2000 Ford F-350 SD fuel system problems

Filed Mar 28, 2016 · Fuel system · 102,000 miles · WV

Tl* the contact owns a 2000 ford f-350 sd. The contact stated that located under the fuel filter, the o-ring and the drain line failed on more than one occasion. The vehicle was taken to the dealer more than twice and they were not able to replicate and diagnose the failure. The vehicle was taken to an independent mechanic who replaced the drain line and indicated that there was too much pressure flowing into the fuel filter. The manufacturer was notified of the failure. The VIN was not available. The approximate failure mileage was 102,000. Updated 05/10/16*lj updated 11/3/2017

Filed Jun 16, 2014 · Fuel system · 130,000 miles · MO

Tl* the contact owns a 2000 ford f-350 sd. The contact stated while driving various speeds the vehicle stalled although the fuel level was at capacity. The contact took his vehicle to an independent mechanic and the dealer who both stated that having less then 5% bio diesel would cause the failure to occur. The manufacturer was made aware of the failure. The vehicle was repaired. The failure mileage was 130,000. The current mileage was 200,000.

Filed Jun 25, 2013 · Fuel system · 175,000 miles · IL

I was traveling down the highway at 60 miles per hour when I heard a large bang. I stopped and didn't see anything until I stopped for gas. Gas was leaking out the fill hose and I looked under the truck and the gas tank strap had broke and the tank was verily hanging on. I purchased two straps to hold the tank in place until I could get to a ford dealership. This is the same problem that ford recalled the 150 and 250 models for. Luckily for me the tank did not rupture and catch fire. The 350 needs to be recalled to fix this problem before someone is killed.

Filed Jun 18, 2013 · Engine, Fuel system · 86,000 miles · NC

This issue was on a 2000 ford f350 rescue truck on route to emergency call when engine shut down and lost all power like it was out of fuel 7.3 liter diesel and tank was full. Had unit towed to garage in king nc and $900.00 later after new fuel tank fuel filter and fuel pump to liner inside of tank came off and clogged the fuel system and engine ford motor company was no help and said since the vehicle was out of warranty they would not do anything to resolve the cost issues.

Filed Jun 18, 2013 · Engine, Fuel system · 160,000 miles · NC

This issue was on a 2000 ford f350 ambulance on route to emergency call when engine shut down and lost all power like it was out of fuel 7.3 liter diesel and tank was full. Had unit towed to tabs garage in king nc and $1700.00 later after new fuel tank fuel pump 3 injectors due to liner inside of tank came off and clogged the fuel system and engine ford motor company was no help and said since the vehicle was out of warranty they would not do anything to resolve the cost issues.

Filed Oct 6, 2011 · Fuel system · 145,000 miles · PA

Tl* the contact owns a 2000 ford f-350 sd. While driving approximately 35 MPH, the contact heard a noise from the rear of the vehicle. The contact stopped the vehicle to inspect the noise and noticed that the front fuel tank strap was corroded and fractured. The vehicle was not taken to the dealer for diagnostics. The contact referenced the federal safety agency campaign id number: 11v385000 (fuel system, gasoline:storage:tank assembly:mounting) that and contacted the manufacturer but was advised that the VIN was not included in the recall. The vehicle was not repaired. The approximate failure mileage was 145,000. Updated 11/03/11*lj updated 12/02/11

Filed May 10, 2011 · Fuel system · 120,000 miles · MA

Fuel tank strap has broken again.2nd time for the rear strap,front replaced 1 time. Also replaced gas tank in 2006 due to leak from rusting at seam,tank is starting to leak again. Tank dropped to the street when strap gave way last time,luckily I was going slow on a side street. Speaking with other owners of these trucks,f-350 superduty 2000 cab and chassis most are having or have had the same issues I am having.

Filed Feb 22, 2011 · Electrical, Engine · MT

2000 ford f-350. Consumer writes in regards to factory recall, cam sensor/cam parts and replacement *tgw the consumer stated within days of purchasing the vehicle, it was inoperable as a result directly relating to and stemming from a specific recall regarding the camshaft. Ford sent the consumer a recall letter two years later. The consumer also stated the vehicle had an electrical and fuel problem.

Filed Mar 1, 2010 · Fuel system · 59,000 miles · FL

Plastic diesel fuel filter drain valve has deteriorated--dumping diesel fuel onto the engine while running at the rate of 10 to 25 drops per minute--the diesel fuel winds up on the road --- when turned off the entire contents of the diesel fuel filter (a pint or more) runs over the engine & onto the ground---pollution & fire hazard !!!!!!!

Filed May 25, 2004 · Electrical, Fuel system · 171,874 miles · MI

Driving at 73 MPH on us 131 express way my truck all of a sudden lost all power to the fuel system. Causing my engine to shut down and causing me to loose power steering and power brakes. Causing me to take evasive measures to keep from getting rear ended and braking with both feet to get the truck safely stopped. In having my truck repaired at the ford dealership they found that the computer module part number xc3z-12b599-aa shorted out causing the engine to shut down. When checking over the module myself. I found a metal vent cap coming off from the outside of the module in tipping the unit over water came dripping out of the module. This module is located behind the wheel well on the firewall of the truck. I feel that this is a deffective and hazardous design. That could/should be fixed so that other incidents do not happen.