The contact owns a 2017 Ford F-250. The contact stated while driving 15 MPH, the vehicle almost stalled. There were no warning lights illuminated. The contact's vehicle stopped in traffic and then failed to respond. The contact attempted to restart the vehicle and the message “Low Engine Power Pressure” was displayed. The vehicle was then towed to an independent mechanic who diagnosed the vehicle with catastrophic fuel system failure. The vehicle was not repaired. The dealer was made aware of the failure. The manufacturer was made aware of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 61,000.
2017 Ford F-250 SD fuel system complaints
Page 2 of 3: complaints 11 to 40 of 54, newest first, as owners wrote them.
I own a 2017 Ford F-250 6.7L Power Stroke Diesel with a CP4 fuel pump that recently failed. Ford has already recalled this exact part for 2020-2022 models (Recall 24V‑841) due to known defects, but they refuse to assist owners of earlier models like mine, even though the issue is the same. The CP4 failure can cause sudden fuel system failure, which is dangerous while driving. Ford should extend the recall to cover all affected vehicles before more owners are left with costly repairs or safety risks.
The contact owns a 2017 Ford F-250. The contact stated that while driving at an undisclosed speed, the steering wheel became stiff and difficult to turn in either direction. In addition, the contact stated that the vehicle lost automotive power. The contact was able to veer over to the shoulder of the roadway; however, the vehicle failed to start and was towed to the residence. The message "Low Fuel Pressure" was displayed on the instrument panel. The vehicle was towed to a local dealer where it was diagnosed that the CP4 high-pressure fuel pump needed to be replaced. The vehicle was repaired at the owner's expense. The local dealer was contacted and informed that the failure was a manufacturing defect; however, the vehicle was not diagnosed or repaired. In addition, the vehicle was inspected at the scene by a certified Ford mechanic who determined there was metal shavings inside the fuel injector, fuel pump, and the fuel system was flushed. The contact related the failure to the federal safety agency Campaign Number: 24V957000 (Fuel System, Diesel); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 156,000.
On Tuesday, [XXX], at approximately [XXX] PM, I was driving southbound on [XXX] near Coalinga, CA, when my truck suddenly experienced a failure. I noticed smoke in the side mirror and asked my passenger to confirm. Moments later, a "Low Fuel Pressure" message appeared on the dashboard, and smoke began coming from the hood. I immediately pulled over and attempted to pop the hood, at which point flames erupted from the engine bay. The fire quickly spread, fully engulfing the vehicle within minutes. Emergency responders, including Cal-Fire and CHP, arrived on the scene. The truck was towed by Cal-State Towing Service in Huron, CA. The Fire Captain on site provided an incident card, but the full fire report is expected to take at least a week to obtain. There were no prior indications of mechanical issues before this incident, and no recent repairs or modifications to the fuel system or engine. However, I recently became aware of an ongoing the federal safety agency investigation into fuel leaks and fire risks in Ford Super Duty trucks equipped with the 6.7L diesel engine (TFL Truck Report). The investigation highlights a potential issue with fractures in the secondary fuel filter housing, which could lead to fuel leaks and fire hazards. Given that my truck displayed a Low Fuel Pressure warning immediately before catching fire, I strongly suspect this failure may be related to the issue under investigation. The truck is currently in tow yard storage and is available for inspection upon request. This incident posed a serious safety risk to myself, my father and others on the roadway, and I believe it warrants further examination by the federal safety agency. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2017 Ford F-250. The contact stated while driving 65 MPH and hauling two horses in a horse trailer, the vehicle stalled inadvertently. The contact was able to pull over to the side of the road, where the check engine warning light illuminated, and the message "Reduced Engine Power" was displayed. The vehicle failed to restart and was towed to Lee’s Body Shop, where it was diagnosed that the CP4 fuel module had failed. The autobody repair shop recommended that the CP4 fuel module, the fuel lines, and the particulate filter be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a related recall. The manufacturer referred the contact to the federal safety agency Hotline for assistance. The failure mileage was unavailable.
