2006 Ford F-250 SD technical service bulletins
105 technical service bulletins and manufacturer communications cover the 2006 Ford F-250 SD.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all...
- Accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions
- These SKUs are Trailer Brake Control Modules
- Accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions
- This SKU is a Spare Tire Hoist
- Concern during or after programing the VSM. The programming may fail or vehicle symptoms such as...
- Accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions
- This SKU is a front upper ball joint
- Some 2005-2017 f-super duty 4X4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit...
- Exterior Mirror
- Lincoln/ford: when driving from idle up to 1200 RPM, there may be an intermittent rattle noise coming from...
- Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a...
- Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21,...
- Ford trucks service campaign: vehicles have experienced severe steering wheel and front wheel vibrations...
- Ford: some super duty trucks equipped with a 5.4L 3V or 6.8L 3V engine may experience premature automatic...
- Ford: 6.0L diesel hard start/long crank/no start du to low injector control pressure (ICP)
- Ford truck: some trucks equipped with a 6.0L diesel engine may exhibit a hard start/long crank or no start...
- 1999-2008 7.3L/6.0L/6.4L/4.5L diesel f-super duty - clean the charge air cooler (CAC) system after certain...
- 2005-08 F250-550 super duty manual transmission - clutch pedal concern
- 6.0L turbocharger carbon deposit diagnostics and service tips
- 1999-2008 F250-F550 super duty 4X4 with electronic shift transfer case not engaging 4X4
- 2005-2008 f-super duty manual transmission- clutch pedal concern
- 6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK of power or surge with some 2003-2007 f-super duty,...
- Stuck or jumping/bouncing/erratic speedometer and/or tachometer
- Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes
- Buck/jerk when pulling large heavy gooseneck trailers
- Rear of vehicle is too high/low -5TH wheel and goose neck applications
- 6.0L diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct
- ABS light on and possible C1175, C1236, P0500,P0503
- Adding additional bulbs to turn indicator or hazard flasher circuits
- Power steering pump pulley alignment
- Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start
- 6.0L oil seep or boost pressure leak at hot side charge air cooler duct
- Lack of power due to low fuel pressure - fuel tank liner seperation
- Steering wheel oscillation
- High pressure system diagnostics - 6.0L engines
- 6.0L turbocharger carbon deposit diagnostics and service tips - lack of power, white or black smoke,...
- Hesitation, runs rough, or surge either on acceleration or during idle in gear and occurs right after...
- 6.0L - MIL on with DTC P2138, P2139, and P2140
- Lack of cooling fan operation
- Service calibration update - loss of RPM on deceleration - 6.8L
- Service calibration update - loss of RPM on deceleration - 6.8L
- 6.0L - reduced engine performance - high altitude
- Air filter water ingestion / snow packing with codes P0103
- Lack of power due to low fuel pressure, fuel tank liner seperation
- Diagnostic trouble codes (DTC) P0340, P0344, P0345, P0349
- Buck/jerk steady throttle or slight tip in 6.0L
- Power steering fluid leak at jumper line to hydroboost connection
- Lack of power or lack of performance condition when operated above 5,000 feet of altitude
- Misfire and DTC P0300
- Watch for oil flow from the base engine oil pump
- Front wheel bearings - noise
- Some vehicles have vehicle certification labels that show an incorrect vehicle build date
- Repeat turbocharger or vgt replacement
- Oil flow from the base engine oil pump
- Runs rough or misfire due to a stuck valve
- Tachometer sticks or intermittently inaccurate
- Stuck speedometer
- Lack of power or MIL on - turbocharger sticking - revised diagnostics
- 18 inch conti tr all-terrain tires
- DTC B2900 or B2477 - service tip
- P0404 service tip
- White smoke, lacks power, exhaust odor, surges, runs rough, or no start - 6.0L
- Diagnostic procedure for trailer tow lights or no power due to open fuse
- Neutral tow capability -- service kit requirements
- Exhaust smoke and/or smell, harsh transmission shifts -- 6.0L
- Service calibration update -- loss of RPM on deceleration -- 6.8L 3V
- MIL on with DTC P0460 -- 6.0L
- Customer satisfaction program 05B35 - the engine control modules may not be calibrated to the latest...
- Bearing & sensor assembly - ABS sensor is available for service - base part number 2C204
- Fuel conditioner
- Part changes on vehicles built after january, 2006
- Diagnostic trouble codes P0340/P0344/P0345/P0349 - 4.6L 3V and 5.4L 3V
- Coolant degas bottle overflow - 6.0L
- Buck/jerk steady throttle or slight tip in - 6.0L
- High pressure system diagnostics - 6.0L for a hard start/long crank or no start condition due to low...
- Stuck or jumping / bouncing / erratic speedometer and/or tachometer
- Neutral tow capability - service kit requirements
- Misfire, lack of power, buck/jerk, excessive smoke or crank/no start
- 6.0L - MIL on with DTC P0460
- 6.0L - MIL on with DTC P2138, P2139, P2140
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Buck/jerk or surge - 6.0L vehicles built before 8/22/2005
- Drive away shudder or vibration
- Service kit available for wiper motor wiring
- Malfunction indicator lamp, diagnostic trouble codes P0172, P0175, P2106, hesitation, surge, harsh drive...
- Diagnostic trouble code P2106, harsh drive engagements, transmission shudder - 5.4L 3V engine
- Coolant degas bottle overflow
- Vacuum pump inoperative or runs continuously - climate control defaults to defrost mode
- Trailer brake controller applications
- Hard start, no start and/or other symptoms caused by a high pressure oil system leak - service tip
- Torqshift transmission - intermittent clunk when shifting from reverse gear or drive gear to park
- Headlight adjustment - chassis cab incomplete vehicles
- Safety belt retraction speed
- Lack of power and/or DTC P2263 or P0299 after turbocharger replacement - service tip
- A driveline clunk or bump when starting from a stop
- Diesel exhaust smell in CAB-6.0L engine
- Diagnostic trouble code (DTC) P0340 and or P0344-5.4 3V engine
- Oil leak or boost pressure leak at hot side charge air cooler (CAC) DUCT-6.0L diesel engine
- Lack of air conditioning cooling - climate control mode selection not working
- 5.4L 3V with P030X and/or P0316 accompanied by spark knock
- Vibration diagnosis - tire/wheel runout
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Ford F-250 SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history