2001 Ford F Series problems

What is wrong

Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, inc. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.

Risk

This overheating condition can cause the running board to melt or cause a fire.

Remedy

Dealers will replace the wiring harness on these running boards. Owner notification began march 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1‑800‑745‑6096.

Recall number 03V094000 · Recall details

On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi?s analysis showed, it is possible for a spark plug to detach from the engine cylinder threads in the subject vehicles.however, odi?s analysis of 474 complaints describing such incidents found only a very few alleged any safety-related consequences.none of these showed any evidence of a serious safety consequence.given the large population and relatively long exposure time of the subject vehicles, the complaint analysis indicates that the risk to motor vehicle safety from the alleged defect is very low.in view of the foregoing, it is unlikely that the federal safety agency would issue an order for the notification and remedy of the alleged defect at the conclusion of the investigation requested in the petition.therefore, in view of the need to allocate and prioritize the federal safety agency?s limited resources to best accomplish the agency?s safety mission, the petition is denied.

DP05005

During the initial recall campaign in 2001, the subject vehicles were inspected by ford dealerships using a test tool that would detect a defective front seat outboard seat belt buckle assembly.approximately one million vehicles passed the inspection test for one or both front buckles.subsequent to the recall service action, odi received 15 consumer reports alleging that a passed inspection buckle subsequently failed to latch or inadvertently unlatched during use.in addition, ford has identified 543 owner and field reports alleging buckle failure subsequent to passing the inspection test.ford tested and examined over 100 warranty-returned buckles and found that 44% of the buckles had no problem or a condition not related to the recall inspection (non-latch related buckle damage or foreign contamination).warranty claims were highest during the 18-month period after the start of the recall (july 2001) and have been declining during the past 24 months.over the past 12 months, ford has received approximately 12 warranty claims per month out of a vehicle population of about one million.complaints counts are also decreasing.during the past seven months, odi has received only two complaints. A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by the federal safety agency that a safety-related defect does not exist.the agency reserves the right to take further action if warranted by the circumstances.

EA05004

Under recall campaign (01v227), ford recalled approximately 1.3 million vehicles to inspect and if necessary replace the front driver and/or passenger seat belt buckle.approximately 1.1 million owners responded by taking their vehicles to a dealer for inspection of the buckle using a specialized buckle test tool.ford reported that 829,927 vehicles had both buckles pass the tool test and another 167,336 vehicles had one buckle pass.odi and ford received complaints alleging seat belt buckle failure shortly after passing the original recall inspection service.complainants alleged that the buckle failed by either not latching or false-latching (partial engagement of the latch to the latch plate).a false-latched buckle may release with minor movement or impact against the buckle housing including inadvertent release while the vehicle is in motion.odi is upgrading this recall query to an engineering analysis (ea05-004) to further analyze the field performance of those vehicles that ford dealers passed (one or both buckles) using ford's inspection test (997,263 vehicles).

RQ04011

There is no summary currently available

RQ02002