The Fuel Pump Failed , yes it is available for inspection upon request. Truck cut off in middle of busy road way , unable to move to shoulder creating a high risk to be hit or someone to be hit . Independent service center diagnosed was made aware this is a common problem . No warning lights or previous symptoms before engine cut off . We have been informed this is a recurring issue with Ford F250 creating a dangerous enviorment when driving for the driver and all other vehicles on the road .
â The contact owns a 2017 Ford F-250. The contact stated while driving at approximately 40 MPH, the vehicle lost automotive power. The contact related the failure with Manufacturer Campaign Number: 21m01. The contact stated that the dense sensor indicated diesel emission fluid was full when it was not. The check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with a reductant level sensor failure. The local dealer was contacted; however, the vehicle was not repaired due to costs. The contact stated that the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 108,000.
1 .Driver's side door will not close in cold weather due to frozen actuator. TSB has been issued on this problem; Ford will not repair due to vehicle being out of warranty. 2. Backup/vehicle camera's do not always work when truck is in reverse. TSB has been issued on this problem; Ford will not repair due to vehicle being out of warranty. 3. Ford inadvertently installed a substantially smaller fuel tank on my specific vehicle. TSB has been issued on this problem; Ford will not repair due to vehicle being out of warranty.
The CP4 fuel pump began failing with the truck just over 100K miles. When taken in for routine service there were traces of metal shavings in my fuel. This is a widely known problem with the CP4 and is still being used in Ford trucks. The cost of repairs is substantial. The best case is you catch it early and it only costs between $3-6,000. If I had not caught this and the entire fuel system had been damaged, my local Ford dealership informed me it could cost close to $16,000. This is a devastating amount of money to pay for a well known issue in Ford trucks.
The contact owns a 2017 Ford F-250. The contact stated that after driving approximately 50-65 MPH and pulling into a business parking lot, the contact became aware that there was a trail of fuel on the ground. The contact inspected the vehicle and became aware of fuel leaking underneath the front of the vehicle between the tires. The contact drove to the nearest independent mechanic, where it was diagnosed that the upper fuel filter had fractured and was leaking. The mechanic replaced the fuel filters, and the vehicle was repaired. The dealer was not contacted. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 136,942.
The hose connecting to the fuel filter in the engine compartment came off and dump fuel all over the engine. Luckily we turned it off before a fire started. This has happened 3 times now.
I have been made aware of the probe involving 2015-2021 Ford Super Duty pickups where the fuel filter housing and fuel lines have cracked. I wanted to make you aware that in November 2023, my vehicle suffered the same part failure. Park Ford in Tallmadge Ohio did the repair and I paid for it out of pocket. It was significant and I had diesel fluid leaking profusely. My vehicle is a 2017 Ford F-250 with the diesel engine and at that time only had approximately 50,000 miles on it. I thought it was odd that this part failed. I see it may not have been an isolated occurrence. I wanted to add my complaint to those being investigated by your agency.
This is the third time i have had to tow this vehicle in less than a year and half for a Long Crank no start. The fixed a melted wiring harness the first time. Second time couldn't tell me what the problem was but got it running and then now its back at the dealership again for the same problem.
The contact owns a 2017 Ford F-250. The contact stated while driving at an undisclosed speed, the vehicle failed to exceed 20 MPH, with the vehicle losing motive power. The contact stated that the gas light pump icon and the engine power reduced message were displayed. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the high-pressure fuel pump had imploded, resulting in metal being found in the fuel system. The mechanic stated that the fueling system needed to be replaced. The vehicle was not repaired. The dealer was contacted but no diagnostic test was performed. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the federal safety agency Hotline. The failure mileage was approximately 142,000.
The contact owns a 2017 Ford F-250. The contact stated while driving 60 MPH, the vehicle shut off. The reduced engine power warning light was illuminated. The vehicle was towed to a dealer service center. The vehicle was diagnosed stating the fuel injectors needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the federal safety agency Hotline. The approximate failure mileage was 140,000.
