2014 Ford Fusion fuel system problems

Filed Aug 18, 2026 · Fuel system · IL · 1 injury

The contact owns a 2014 Ford Fusion. The contact stated that upon entering the vehicle, there was an abnormally strong fuel odor coming from the vehicle. The failure persisted, and the fuel odor became stronger, causing the contact headaches while driving the vehicle. Upon taking the vehicle to an independent mechanic to determine the cause of the failure, the mechanic discovered that the fuel line was rusted. The mechanic informed the contact that he was unsure what had caused the failure. The contact was provided an estimate for the repair. The mechanic stated that had the contact continued driving the vehicle as-is, the vehicle could have caught on fire. The vehicle remained with the dealer unrepaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Filed Mar 4, 2026 · Fuel system · TX

There is a problem with the purge valve on the ford fusion. Car will not start after pumping gas. You have to step on the gas pedal several times and then the car will turn on. After doing research there seems to be several people with the same problem. The purge valve on the canister is getting stuck letting the fumes come in making the system run with extra fuel that’s escaping.

Filed Jun 9, 2025 · Electrical, Engine · GA

I had multiple coolant leaks in the pass and I have to constantly replace the hose about every 2000-3000 miles Also my screen went out in my dashboard causing me to not be able to make any audio changes or station adjustments in my car Lastly whenever I get ready to increase my speed my car jerks back

Filed Feb 13, 2025 · Fuel system · NC

Car cuts off while driving. Runs for awhile and will cut off again. Check engine light came on the first time codes says the fuel pump. Change the fuel pump. 2nd time it does it codes pOO88 and POOc6 comes up and changes the fuel pressure sensor. Car starts to stall and cuts off a third time.

Filed Nov 9, 2024 · Electrical, Fuel system · FL

When driving the car will stall out and die in the driving state. This occurs without warning from any sensor light error warnings. After acceleration to 35 it will sputter as if the fuel is not flowing, yet then it will correct but stall and completely die during operation while driving. Have had both the upper and lower full pumps installed within the last calendar yet still currently having the problem or issue. Experiencing the exact same Eco boost concerns as other Ford models have been recalled for as of recent

Filed Oct 12, 2024 · Electrical, Engine · MS

another attachment!

Filed Oct 12, 2024 · Electrical, Engine · MS

Attachment to last complaint

Filed Oct 12, 2024 · Electrical, Engine · MS

I've had my Ford Fusion SE ecoboost 1.5, 2014 in for service on 2 separate occasions a day apart for the same reoccurring problems. The first service there was the actions done related to recalls which are consistent with 20S15 A-C and recall 23E03 B. The reasons for my Ford Fusion 1.5 to have been brought to the Premier Ford, Waveland, Ms was as follows: The temperature overheat lamp light was jared, there was 3 leaks from the overheat, there was a Shutter and sounds that came from the engine, (LIMP*)and there was no fuel power through acceleration. There had been moisture located on exhaust before brakedown without having been driven for approximately 10hrs before brakedown. 2ed service was as follows: temperature overheat lamp light jared, no power through fuel to accelerate, and issues starting. LIMP* I had not on this brakedown paid attention to if my Fusion needed water, the engines performance in regards to shakes or sounds nor did I look to notice nor did I look for leaks. I called directly to Premier Ford, Waveland and had my Ford towed in. The service was as follows: 1) 3U2Z*14S411*HYB WPT988 WIRE ASY 2) DS7Z*8501*E PW556 PUMPASP-WATER 3) BE8Z*8507*A GASKET-WATER PUMP 4)VC*13*G 3801132 ANTI-FREEZE 5) 6 BM5Z*6K2543*S437 SCREW 6) BM5Z*6K254*A TENSIONER - TIMING BELT With the parts 261.44 Labor 1748.99 misc charges 50.00 for a total of after taxes 2204.66 I picked up my Ford Fusion on October 4, 2024 and on October 9, 2024 I went beck to the Premier Ford and spoke with the service department because I had to stop and let my Fusion cool every 20 to 30 minutes, I stated that there was some loss of water and it was overheating, the power train light warning notify me of an issue, and that my Fusion would not go over 80miles per hr. The service department associate seemed frustrated with me and argued the fact that it had ran hot and said that the reason for the speed issue was that the lamp was Identifying the keylock complete on pdf

Filed Sep 29, 2024 · Engine, Fuel system · MS

Complaints 11617112 and 11617127 Thank you for your patience with me!

Filed Sep 29, 2024 · Engine, Fuel system · MS

On [XXX] ford premier out of waveland evaluated my car after I had to have it towed in due to overheating. The high temperature warning notification was lock and wouldn't change to normal after it cooled. I was not fully aware of my car overheating due to no warning other the the temperature overheat warning. A couple of days prior without driving it for 10hrs I noticed a moist to the exhaust pipe. When it broke down the engine had a misfire, a shake, and had not power to the engine to accelerate. There was 3 different puddles of fluids underneath the car. When I had spoke to the service department on this breakdown I made them aware of everything with one of the Mechanics witnessing the shake within the engine. There was a confusion on my part due to the sticker showing a 1.5l and my Insurance showing through carfax a 2.5l with also Descripting a 1.5l that showed for my car to be compatible to a 2.0l, 1.6l Installation of coolant system, that of which lead me to request recalls through Vin# on [XXX] through Verified and it was shown to be compatible for recall. Premier Ford service department Assured me that nothing was wrong with the coolant system that the power train control module reprogramming took care of the breakdown. He assured me when I picked up my car That nothing was wrong with my car. Except for me needing to go, change the brakes so that he could change the brake hoses that are part of the recall associated with the brakes. This was on [XXX]. On [XXX] I broke down again with the same issue with this time before the breakdown there was a stall when I started my car And when they had my car on [XXX] I asked them the check the Fuel Injections and he stated there was nothing wrong with the fuel injections. My car has shown every sign that shows through the coolant system of a fire hazard. I am requesting that the Department to assign the safety recall 17s09 to my vin# [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)