2019 Ford Fiesta: ABS light or ABS activating

Filed Sep 25, 2026 · Brakes · NC

My granddaughter and I were driving the car around 50mph. When suddenly we smelled burning. The car wouldnt go when I pressed the gas pedal. We smelled the loudest weird smell. So I immediately pulled into the closest car clinic. The breaks were blue and almost on fire. No warning or anything. Turns out, It was the abs control module. It totally failed and caused the breaks to lock up completely. Which almost caught fire. The break pads were blue. We were terrified. After getting Calipers, break pads, and rotars repaired costing $712. I still have to pay another $1000 when I get paid in a week. To get the abs control Module repaired. Because the car isn’t drivable without that repair. I just wish Ford would pay for the repair. Being that they made most of the 2019 Ford Fiesta SE with the wrong fluids. Which causes the breaks to lock up and the abs control module to fail/die. But they denied it. Which is so unfair. Because We could’ve died. And it’s an expensive repair. At no fault of my own. I will upload the other invoices for the back breaks, rotars, pads, calipers and abs control model as soon as I get it paid and repaired. . Thank you

Filed Sep 22, 2026 · Brakes · 65,400 miles · NC

The contact owned a 2019 Ford Fiesta. The contact stated that while driving 50 MPH, there was an abnormal burning odor on the interior of the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed with ABS control modular failure. The contact was informed that during the production of the vehicle, the manufacturer used brake fluid which caused the brake pads to swell and corrode. The contact was informed that the front and rear brake pads and rotors had seized. The contact was informed that the failure was a fire risk. The dealer was contacted by phone and made aware of the failure. The contact agreed to a voluntary buy back. The failure mileage was approximately 65,400.

Filed Dec 23, 2025 · Brakes · GA

Brakes started seizing up while driving. Became extremely dangerous as the car would rock at speed and also would not start moving if I came to a stop. Went immediately to a shop, when I arrived into the shop, inspection found that the caliper was locked onto the wheel preventing the front wheel from moving. Had the caliper replaced but the caliper was still seizing, and then had to get the ABS Hydraulic Assembly, P/N D2BZ 2C405-E replaced. This P/N seem to be causing a lot of troubles from online forums. This issue had no warming lamps, messages or anything indicating this other than a feel that the car is accelerating more slowly. However, when the brakes started seizing, the situation felt extremely dangerous.

Filed Nov 15, 2025 · Brakes · NY

ABS Module failure. I had to leave the break lines direct, losing my ABS. I had to replace the brake pump because of that too. The car was only 80k ish.

Filed Oct 31, 2024 · Brakes · AL

Upon stopping when applying the brakes they locked up. There were no warning lights on. It was diagnosed by an independent auto repair shop, not drivable I had it towed to the Ford Dealership. The ABS module, and calipers have failed. I learned there was a recall on these parts but do not apply to my specific vin #. The ABS module is on national back order, likely a month out. I have paid for the part. The service dept quoted new rotors calipers/hose and pads I think this vehicle may need to be added to the recall since it is the exact same failure. Luckily I was in town and not on the interstate when the brake system failed.