The engine light activated on the dash randomly while driving. My truck was experiencing loss of power and for the next few days and reduced fuel mileage. I checked the engine code and learned it is a common error with 2017 Ford Super Dutys with the 6.7L diesel engine. The code is “DTC P203B”, sometimes indicated as P203B00 is an OBD diagnostic trouble code indicating a manufacturer-specific fault with the vehicle powertrain (i.e. engine and gearbox). This code identifies an error with the air/fuel mixture causing reductant level sensor circuit range/performance. I believe this error in manufacturing is a safety risk because it is common within these trucks and can leave motorists stranded or potentially disable the vehicle in the roadway causing a traffic hazard.
The contact owns a 2017 Ford F-250. The contact stated that while driving at approximately 60 MPH, the vehicle lost motive power and stalled. There were no warning lights illuminated. The vehicle was towed to the residence. The vehicle was then towed to an unknown local dealer where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was not repaired. The vehicle was towed back to the residence. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the fuel injector and high-pressure fuel pump needed to be replaced. The manufacturer was contacted and referred the contact to the federal safety agency Hotline. The failure mileage was approximately 139,000.
While responding my personal vehicle to a motor vehicle collision (volunteer first responder) my 2017 f250 lost all power at 70+ miles an hour on a highway. Power steering and power brakes were not functioning and caused a delay in service to the community. Mechanic diagnosed it as a contaminated fuel system from the problematic Bosch CP4 pump, which Ford is well aware of. They even have a “kit” to fix this issue costing well over $6,000. This is a major safety issue when all power is lost especially if towing trailers.
The contact owns a 2017 Ford F-250. The contact stated while driving approximately 70 MPH, the vehicle stalled. Additionally, the vehicle lost power steering functionality. The contact stated no warning light was illuminated. The contact was able to move the vehicle off the highway. The contact had the vehicle towed to a local dealer, where it was diagnosed that metal shavings were found in the fuel pump and determined that the fuel pump needed to be replaced. The vehicle had not been repaired. The contact stated that two weeks prior to the failure, the vehicle had been taken to the same dealer to be diagnosed and repair a fuel leak from the fuel injectors. The contact stated that the fuel leak had been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 80,000.
Engine light keep coming on and I was losing power. I had to spend $10,000.00 getting it fuel filter system had metal savings. I need to be reimbursed for this problem, when I took it in the shop to get it fixed. They stated 2017’s had this problem come on Ford I love my truck and very sad that I had to spend this amount of money. Please contact me with your help [XXX] [XXX] [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
The contact owns a 2017 Ford F-250 SD. The contact stated that there was an unknown fluid on the ground underneath the vehicle. The contact started that vehicle and became aware that diesel fuel was leaking from the fuel tank. The vehicle was not diagnosed. The dealer was contacted and stated that the vehicle needed to be diagnosed. The manufacturer was contacted and stated that the vehicle was not included in the federal safety agency Campaign Number: 16V778000 (Fuel System, Diesel) and advised the contact to call the federal safety agency Hotline. The approximate failure mileage was 69,000.
vehicle looses power and shuts down while driving.....fuel injection kit is not available for purchase. Part number is HC3z9b246b to correct problem is on back order and no estimate on when part will become available. The truck has been at the dealership for 5 weeks. A hugh company like Ford this is totally unacceptable and dangerous say the least
Connectors on upper fuel filter cracked and diesel was spraying all over the engine compartment.
The contact owns a 2017 Ford F-250. The contact stated that while driving approximately 70 MPH in a construction zone, the messages "Low Fuel Pressure" and "Reduced Power" were displayed, and the vehicle decelerated to 5 MPH. The vehicle then lost motive power. The driver was able to veer to the side of the road downhill. The vehicle was towed to the residence. The local dealer was not notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.
