2019 Ford Fiesta brakes problems

Filed Sep 25, 2026 · Brakes · NC

My granddaughter and I were driving the car around 50mph. When suddenly we smelled burning. The car wouldnt go when I pressed the gas pedal. We smelled the loudest weird smell. So I immediately pulled into the closest car clinic. The breaks were blue and almost on fire. No warning or anything. Turns out, It was the abs control module. It totally failed and caused the breaks to lock up completely. Which almost caught fire. The break pads were blue. We were terrified. After getting Calipers, break pads, and rotars repaired costing $712. I still have to pay another $1000 when I get paid in a week. To get the abs control Module repaired. Because the car isn’t drivable without that repair. I just wish Ford would pay for the repair. Being that they made most of the 2019 Ford Fiesta SE with the wrong fluids. Which causes the breaks to lock up and the abs control module to fail/die. But they denied it. Which is so unfair. Because We could’ve died. And it’s an expensive repair. At no fault of my own. I will upload the other invoices for the back breaks, rotars, pads, calipers and abs control model as soon as I get it paid and repaired. . Thank you

Filed Sep 22, 2026 · Brakes · 65,400 miles · NC

The contact owned a 2019 Ford Fiesta. The contact stated that while driving 50 MPH, there was an abnormal burning odor on the interior of the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed with ABS control modular failure. The contact was informed that during the production of the vehicle, the manufacturer used brake fluid which caused the brake pads to swell and corrode. The contact was informed that the front and rear brake pads and rotors had seized. The contact was informed that the failure was a fire risk. The dealer was contacted by phone and made aware of the failure. The contact agreed to a voluntary buy back. The failure mileage was approximately 65,400.

Filed Apr 8, 2026 · Brakes, Engine · NC

The brakes stick and then when i hit the gas its sluggish and just takes off full force. Causing 50% gas loss. The breaks are getting stuck. Calipers sticking. This is a fire hazard

Filed Dec 23, 2025 · Brakes · GA

Brakes started seizing up while driving. Became extremely dangerous as the car would rock at speed and also would not start moving if I came to a stop. Went immediately to a shop, when I arrived into the shop, inspection found that the caliper was locked onto the wheel preventing the front wheel from moving. Had the caliper replaced but the caliper was still seizing, and then had to get the ABS Hydraulic Assembly, P/N D2BZ 2C405-E replaced. This P/N seem to be causing a lot of troubles from online forums. This issue had no warming lamps, messages or anything indicating this other than a feel that the car is accelerating more slowly. However, when the brakes started seizing, the situation felt extremely dangerous.

Filed Nov 15, 2025 · Brakes · NY

ABS Module failure. I had to leave the break lines direct, losing my ABS. I had to replace the brake pump because of that too. The car was only 80k ish.

Filed Jul 17, 2025 · Brakes, Driver assistance · OH

The contact owns a 2019 Ford Fiesta. The contact stated that the rearview camera image was distorted or black while the vehicle was in reverse(R). The contact stated that the failure had obstructed the visibility of the roadway and had prevented the driver from safely operating the vehicle. Additionally, the contact stated that while driving at an undisclosed speed, there was an abnormal knocking and screeching coming from the front passenger's side and the driver's side. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the brake pads and calipers had failed and needed to be replaced. The vehicle was repaired; however, the failure persisted. The contact related the failure to the federal safety agency Campaign Numbers: 19V629000(Service Brakes, Hydraulic) and 24V951000 (Back Over Prevention); however, the VIN was not included in the recalls. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

Filed Jul 11, 2025 · Brakes · 75,000 miles · FL

The contact owns a 2019 Ford Fiesta. The contact stated that while driving at an undisclosed speed over a pothole, the vehicle made a clunking sound, and the front passenger’s side wheel seized. The vehicle was towed to the dealer, who determined that the front brake system had melted and needed to be replaced. The vehicle was not repaired. The contact stated that the brake pads had previously been replaced a year before the failure. The contact related the failure to the federal safety agency Campaign Number: 19V629000 (Service Brakes, Hydraulic); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The failure mileage was approximately 75,000.

Filed Oct 31, 2024 · Brakes · AL

Upon stopping when applying the brakes they locked up. There were no warning lights on. It was diagnosed by an independent auto repair shop, not drivable I had it towed to the Ford Dealership. The ABS module, and calipers have failed. I learned there was a recall on these parts but do not apply to my specific vin #. The ABS module is on national back order, likely a month out. I have paid for the part. The service dept quoted new rotors calipers/hose and pads I think this vehicle may need to be added to the recall since it is the exact same failure. Luckily I was in town and not on the interstate when the brake system failed.

Filed Sep 5, 2024 · Brakes, Transmission · VT

My clutch slave cylinder failed with approximately 64000 mi on the vehicle. This is a hydraulic system sharing the same reservoir as the brakes. The clutch pedal stuck to the floor leaving me unable to change gear while driving on the highway. Had to pull off on the side of the road and manually pull up the clutch with my hand. After that it functioned seemingly fine. I took the car to a local garage who diagnosed the issue and said it was fairly common on these cars. Part has not been replaced yet so it cannot be inspected but it is scheduled to go in to have the transmission dropped and slave cylinder replaced. There were no lamps messages or other warning signs prior to the incident on the highway aside from a slight softening of the clutch feel which occured during the months proceeding the failure. The clutch in this vehicle is notoriously soft to begin with so it did not feel much different. Thank you

Filed Jan 25, 2023 · Acceleration, Brakes · FL

This car very bad no body can't buy