My Car purge valve canister is bad and i reported the situation to a ford dealership near me for over 2 weeks now and nothing has been done.They claim they are expecting parts but nothing yet up until now.
2015 Ford Focus fuel system problems
172 complaints (17% of all complaints for this car). Typical mileage when it fails: 68,000. 1 crash reported.
- owner complaints
- 172
- of this car's complaints
- 17%
- typical mileage
- 68,000
- crashes
- 1
- recalls
- 2
Which part fails
- Storage: evaporative emissions: canister2
- Storage: tank assembly1
- Delivery: pressure sensor1
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Ford Focus fuel system problems in other years
Specific symptoms reported on the 2015 Ford Focus fuel system
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Fuel system, gasoline: storage: evaporative emissions: canister
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2012-2018 Focus vehicles previously repaired incorrectly under recall number 18V735. The Canister Purge Valve (CPV) may malfunction, causing the engine to stall unexpectedly while driving.
- Risk
- An engine that stalls while driving increases the risk of a crash.
- Remedy
- Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed July 29, 2026. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 26S40. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on on July 6,2026.
Recall number 26V369000 · Recall details
Fuel system, gasoline: storage: evaporative emissions: canister
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2012-2018 Ford Focus vehicles with a 2.0L GDI or 2.0L GTDI engine. The Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in fuel vapor management system.
- Risk
- The excessive vaccuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
- Remedy
- Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began August 19, 2019. Owners may contact Ford Customer service at 1‑866‑436‑7332. Ford's number for this recall is 18S32. Note: Until the vehicle is serviced for this concern, owners are advised to keep the fuel tank at least halfway full.
Recall number 18V735000 · Recall details
Related investigations
Loss of Motive Power
On September 15, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 98 consumer complaints alleging loss of motive power in model year (MY) 2012-2018 Ford Focus vehicles. The RQ focused on the effectiveness of the remedies of Recall 18V‑735 and 19V‑515. In October 2018, Ford issued Recall 18V‑735, which updated Powertrain Control Module (PCM) software in MY 2012-2018 Ford Focus vehicles equipped with 2.0L GDI engines built prior to April 13, 2017, and those with 2.0L GTDI engines built prior to February 2, 2018. The recall addressed vehicles experiencing a malfunctioning Canister Purge Valve (CPV) that can stick open and PCM software that does not adequately detect a stuck-open CPV condition. A CPV that is stuck open can cause excessive vacuum in the fuel vapor management system, potentially deforming the fuel tank, collapsing on itself. This deformation of the fuel tank can cause a Malfunction Indicator Light (MIL) to illuminate, an inaccurate or erratic fuel gauge indication, drivability issues, and/or loss of motive power. In July 2019, Ford issued Recall 19V‑515, which addressed certain MY 2012 and MY 2017 Ford Focus vehicles equipped with 2.0L GDI and MY 2013-2014 Ford Focus vehicles equipped with 2.0L GTDI engines whose PCM software had been reprogrammed as a part of recall 18V‑735. The updated software calibrations for these subject vehicles were not properly installed by Ford at the time of production. Approximately one year after this RQ was opened, on September 25, 2024, Ford initiated a customer satisfaction program (24N07) for MY 2012-2018 Ford Focus vehicles equipped with the 2.0L GDI and GTDI engines toâas ODI learned during this investigationâaddress a different issue with the CPV from the primary focus of the safety recalls (18V‑735 and 19V‑515).  Ford stated the CPV may not operate as intended in these vehicles. A failed CPV on its own merit, may cause drivability concerns such as engine hesitation, running rough, or stalling at low speed, which will be accompanied by an illuminated MIL. This program provides a one-time replacement of the CPV for vehicles with 15 years of service or less (with no mileage restriction). This coverage will automatically transfer to subsequent owners. It is to be noted that the customer satisfaction program being taken by Ford to address this RQ investigation results in a much different and significantly less severe problem than the safety action taken to remedy 18V‑735 and 19V‑515. ODI found no further issues with the combined scope and severity related to 18V‑735 and 19V‑515 therefore, ODI is closing this Recall Query. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to
RQ23006
What 2015 Ford Focus owners say
Most recent owner complaints, unedited.
The contact owns a 2015 Ford Focus. The contact stated that the vehicle was previously repaired under the federal safety agency Campaign Number: 26V369000 (Fuel System, Gasoline); however, the failure occurred after the recall repair. While starting and driving at an undisclosed speed, the check engine warning light illuminated. The vehicle stalled after refueling, and the RPM fluctuated while idling. The contact turned off the vehicle and waited before restarting the vehicle. Additionally, the contact discovered that the fuel tank was deformed. The contact retrieved DTC: P1450. The vehicle was taken to the dealer, who determined that the canister vent valve needed to be replaced. The dealer informed the contact that the failure was not associated with the recall. The manufacturer was notified of the failure by phone. The failure mileage was approximately 57,800.
