Failure of the brakes, consumer was driving at high speed and the consumer could not stop the vehicle, causing the consumer to have a near accident.*ak consumer states hydraulic return line fitting brakes out of hydraulic pump housing, due to vibration, when this occurs all fluid is dumped out resulting in sudden loss of brkes.
The worst 1995 Ford F800 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Brakes1
- Transmission1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Brakes1
- Transmission1
Recalls 4
Vehicle speed control
- What is wrong
- The hand throttle cable can wear the brass swivel block on the governor lever through which it passes.
- Risk
- This wear can result in the governor jamming in thedamaged swivel and could prevent the governor lever from returning to the idle position.
- Remedy
- Dealers will install a revised governor lever with a stainless steel swivel. Also letters will be sent to vehicle owners that have the same vehicles but do not have a ford installed hand throttle advising them that they may require service if they have had an after market hand throttle installed.
Recall number 95V143000 · Recall details
Electrical system: wiring
- What is wrong
- A connector in the wiring where the tilt hood mounted lamps attach to the vehicle wiring harness was built without sealing plugs. Moisture, road salt or other contaminants can enter the connection resulting in crossed circuits, shorts or corrosion of the wiring of the connector.
- Risk
- The headlamps or other front-end lighting systems can malfunction as a result of this condition increasing the potential for a vehicle accident.
- Remedy
- Dealers will inspect the connector and install sealing plugs in the open cavities. If the inspection reveals corrosion, a new connector will be installed.
Recall number 95V092000 · Recall details
Steering: linkages: drag: link: connection
- What is wrong
- The drag link installed can contact the front axle I-beam under certain extreme conditions. This drag link was not intended to be installed on "low profile" vehicles.
- Risk
- This can result in loss of steering control.
- Remedy
- Dealers will install the correct drag link on the vehicles.
Recall number 94V244000 · Recall details
Service brakes, hydraulic: antilock/traction control/electronic limited slip: control unit/module
- What is wrong
- The vehicles were manufactured without separate ABS indicator lamps. This does not comply with the requirements of fmvss no. 105, "hydraulic brake systems."
- Risk
- Consequence of non-compliance: the brake system could fail and the driver would have no warning.
- Remedy
- Dealers will install ABS indicator lamp and circuitry.
Recall number 94V235000 · Recall details
Technical service bulletins for the 1995 Ford F800 12
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Some vehicles equipped with 26 inch diameter fans may exhibit an engine overheat condition. tt
- Conditions with power steering fluid leaking from the brake pump reservoir at 90 degree elbow on some...
- Exhaust leak at exhaust manifolds--vehicle equipped with 7.0L 0R 7.5L engine. ak
- Some medium duty trucks may have a concern with a worn or binding clutch rod ball end. tt
- Exhaust - exhaust leak at exhaust manifolds - vehicles equipped with 7.0L or 7.5L engine. tw
- Generator-motorcraft 95AMP-FRONT bearing CONCERN-FD1060/1460 engines- vehicles built before 7/3/95. sd
- Engine- 'knocking' noise - when operating engine at 200-2300 RPM - FD1460 engine
- Brakes-rear-re-index rear/rear brake chamber or eliminate interference with dso asphalt spreader...
- Unknown
- Stall or no start - fuel shutdown solenoid - wiring chafing on fuel injector lines-vehicles built before...
What 1995 Ford F800 owners say
Most recent owner complaints, unedited.
The front left wheel has fallen off due to wrong size bearing in front axle. Tt
Compare the 1995 Ford F800
Other model years
Questions about the 1995 Ford F800
Is the 1995 Ford F800 reliable?
Owners have filed 2 complaints about the 1995 Ford F800, close to a typical F800 model year.
What is the most common problem with the 1995 Ford F800?
Brakes, with 1 complaint. Next is transmission (1).
How many recalls does the 1995 Ford F800 have?
4 recalls, covering vehicle speed control, electrical system and steering.
Was there a recall on the 1995 Ford F800 brakes?
Yes, 1 recall: 94V235000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1995 Ford F800?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history