There is a pin hole in the center of plastic housing for the upper fuel filter on my 2017 F250 diesel. Shoots fuel out when driving. Very dangerous. Appears to be similar to the 2022 ford diesel fuel filter recall.
After driving for over an hour at highway speed, I smelled something but could not determine what it was. The next day I drove around town and once when I pulled up to a traffic signal, I noticed the smell again and some light smoke coming from the front of the truck. When I got home, I opened the hood and diesel fuel was dripping off the hood insulator and running all over the engine and around the seals around the hood. I cranked the engine again to see if I could determine where it was coming from and a saw a stream shooting straight up from the center of the engine. I took it to a local Ford dealership, and they repaired it. The top of the fuel filter mounted in the top center of the engine ruptured and sprayed diesel all over the engine. I left the part at the dealership after the repair. There were no dashboard warnings and there was no change in vehicle responsiveness in pressing the accelerator. When I returned from the dealership, the diesel that had spilled reached the exhaust system and smoke came out from under the center of the truck. It half-emptied the fuel tank in 3 days. I know diesel in not as volatile as gasoline, but this was still a dangerous situation.
As I was driving down the road, I started to smell diesel fuel. No warning lights were illuminated on the dash. I pulled over and found that diesel fuel was leaking under the truck from under the engine. When I checked under the hood, I found that the secondary diesel filter had a stream of diesel coming out of it. I was able to safely get the vehicle home and started researching online, I found that this was a common problem but was not issued as part of a recall from Ford. I did find that the part was simple to replace so I performed the replacement myself. Unfortunately, I discarded the faulty part so it is not available for inspection but this is a common issue which many have experienced and I believe that finding a faulty filter will be easy. I am in contact with someone that has one on hand.
Fuel filter cracks on the top and squirts diesel fuel all over engine bay. Happened once at 35k miles and then happened again at 44k miles. Very dangerous considering it can start a fire and no lights turned on.
The contact owns a 2017 Ford F-250. The contact stated that there was fuel leaking from the fuel filter cap into the engine. The vehicle was taken to an independent mechanic and diagnosed that there was a manufacturer's defect with the secondary fuel filter cap. The secondary fuel filter and fuel filter cap were replaced. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The failure mileage was 44,458.
truck has less than 60,000 miles. Driving along the hiway with grand daughter, going to dance , truck dinged said reduced power,and started losing power started to pull over and engine died, battery light came on, went to get out out some one driving by said get out your truck is on fire, as i got out could see fire smoke, coming from area under engine on left hand side, fire was dripping out . Popped hood release, but now less than a 2 minutes later from reduced power had fire boiling out under the hood. one person had a fire ext and we sprayed in the crack of the hood, as too hot to get hood open, paint was turning colors, by time fire dept got there, the truck was engulfed in fire, loud explosions going on, windows has already blow out left hand side tire on fire. By the time Port Lavaca Texas 77979 fire dept got the fire out, nothing left of the truck. but rear bed. Truck had bee going in Regeneration a lot lately , While waiting for Grand Daughter to come out of school in 10 min, it went in and out of Rengen several times with weird, rpms rise and drops. Drove fine, when we left school. was app. 18 miles from home when the truck said reduced power and started to slow down and died. Called Ford customer care, got passed on twice to different parts, then told Office of general counsel would call. after a week i called back could not get a phone number to call. only a fax. when office of general counsel did call about 11 days later, the guy would not give me his name, a phone number, a email address, told him Video on youtube of 2016 ford Test truck in Cal. on side of road, 6.7 diesel i had seen same thing started under the engine compartment and burnt to ground. See several more post about them catching on fire, all around same age and all 6.7 diesels . Then he said just tell your insurance sub ligation, and let them handle it since i had insurance. Calhoun county Texas Sheriffs office and Port Lavaca Texas fire dept has the reports,
VIN decoder
See the problems and recalls for an exact car
Buying a used 2017 Ford F-250 SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history