2012 Ford Focus body problems

Filed Aug 2, 2026 · Body · TX

Started July 2026, my drivers side door handle keeps getting stuck open

Filed Jul 27, 2026 · Body · CA

My driver side door was working perfect until one day i went into my car and tryed closing my door but it wont close so i had to go to work while holding the door so it dosent open i favent talked to ford itself bucause om scared they will charge me a lot

Filed May 7, 2026 · Body · VA

While driving on the highway the sunroof suddenly blew off. The sunroof had not been opened prior. The frame bent upwards from the front, and the glass completely flew out onto the highway.

Filed Jan 5, 2025 · Body · DE

Back passenger door fails to latch when closed.

Filed May 7, 2024 · Body · NY

The trunk lid is rusting/deteriorating along the rim that meets the back bumper. I just dropped it off my red Ford Focus to Scott's Auto Fixit in Webster, NY for repair. I couldn't afford the new truck lid that the dealership service department offered at the Ford Dealership in Webster. The trunk lid was inspected by my auto insurance representative in 2019 (I have photos from 2019 and today {2024}). The lid is deteriorating with pieces of the lid falling into the trunk. I'm concerned of the possible risk of the trunk deteriorating to the point that other safety components would be affected - light, latch, lock (security). I've also notice that several Ford Focus automobiles are experiencing the same issue; the trunk lids are visibly rusting/deteriorating. The rust has discolored the paint on the rear bumper; that also needs to be addressed. frustrated!

Filed Nov 8, 2023 · Body · 123,000 miles · MI

The contact owns a 2012 Ford Focus. The contact stated following repair work on the transmission, the contact was advised by the dealer to pick up the vehicle. The dealer informed the contact that the vehicle was not test driven because of extreme rust to the sub frame, and that the vehicle was unsafe to drive. The contact determined that the cost of replacing the sub frame would exceed the value of the vehicle. The vehicle was not repaired. The contact researched online and related the failure to several reported instances of severe corrosion for several years, makes, and models of the vehicle. The manufacturer had been informed of the failure. The failure mileage was approximately 123,000.

Filed May 8, 2023 · Body, Fuel system · TX

After completing door latch recall there is still an alert the the hatchback is open. And doesn't shut off. The dealer states that I have to pay for replacement since the recall shows complete. Except the instructions did not show anything in regards to this component , in regards to the fuel system, the dealer said I would have to pay for test to determine if the PCM would fix the engine ight after I took in for recall.

Filed Jan 6, 2023 · Body · KY

The rear driver side door latch will not latch and stay closed. The door swung open while I was driving. it has not been reproduced. it has not been inspected. I believe something is wrong with the door latch, but I do not use this door very much.

Filed Jan 4, 2023 · Body · CA · crash · 1 injury

The vehicle was being towed by a Class A RV using a manufacturer approved towing system. All connections and safety measures were properly installed and tested just prior to incident. Vehicle has been towed using the same equipment for several years with no incident. The attachment from the frame to the front-end assembly completely separated and the vehicle body went into oncoming traffic. The vehicle in oncoming lane was struck and one individual injured. Upon visual examination, the frame component appears to have failed on both sides at the front-end. The bolts are still in-tack, tight and uncompromised. This is a frame component failure.

Filed Aug 3, 2022 · Body, Fuel system · WA

There is a warning light showing a code 1450, unable to create fuel vacuum, that at first was thought to be an issue with a current recall for the car that was fixed. But after a routine oil change a fuel leak was found. I was told by the mechanic that it appears to be a fuel tank deformation similar to the 19S22 recall. My Ford focus was not apart of that recall and I was told by Ford to contact you to potentially have my car added. The leak is subnational enough that it could cause an engine fire.