The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to reach her destination but had to periodically start the vehicle and let it run to ensure that the vehicle would remain operable. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the diesel exhaust fluid tank had frozen and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000.
2016 Ford F-350 SD fuel system complaints
Page 2 of 2: complaints 11 to 27 of 27, newest first, as owners wrote them.
The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the diesel particulate filter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the federal safety agency Hotline. The failure mileage was approximately 44,000.
The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the diesel particulate filter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The contact related the failure to Customer Satisfaction Program: 20M06 (Diesel Particulate Filter Warranty Extension) however, the VIN was not included. The failure mileage was approximately 36,000.
The diesel exhaust fluid system, reductant heater and sender assembly. The truck went into a -idell reduced power mode ( 5 miles an hour) 25 miles from service at 2:00 AM 300 miles from home. The dealer has the truck. They towed it in September, 2021. they have had it for seven months. I need a TRUCK !!!!!!!! What is going on, this is unacceptable.I have been renting a car since Oct, 2021. Ford didn't offer me anything. The truck has 21,000 miles on it. Sell it and get me a new truck, I need a TRUCK.
The cp4 injection pump destructed and took out the whole fuel system with it. Cause upwards of $12,000 in repairs this is a issue ford needs to address and get took care and take some responsibility on there own
A main computer communication cable failed (rubbed through) due to rubbing due from the use of the parking brake. I noticed all my gauges were not working. I happened to be very close to the Ford dealer, so I pulled in the lot and turned the truck off to see if the issue would reset. Upon trying to start the truck, everything was dead. I got the service manager and left the truck. When he called me to tell me what he found, I immediately recall reading about this same issue several times on the Ford Truck Enthusiast web site, and the fix was simply moving the communication cable so it doesn’t rub.
The Diesel Exhaust Fluid system is faulty. I have been informed that GMC and Chevy have recalled the system but Ford has not. I have complained to Ford with no response. My neighbor has 4 work trucks that have all needed replacing (so has mine). I have 2 friends who also have Fords, one was covered under the factory warranty and the other was not. My mechanic states it is a known issue.
Tl* the contact owns a 2016 ford f-350. The contact stated that while driving 70 MPH, the fuel mode warning light illuminated, which caused the vehicle to stall for approximately one minute before resuming normal operation. The failure recurred intermittently. The vehicle was taken to tindol ford (1901 e. Franklin blvd, gastonia, nc 28054, (704) 867-8341) where it was diagnosed and it was determined that the fuel rail system failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 209,700. The VIN was not available.
About 2018 my 2016 f350 diesel gas mileage was good around 16 mpg city and 19mpg hwy I took my truck to ford for service because the regeneration would keep coming on all the time well they finely said it was a sensor but did nothing to replace anything but they told me ford company told them to re-flash my computer in my truck because they had a update well my gas mileage went down to 11 mpg city and 9 mpg hwy and I try to take it back and tell me it is no longer under warranty.....so they did something to my fuel mileage which is totally wrong what they did to me because when I bought it the truck the fuel mileage was better so I am loosing money every time I drive it because what the did behind my back our first trip about oct 2019 we had power loss while driving at around 60 MPH where no matter how far I push the gas peddle to the floor nothing happen of flat land while towing and in heavy traffic where speed limit was higher then 60 MPH where people were rushing around me and honking there horns and we could not pull over with no power to get over a check engine light on we haven't used this truck much if I did would have more problems so I will not know what will happen this year on the 2nd trip also I have check engine that comes on without towing but goes out after awhile and the dealer told me they cant do anything ..I do have a picture of the check engine light on at 20,203 miles and now I only have 20,300 on a 2016 f350 truck right now and it is may 22, 2020 the check engine light was on more then one time but this was the first time I took a picture.
Truck was taken to green ford peoria il. For recall on the crankcase ventilation recall. After receiving my truck back the next day truck threw another engine light on and truck was returned that day to find reductant heater code was showing. My truck of course is a 2016 f350 with the 6.7 found recalls for previous years but not this truck year, same exact issue. I left the dealership preparing to enter the highway, truck was still under full power as I merged into heavy traffic speeding up to merge the truck lost power. I nearly was rear-ended as the traffic was moving at 70 MPH. I was able to throw my flashers on and get to the side of the road. After speaking with the advisor at green ford I was told my truck went into limp mode. I purchased the truck used with 92k miles and have only put 3k on it since. I'm very dissapointed in this issue as I've seen it's a very common thing to happen. The recall should be extended to the 2016 6.7 just as the previous years
The reductant heater recall needs to extend to at least my 2016 truck. They have had excessive failures. My last truck was included in the recall (warranty extension-program 18m01). This recall was given in 2018 and they should have included more than just 2012 to 2015.
