2004 Ford F-350 SD technical service bulletins
63 technical service bulletins and manufacturer communications cover the 2004 Ford F-350 SD.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all...
- This SKU is a Transmission Line
- This SKU is a Spare Tire Hoist
- Concern during or after programing the VSM. The programming may fail or vehicle symptoms such as...
- This SKU is a front upper ball joint
- Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a...
- Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21,...
- Ford: the restraint control module (RCM) when using vcm II, would have an error code 35 and diagnostic...
- Ford trucks service campaign: vehicles have experienced severe steering wheel and front wheel vibrations...
- 1999-2008 7.3L/6.0L/6.4L/4.5L diesel f-super duty - clean the charge air cooler (CAC) system after certain...
- 6.0L turbocharger carbon deposit diagnostics and service tips
- Water in the fuel tank behind rear axle - 6.0L, 6.4L and 7.3L diesel engine
- 1999-2008 F250-F550 super duty 4X4 with electronic shift transfer case not engaging 4X4
- 6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK of power or surge with some 2003-2007 f-super duty,...
- Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes
- 6.0L diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct
- Dtc's P006A or P132B - lacks power, surge, or flutter after field service action 06E17
- Adding additional bulbs to turn indicator or hazard flasher circuits
- Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start
- 6.0L oil seep or boost pressure leak at hot side charge air cooler duct
- Lack of power due to low fuel pressure - fuel tank liner seperation
- 6.0L turbocharger carbon deposit diagnostics and service tips - lack of power, white or black smoke,...
- Lack of cooling fan operation
- Air filter water ingestion / snow packing with codes P0103
- Lack of power due to low fuel pressure, fuel tank liner seperation
- Driveability issues and/or DTC P132B, P006A immediately after reprogramming
- Watch for oil flow from the base engine oil pump
- Repeat turbocharger or vgt replacement
- Oil flow from the base engine oil pump
- Exhaust pressure sensor input no longer used if PCM is reprogrammed - service tip
- Lack of power or MIL on - turbocharger sticking - revised diagnostics
- P0404 service tip
- Voluntary emission recall 06E17 supplement #1: control module recalibration. corrosion may exist at the...
- White smoke, lacks power, exhaust odor, surges, runs rough, or no start - 6.0L
- Water-in-fuel (WIF) lamp
- Diagnostic procedure for trailer tow lights or no power due to open fuse
- Neutral tow capability -- service kit requirements
- Fuel conditioner
- Coolant degas bottle overflow - 6.0L
- Neutral tow capability - service kit requirements
- Water-in-fuel (WIF) lamp on
- Misfire, lack of power, buck/jerk, excessive smoke or crank/no start
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Drive away shudder or vibration
- Service kit available for wiper motor wiring
- Diagnostic trouble code P0488 and/or P1334 with no driveability symptoms, harsh shift and/or transmission...
- Coolant degas bottle overflow
- Vacuum pump inoperative or runs continuously - climate control defaults to defrost mode
- Torqshift transmission - intermittent clunk when shifting from reverse gear or drive gear to park
- Voluntary emission recall 05E15 - supplement #2
- Diagnostic trouble code P0488 set after reflash
- Headlight adjustment - chassis cab incomplete vehicles
- Malfunction indicator lamp on with misfire dtc's spark knock piston scuffing
- Lack of power and/or DTC P2263 or P0299 after turbocharger replacement - service tip
- Intermittent crank no start due to an EGR throttle plate that is stuck closed
- Dtc's P0488 (EGR throttle position range/performance) and/or P1334 (EGR throttle position sensor minimum...
- Buck/jerk, lacks power, black smoke, rolling idle, surge, MIL on, and diagnostic trouble codes P2263,...
- RPM surge at idle; audible EGR surge; low power/smoke/rough idle following a cold start that corrects...
- Low power-cold side charge air cooler (CAC) disconnected-oil leak at cac CONNECTIONS-6.0L-VEHICLES built...
- Diesel exhaust smell in CAB-6.0L engine
- Vibration diagnosis - tire/wheel runout
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Ford F-350 SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history