2006 Ford Freestyle suspension problems

Filed Oct 1, 2018 · Suspension · 140,000 miles · WI

2006 ford freestyle, 140,000 miles. Car is in good shape except for the front engine cradle/ subframe rusting out. I believe ford issued a recall on the 2001-2004 escapes for the same issue, they should step up to remedy this issue on the freestyle also.

Filed Jun 3, 2016 · Steering, Suspension · OH

Vehicle was discovered to have severe rust on front frame assembly drivers side during routine maintenance on today's date. It appears this has been an issue for some time and has just became painfully apparent. The corrosion/rust/deterioration occurs directly below an area where the air conditioning system dispenses later/condensation. Erosion to structural support is so bad it has eaten away bottom, sides and top of frame assembly. Sometimes known as an engine cradle. In order to replace, the engine must be moved and other front end components removed from vehicle. It is the opinion of complainant that this rust issue could result in a dangerous condition for the driver of the vehicle, the occupants of the vehicle as well as other motorists on the road and the general public. It is also the opinion of the complainant that this rust issue could result in the structural ability to suspend the engine. Possibly resulting in misalignment of key components or moving parts and could result in excessive wear and damage to other components of the automobile. It is also the opinion of the complainant that the rust issue and weakening of front end support members could possibly impact steering, tire life, tire pattern on roadway during hazardous conditions, etc. Ford motor company appears to have similar rust/chassis/frame issues on other models of vehicles after doing quick search online regarding this issue and comparing photographs. Ford motor company has issued recalls for other rust/frame/chassis issues, but not for the ford freestyle.

Filed Jan 14, 2016 · Suspension · PA

The subframe is rusted beyond repair. I am aware that between the years 2001 and 2004 ford motors had the same issue and recalled the vehicles

Filed Oct 1, 2014 · Brakes, Engine · 140,000 miles · DC

I was driving to work and the car just stopped..it would not come back on, it would not turn over with the key, so I had to tow it home it will move 12 inches forward and backward.

Filed Nov 3, 2012 · Acceleration, Brakes · 106,000 miles · CA

Vehicle would not slow as exit off freeway, rpms increased against braking system. Very dangerous and would not slow. Almost lost control of vehicle. Also, continues to worsen, lungin forward and in reverse.

Filed Jan 4, 2012 · Brakes, Suspension · FL

My ford started jerking backwards when I put reverse or lunging forward when I start driving forwards. This happened twice, once in the jekyll island when we were on vacation (all three days) in july 2011 and also when recently like three months ago, oct 2011. I first noticed when I was backing out from a hotel parking lot. I thought I am going to it the other cars. Also, I changed the brakes twice, once from the dealer and once from the auto mechanic. My mileage so far is 50k and this is a 2006 ford freestyle. I constantly face brake problems in this vehicle. And also other problems.(like front axle) could someone do something about these problems, please!!!

Filed Sep 13, 2011 · Acceleration, Suspension · 38,000 miles · PA

When driving, my car loses power. Sometimes when moving slowly, I engage the gas pedal and lose power. Sometimes when I engage the gas to move from a stopped position, my car will start to go and then lose power. The car does not shut off, it just won't move, and then suddenly does. The dealer replaced the throttle body, but this is still happening. They said unless they can get the problem to happen when they are driving it, there is nothing they can do to help further. This is very scary and I'm sure it's a matter of time before there is an accident. When I put my car in reverse, sometimes it revs up before actually moving. I have had many problems with this vehicle, starting in the 20,000 miles. Bad window motor, bad brakes, intermittent dash board clearance, air conditioning mechanism leaking into car. The dealer did replace the window motor, brakes and air conditioning problem, but had no explanation on the dash lights resetting. My paint is bubbling up on the hood of my car. Ford offered to fix this for $850. The bubbling started at 39,000 miles. I did not pay them to fix this, as I feel ford should be responsible for this. When ford had my car last, they replaced a sway bar and did not tighten the nut, I then had the ABS light come on and they replaced the wheel speed sensor and tightened the nut. My car clunked so bad, I fear that this caused additional suspension problems. I've always had noise in the front end, especially on a tight turn. The greased the front end, but that does not fix the problem. Today, my car only has 45,000 miles on it, but unfortunately, my warranty is up and I know that one day when I put my foot on the gas pedal, it's not going to move. I was told by a ford service rep. That the CVT transmission cannot be replaced, so when it does fail, I'm out of luck, there is no repair for this. Recall please

Filed Jun 15, 2011 · Acceleration, Suspension · 36,935 miles · GA

Tl*the contact owns a 2006 ford freestyle. While attempting to place the gear in drive, the vehicle lunged forward. The vehicle was taken to the dealer where the throttle body was replaced. Approximately three years after the vehicle was repaired it began to lunge backwards while in reverse and forward while in drive. The vehicle was not taken to the dealer for diagnostic testing. The vehicle was not repaired. There was an open investigation under the federal safety agency action number: pe11018 (vehicle speed control) which may be related to the failure. The contact also stated while turning the steering wheel either to the right or left the vehicle would make a clicking sound within the front axle. The vehicle was taken to the dealer where the technician stated the front driver and passengers side cv joints needed to be replaced. The vehicle was repaired by an independent mechanic. The vehicle was repaired. The approximate failure mileage was 36,935.

Filed Sep 2, 2010 · Acceleration, Suspension · 47,000 miles · TX

Surging from a while brake applied or when letting off brake but before applying gas. Front end noises when turning to right, loud creaking sound. Brakes make a creaking sound also but show now signs of needing to be replaced. All issues started at the same time.

Filed Aug 20, 2008 · Suspension, Tires · 1,000 miles · PA

In 2006 we purchased a new ford freestyle. At three months I took it to have the oil checked and I was told my tires were bald,ford gave us new tires. Since then I am getting ready to put my forth set of tires on the car. I have talked to several people who have the same car and they all have had the same problem. We took it to a ford dealer and they told us there was no way to align it, we then took it to our personal mechanic and he checked it and said there was no way to align it then the other day I took it to a tire place and they said they do not even sell a kit to align it. What can I do ?