While driving on I-75 in the passing lane at between 70-75 MPH, approaching macon,ga. Our vehicle slowed way down. We were able to make it to exit 167 before vehicle quit running. Vehicle quit on the exit ramp, less than a mile from where it 1st began slowing down. Vehicle was towed to riverside ford in macon. Upon examination by ford mechanic, while there was no water in the fuel, there was a slight amount of rust around rim and metal in the fuel filter. We had vehicle towed home. On monday we had the vehicle towed to robbie roberson ford in waycross, ga. Upon examination of the fuel system by one of their mechanics the same determination was made., slight rust around rim of fuel filter and metal in the filter. At no time did the water sensor light come on. The fuel pump had exploded. Ford assumed no liability although the vehicle is still under warranty. The vehicle fuel system should not be so sensitive that the fuel pump explodes just because of a little rust probably caused by condensation. Had we not been able to exit I-75 and the vehicle quit in traffic this could have resulted in a major accident with multiple injuries/deaths. Ford is aware they have an issue because they have a kit to fix it but refuse to acknowledge problem.
Tl* the contact owns a 2016 ford f-350 sd. The contact stated that the vehicle stalled without warning. The vehicle was towed to basil ford (1540 walden ave, buffalo, ny 14225, (716) 893-1000) where it was diagnosed that the incorrect fuel was placed in the vehicle. The vehicle was then towed to washington ford (507 washington rd, washington, pa 15301, (724) 223-5100) who speculated that there was no octane in the fuel or there may have been water or rust in the fuel system. The dealer later stated that, with fuel samples, they found metal shavings in the fuel system and the high pressure fuel pump may need to be replaced. The vehicle was serviced by the second dealer, but they could not provide a permanent remedy to repair the vehicle. The contact was awaiting a response from the manufacturer to determine if the part was available to provide to the dealer to repair the vehicle. The approximate failure mileage was 45,222. *tt *dt updated 10/19/18
Tl* the contact owns a 2016 ford f-350. While driving approximately 70 MPH, 'losing power' displayed and the vehicle stalled. The vehicle was not able to restart and was towed to classic ford smithfield (1698 e booker dairy rd, smithfield, nc 27577). The dealer diagnosed the vehicle, but could not locate the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the failure was due to contaminated fuel. The approximate failure mileage was 35,000. The VIN was not provided. *tt *dt updated 10/19/18
Vehicle has 30k miles on it. Was driving down the road, vehicle shut up, and would not start back up. Took to dealer, stated it was a fuel pump problem, that the fuel pump in the truck blew up and sent metal shreds through the fuel rail system and into the engine. Ford denied the warranty stating the fuel was contaminated with to much water. Upon having my fuel tested, it was determined it was not contaminated and they paid 9000 of repair cost, and I paid 1000. I have two vehicles (the other which I will also make a complaint as well) and both vehicles have unsafetly shut off and lost power. After doing research, the fuel pump in the trucks in not rated for the lubricity the diesel fuel in america offers. I have spoken to several mechanics who said the pump will blow up if you do not use a fuel additive. Fuel specifically states to use united states ultra low diesel fuel in their system, and does not require their consumers to use fuel additives. The pump is not rated, and ford is putting these pumps in their trucks knowing their not rated for ulsd in the untied stated.
Vehicle has 10k miles on it. Was driving down the road, vehicle shut up, and would not start back up. Took to dealer, stated it was a fuel pump problem, that the fuel pump in the truck blew up and sent metal shreds through the fuel rail system and into the engine. Ford denied the warranty stating the fuel was contaminated with to much water. Upon having my fuel tested, it was determined it was not contaminated and they paid 9000 of repair cost, and I paid 1000. I have two vehicles (the other which I will also make a complaint as well) and both vehicles have unsafetly shut off and lost power. After doing research, the fuel pump in the trucks in not rated for the lubricity the diesel fuel in america offers. I have spoken to several mechanics who said the pump will blow up if you do not use a fuel additive. Fuel specifically states to use united states ultra low diesel fuel in their system, and does not require their consumers to use fuel additives. The pump is not rated, and ford is putting these pumps in their trucks knowing their not rated for ulsd in the untied stated.
The animal are eating plastic fuel lines causing fuel leak
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Ford F-350 SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history