forward, and hit one unoccupied and parked vehicle, and hit another occupied vehicle stopped at the stop light. The air bags did not deploy. The driver sustained nerve pain, causing the fingers to become numb, and the driver sustained headaches, back, hips, and shoulder pain. It was unknown whether the other driver sustained injuries. The contact's wife drove to an emergency room after the collision and received medical assistance. A police report was filed. The vehicle was taken to an auto collision repair shop, where it was serviced for the collision damage. An independent mechanic had diagnosed the vehicle with a one-pedal driving system and ABS failures. The vehicle was not repaired. The dealer was not contacted. The manufacturer was notified of the failure and referred the contact to the insurance company for assistance. The failure mileage was 13,290.

Filed Apr 2, 2026 · Brakes, Electrical · IL · crash

As I went to reverse to pull out of a parking area, the truck accelerated, I applied the brakes and the truck continued going dragging the front tires at one point. I decided at the last min to attempt to put the truck in neutral or park and at that time it was stopped between two trees. This could of been very bad if my kids were in the yard playing or many other scenarios. The 2024 F150 is still at the dealership waiting on approval to do body work. We have requested they run diagnostics or telemetry on the trucks systems to verify the problem but after a month that has not been done yet.

Filed Mar 12, 2026 · Acceleration, Brakes · CA · crash

Three incidents happened with this vehicle. When I put the car on reverse and reversed and stopped, the gear was then put on drive and before the accelerator was stepped on the vehicle propelled itself at a very high speed and I had to emergently step on the brakes before it hit anything. The the front collision warning did not come on and the vehicle did not brake on its own. The same thing happened in our driveway and before we could apply the brakes the vehicle crashed into a tree. This time also the front collision warning did not come on and the vehicle did not brake and went and hit a tree. There was a video that captured this incident and was shown to our Ford dealership and they did not do anything about it. We told them that the vehicle accelerates by itself and is a safety hazard. Since this did not involve any other vehicle or pedestrian the hazard was limited only to ourselves, The insurance was charged more than $10,000 to fix the damages and we also had to pay a deductible of $1000. More importantly we are unaware if this has been reported by others and can cause serious injuries to the driver, occupants of the vehicle and other who may be involved inadvertenly. Any death caused will become the responsibility of the driver even though this was not the mistake of the driver.

Filed Jan 26, 2026 · Brakes, Electrical · CO

I purchased this vehicle new 7/31/25. Within the first week of ownership I noticed a noise coming from the rear axle. Brought into Ford dealer for diagnosis at 723 miles: tech notes indicated that the abs tone ring was not manufactured correctly and was hitting the ABS wheel speed sensor. The sensor had visible impact marks. The rear axle assembly was replaced under warranty. The repair took over 10 days. At this point I was concerned about the Q/C and build quality of the vehicle. I asked Ford for an extended warranty as a goodwill gesture, which was denied. This failure was related to a Federally regulated safety system: ABS brakes. ~5 months later on 1/8/26 (12, 336 miles), I attempted to place the vehicle in park using column shifter, a service light came on and the truck was not responding to the shifter input. I turned the truck off with the parking brake engaged, restarted truck and another warning light came on saying place vehicle into park. The truck would not start and I was left stranded without warning. The vehicle was towed to the nearest dealer. Diagnosis revealed the shifter module was faulty and needed to be replaced. Ford had a TSB about this issue. The repair took 7 days. At this point I'm extremely concerned about the reliability of this vehicle. This has been two major failures within less than 6 months of ownership. Ford contacted me asking how my experience was with the vehicle. I informed them I was very disappointed and had safety concerns. I asked for an extended warranty which was denied. I then escalated the ticket to asking for a voluntary buyback from Ford. Ford notified me that I didn't meet the criteria for a voluntary buyback and the claim was denied. Due to the repeated failures I do not feel safe continuing to drive this vehicle and I want Ford to step in and assist with this matter.

Filed Jan 20, 2026 · Brakes, Driver assistance · MI · crash

Was driving with my son when pulling up in my driveway I had my foot on the brake when all of a sudden the brakes went to the floor and my truck began to continue slowly up the driveway would not stop and drove into my garage door and damaging my garage door had called ford roadside assistance took it to the shop and they had to replace the brake booster

Filed Dec 8, 2025 · Brakes · TX

Since 28 June 2026, there has been an issue with braking system. I called the local Ford dealer twice and was told there has been no reported brake issues with 2024 Ford F-150. The first time this happened, I was driving on a county (dirt road) and I applied the brakes, and the brakes did not work. Thankfully, there was no traffic and I coasted to a stop. The same problem with the brakes has happened four more times.

Filed Oct 30, 2025 · Brakes, Driver assistance · CA · 1 injury

I’ve now had two major safety issues with my 2024 Ford F-150 STX. 1. September 2025 – Loss of Acceleration While Driving I was driving north at about 40 mph when my truck suddenly stopped accelerating. It felt like it went into neutral on its own. I pressed the gas and nothing happened — the truck just started coasting. There were no alerts, no warning lights, and no explanation. I had to safely pull off the road while the truck was basically free-rolling. 2. Most Recent Incident – Emergency Brakes Slamming On in an Empty Parking Lot When I was leaving a facility recently, I was driving slowly through an empty Walgreens parking lot — no cars or obstacles anywhere around me. Out of nowhere, the truck’s emergency brakes slammed on extremely hard. It didn’t just happen once — the brakes locked up five times within about a minute while I was in Drive. There were zero warning messages on the dash each time. The jolts were so violent that my son flew forward and hit the seat in front of him. My right leg slammed into the dash, and the impact was so strong I ended up in the ER afterward with severe pain on my right side.

Filed Sep 20, 2025 · Brakes · UT · crash

3 weeks after purchasing a brand new 2024 F150, brake light, ABS, traction control, Hill start assist, antilock brake fault pre-collision assist warnings all illuminated and sounded. Took an exit and had no brake control. Went into a ditch and hit a piece of metal, causing minor body damage to my new truck. Vehicle is being worked on and electronic brake booster is being replaced. Battery was not installed properly/connected tightly. Grounding issue also found.