2017 Ford F-250 SD engine problems

Filed Feb 20, 2026 · Engine · 190,000 miles · CA · fire

The contact owned a 2017 Ford F-250. The contact stated while driving 22 MPH and attempting to depress the brake pedal, the brake pedal was firm and difficult to depress. The brake pedal was depressed with both feet and the vehicle started slowing down. There was no warning light illuminated. After coming to a complete stop, the contact saw smoke coming from the grill underneath the windshield wipers and the lower windshield. The contact exited the vehicle and there was fire coming from the engine compartment and entering the cabin of the vehicle. The contact exited the vehicle, ran to the neighbor’s house and grabbed the garden hose and started spraying water on the hood; however, smoke and the fire increased and the fire was too hot for the house to put out the flames. The contact called 9-1-1 for assistance and the Fire Department arrived on the scene and extinguished the Fire. The Police showed up on scene to direct traffic. There was no injuries sustained. A Police Report was filed, but the report number was not provided. The vehicle was towed to the residence. The vehicle was destroyed. The manufacturer was informed of the failure and opened a case and provided the contact with the case number. The failure mileage was approximately 190,000.

Filed Oct 20, 2025 · Brakes, Engine · FL

While pulling a 38ft 5th wheel camper on an incline with the cruise control set at random the vehicle completely dies. It experiences a total shutdown of the engine, which in return causes a complete loss of power steering, brakes etc. The truck will not restart until you push the off button and open the drivers door to shut the entire system down

Filed Sep 24, 2025 · Engine · 95,000 miles · MO

The contact owns a 2017 Ford F-250. The contact stated that while operating the vehicle, the check engine warning light remained illuminated. The vehicle was taken to the local dealer, who diagnosed that the EGR valve was faulty and needed to be replaced. The contact indicated that while the EGR valve was being replaced, the bolts connecting the EGR valve to the exhaust intake fractured and also needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 95,000.

Filed Jun 27, 2025 · Engine · 57,000 miles · MO

The contact owns a 2017 Ford F-250. The contact stated that while the vehicle was parked, the vehicle stalled. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that the engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 57,000.

Filed May 28, 2025 · Engine · ME

Nox sensor failure at 43,000 miles. Eventually leads to loss of power and idle only operation of the vehicle. Looking online shows that these fail constantly, many many reports. Same issues with other makes. Mercedes for instance has increased coverage to 15 years or 150,000 miles on their diesels.

Filed Mar 5, 2025 · Electrical, Engine · CA · fire

On Tuesday, [XXX], at approximately [XXX] PM, I was driving southbound on [XXX] near Coalinga, CA, when my truck suddenly experienced a failure. I noticed smoke in the side mirror and asked my passenger to confirm. Moments later, a "Low Fuel Pressure" message appeared on the dashboard, and smoke began coming from the hood. I immediately pulled over and attempted to pop the hood, at which point flames erupted from the engine bay. The fire quickly spread, fully engulfing the vehicle within minutes. Emergency responders, including Cal-Fire and CHP, arrived on the scene. The truck was towed by Cal-State Towing Service in Huron, CA. The Fire Captain on site provided an incident card, but the full fire report is expected to take at least a week to obtain. There were no prior indications of mechanical issues before this incident, and no recent repairs or modifications to the fuel system or engine. However, I recently became aware of an ongoing the federal safety agency investigation into fuel leaks and fire risks in Ford Super Duty trucks equipped with the 6.7L diesel engine (TFL Truck Report). The investigation highlights a potential issue with fractures in the secondary fuel filter housing, which could lead to fuel leaks and fire hazards. Given that my truck displayed a Low Fuel Pressure warning immediately before catching fire, I strongly suspect this failure may be related to the issue under investigation. The truck is currently in tow yard storage and is available for inspection upon request. This incident posed a serious safety risk to myself, my father and others on the roadway, and I believe it warrants further examination by the federal safety agency. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 22, 2025 · Engine · TX

When it’s gets cold. The o rings inside coolant pipes start leaking on these trucks. There should be a recall for this.

Filed Feb 3, 2025 · Engine · 55,000 miles · WV

The contact's husband owns a 2017 Ford F-250. The contact stated that while her husband was performing an oil change on the vehicle, an abnormal knocking sound started coming from the engine. There was no warning light illuminated. Due to the failure, the vehicle was towed to a dealer where the vehicle was diagnosed with a defective intake manifold. The contact was then provided an estimate for the repair. The manufacturer was notified of the failure and the contact was informed that the warranty on the vehicle had expired. The contact was then referred to the federal safety agency Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 55,000.

Filed Jan 24, 2025 · Engine, Fuel system · VA

The contact owns a 2017 Ford F-250. The contact stated while driving 65 MPH and hauling two horses in a horse trailer, the vehicle stalled inadvertently. The contact was able to pull over to the side of the road, where the check engine warning light illuminated, and the message "Reduced Engine Power" was displayed. The vehicle failed to restart and was towed to Lee’s Body Shop, where it was diagnosed that the CP4 fuel module had failed. The autobody repair shop recommended that the CP4 fuel module, the fuel lines, and the particulate filter be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a related recall. The manufacturer referred the contact to the federal safety agency Hotline for assistance. The failure mileage was unavailable.

Filed Oct 29, 2024 · Engine · 74,000 miles · IL

The contact owns a 2017 Ford F-250. The contact stated that while his son was operating the vehicle, the check engine warning light was illuminated. The vehicle was taken to an unknown local dealer, where the engine sensor was replaced, but the failure later reoccurred. No further information was available. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 74,000.