My 2015 Ford Focus SE with the 1.0L EcoBoost engine and 6-speed manual transmission is experiencing a loss of engine lubrication/oil flow. The camshafts are not receiving adequate oil, there appears to be insufficient oil flow/pressure reaching the cylinder head. I am concerned that continued driving could result in engine damage, engine seizure, or a sudden loss of power while driving. I am aware that the federal safety agency Recall 23V‑905 / Ford Recall 23S64 covers certain 2016-2018 Ford Focus vehicles equipped with the 1.0L EcoBoost for oil-pump drive belt or tensioner failure that can cause loss of engine oil pressure. My 2015 Focus is not currently included in that recall. I am submitting this complaint because my vehicle has a similar loss-of-lubrication condition and I believe the federal safety agency should document and evaluate failures occurring in 2015 Ford Focus 1.0L vehicles as well.
The contact's daughter owns a 2015 Ford Focus. The contact stated that the vehicle stalled while the transmission was in reverse(R), and the vehicle rolled backwards downhill while depressing the brake pedal. The vehicle came to a stop once the vehicle was steered over into the grass, and the vehicle rolled into bushes and stopped. During the failure, the contact’s nephew exited the vehicle in a panic and sustained a scrape to the left hip. No medical attention was sought. The contact’s daughter experienced severe mental anguish, and the one-year-old child was also inside the vehicle. No Police report was filed. The vehicle was not towed. Upon investigation, the contact linked the failure to the federal safety agency Campaign Number: 26V369000 (Fuel System, Gasoline). The dealer acknowledged the similarity between the failure and the recall and stated that the vehicle was not included in the recall campaign. The vehicle was not repaired. The manufacturer was not notified of the issue. The failure mileage was approximately 163,951.
I made an initial post on 06/18/2026 so please reference that as well as this. I have not been able to drive the car since it died on me on the 18th of June. The car has been looked at a few times (actually stalling a third time while idling but was able to turn back on.) It has also displayed symptoms associated with the Ford Recall #26S40 / the federal safety agency recall #26V369 but it is listed at NOT included in the recall as of 07/06/2026. MIL is pulling Code P0420 (catalytic system efficiency below threshold) while only having 40k miles. It is also putting out an inaccurate fuel level for miles driven. The fuel tank itself is misshapen (concave bottom of the fuel tank). Again, reiterating here that it stopped twice while driving within 2 days on major PA highways/interstates and stalled for a third time while in idle mode as described earlier in this post. This has all happened within 28 miles of the TCM being replaced.
The contact owns a 2015 Ford Focus. The contact stated that the fuel tank was cracked and leaking fuel. The fuel warning light was illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 246,000.
Engine Stalls: the engine stalls unexpectedly while driving at highway speeds and city/street speeds. Loss Of Power: Sudden loss of motive power creates an immediate crash hazard. Starting Issues: the car struggles to start or cranks excessively after refueling. Erratic Fuel Guage: The fuel gauge fluctuates wildly and gives inaccurate readings. Malfunction Indicator: The Check Engine Light is illuminated with emission-related codes. Fuel Tank Noise: Loud clunking or thumping noises come from the fuel tank area. The problem began in September 2025 and I took the car to a local mechanic and they fixed the issued, however the issue has started again. The fix did not solve the problems.
After my car was left on idle for a couple minutes ( about 5), it began to shake, the check engine light came on, then it completely died. When I went to restart it, it stalled and then finally turned on but when I began to take off it began to shake and died on me again while driving. I was left in the middle of rode. I put my blinkers on and had to leave my car off for a couple minutes so it would restart again. Then I pulled over to the side so I wouldn’t be in harm’s way. My mechanic believes there is something wrong with thee fuel pressure system whether it be a fuel pump or a fuel pressure sensor.
I am in possession of Recall18S32/the federal safety agency recall18V-735 notice that has not been repaired but it is not showing up on my VIN and Model lookup.
Car is stalling at low speed and losing power. Does not do it at high speed. Occasional check engine light. Will start surging. This is a know issue with the Ford Focus and Ford has issued a Customer Satisfaction Program 24N07. They refuse to honor the program unless you keep paying them for diagnostic work until the code shows up for it. I have ran the codes myself on it and it is fuel related to the Canister Purge Valve. This issue is very dangerous in that the car does stall out on the road with no warning. I have had this issue with the car for several years and have received the CSP letter but cannot get the work done. The issue happened 3 times yesterday, 11-5-2025.
Questions about the 2015 Ford Focus fuel system
Does the 2015 Ford Focus have fuel system problems?
Owners have filed 172 complaints about the fuel system of the 2015 Ford Focus, 17% of all its complaints.
At what mileage do 2015 Ford Focus fuel system problems start?
The typical (median) mileage in owner complaints is 68,000 miles.
Was there a recall on the 2015 Ford Focus fuel system?
Yes, 2 recalls: 26V369000, 18V735000. Check your VIN to see if your car still needs the free repair.
What year does the Ford Focus have the most fuel system problems?
The Ford Focus model years with the most fuel system complaints are 2000 (411 complaints), 2014 (354 complaints) and 2012 (342 complaints).
Other 2015 Ford Focus problems
Transmission 559Engine 180Steering 93Electrical 64Acceleration 42Airbags 18Body 16Wheels 12Visibility 11Brakes 10Driver assistance 10Locks 8Seat belts 6Suspension 4Lights 3Seats 2
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Ford Focus?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history