The SERVICE ENGINE SOON icon appeared. Three days after, I went to Auto Zone to try to find the issue and the issue was unknown. The day after, the SAFETY ALERT icon appeared and immediately after, the message TRANSMISSION NOT IN PARK appeared. The 2015 Ford Fusion Hybrid slowed its acceleration to under 20 mph and upward to 35 mph and returned to under 20 mph. Search with the vehicle's VIN number on the federal safety agency website, shows that VEHICLE MAY POSSIBLY HAVE A DAMAGED/BROKEN/MISSING TRANSMISSION SHIFTER CABLE BUSHING. Safety of others put at risk because when vehicle acceleration and deceleration process slowed the vehicle into incoming traffic and creating a problem in the flow of traffic. Cannot get vehicle to a dealer for inspection.
2015 Ford Fusion engine complaints
Page 6 of 12: complaints 131 to 160 of 311, newest first, as owners wrote them.
This garnish purge valve near my engine constantly has issues. It usually cause warning light on and cannot start my engine
The contact owns a 2015 Ford Fusion. The contact stated that while driving the vehicle, the check engine warning light remained illuminated. The vehicle was taken to an independent mechanic who diagnosed that the engine cylinders were faulty causing coolant to leak into the engine. The vehicle was towed to the local dealer who confirmed the original diagnosis and informed the contact that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 108,000.
The contact owns a 2015 Ford Fusion. The contact stated while driving 40 MPH, the check engine warning light illuminated and the vehicle started to shake abnormally. The contact pulled over because the vehicle failed to exceed 40 MPH. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that coolant was leaking into the spark plug cylinders. The vehicle was not repaired. The dealer and the manufacturer were contacted and notified of the failure. The contact was informed that the vehicle was not under recall and that the repair would be an out-of-pocket expense. The failure mileage was 73,000.
The car began to sputter when cold starting and after a couple of days the check engine light came on. I took the car to the dealership and they said the coolant system leaked into engine causing a cylinder to misfire. This resulted in the engine block cracking and was replaced. This was confirmed by two separate repair centers including a Ford dealership. There is currently a class action lawsuit because of this problem happening with Ford Ecoboost engines.
I am not sure what part or components, but I am experiencing a smell of some kind that is making me sick. As in, nausea, vomiting, sleepiness, headaches and migraines. This only happens when I am in the vehicle and only at certain times throughout the day. I've been vacationing for several months now and this is a reoccurring problem. When I am driving the smell is trying to put me to sleep and I have to pullover on the interstate to sleep and I have been putting the windows down to try to stop the reactions I am having. But, the smell continues even when the engine is not running. That is the best way I can explain the experience that I am having. Thank you so much and have an absolutely amazing day.
The contact owns a 2015 Ford Fusion. The contact stated while her husband was driving 20 MPH, the vehicle started shaking. While the driver was depressing the accelerator pedal the vehicle failed to accelerate while the RPM continued to rise. The contact stated that the check engine warning light was illuminated. The driver was able to park on the side of the road. The vehicle was not drivable. The contact towed the vehicle to an independent mechanic and was informed that coolant was leaking into the engine. The mechanic was able to reset the computer but continued to experience failure. The vehicle was not repaired. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was 128,325.
2015 1.5L Ecoboost misfiring/running rough/coolant level low. While driving highway speeds engine began to lose power and shutter ultimately shutting down causing significant lose of braking and steering. Prior to this incident the check engine warning light came on and after having it scanned, code 0302 (misfire in cylinder #2) had caused the warning light. I replaced all four coil packs and cleaned the spark plugs because they only had about 30k miles on them from recently being routinely replaced. Light came on again when this incident occurred and once the vehicle was able to be scanned again it displayed codes: P0300 (random misfire), P0301 (misfire in cylinder #2), P0304 (misfire in cylinder #4) and P1450 (unable to bleed fuel tank vacuum). The car is no longer able to be driven. As soon as I started researching online what the issue could be it became very apparent that I was not the only individual(s) to encounter this exact same problem. After spending hours upon hours reading all of the reports involving Ford and the 1.5L Ecoboost, I assumed that my troubles were over. However, that was not and still isn't the case. Ford has admitted to a "design flaw" in the engine block of the 1.5L and even redesigned it. They also issued a number of TSB's (Technical Service Bulletin) detailing the symptoms, solution and parts. What they did not and to date have not done is issue a recall or offer to repair the thousands of engines that are affected by their "design flaw". I rely solely on my 2015 Fusion to commute to and from work in order to make a living. I still owe $4,807.18 on the car, following the TSB it will cost another est. $6-$8k to repair, but the problem I am facing now is I can't get to and from work to earn a living because the 2015 Ford Fusion 1.5L Ecoboost is not able to be driven due to "coolant intrusion". WHY ARE MANUFACTURERS ALLOWED TO FATTEN THEIR WALLETS BY CHEATING CONSUMERS AND NOT HELD ACCOUNTABLE FOR THEIR ACTIONS???
Coolant leak into the cylinders. Car overheating due to low coolant.
This car will randomly shut off while driving at any speed on hot days. The display will say "Transmission not in Park" then the instrument cluster will go dark and the engine shuts off. There is no check engine light and there are no ODB codes presented. I have to wait some amount of time, which varies, before it will turn on again. It has also not turned on from sitting for more than eight hours on two hot days. This is very much a safety issue and searching the Internet I find it is not uncommon with Ford Fusion and Escape vehicles with no discernible solution being presented. My auto shop has looked at the vehicle and replaced the fuel flow sensor but it did not fix the issue. I have replaced the key ignition switch and immobilizer ring and pulled every fuse and cleaned the contacts with no resolution.
As I was driving, it felt as if my car had turned off or had no fuel, but no engine lights came on and i had fuel in my tank. Also all my electrical stuff stayed on, only lost power on the accelerator. My safety and others safety was put at risk because there were no warning signs i just had no "Go power" and no one around me knew my car had no power which could lead to an accident, serious injury or death; if on highway traveling at high speeds and it randomly dies. I took my car to a mechanic and they stated everything was perfectly fine they did a full diagnostic and the computer didn't show any errors in operation. This happened 3 times in one day at random times, i could put the car in park and re-start and it ran fine. however i did have to hold the key forward longer for the engine to turn over.
The contact owns a 2015 Ford Fusion. The contact stated while driving at 25 MPH, the vehicle stalled. The contact did not notice any warning lights on the first failure, but in subsequent failures the check engine warning light illuminated. The contact stated that additionally there was a suction noise that started coming from the fuel cap when the vehicle would stall. The contact took the vehicle to the local dealer, where it was diagnosed that the purge valve needed to be replaced. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 88,000.
Answer 1 engine and yes it is Answer 2 my car well driveing down the high way went in to limb mode and shut down Answer 3 yes ford dealer 2 diffrent times Answer 4 sudden and the light came on that said coolent over temp car in limb mode
The contact owns a 2015 Ford Fusion. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with needing the oxygen sensor replaced. The contact stated that the oxygen sensor had been replaced four times previously however, the failure recurred. The manufacturer was informed of the failure and informed the contact to call the federal safety agency for assistance. The failure mileage was approximately 76,000.
The check engine light came on and I immediately took it to the local Hunt Ford dealer. Upon inspection, there was leaking of coolant into the cylinders and now the engine has to be replaced. The total cost for repairs is approximately $8300. I'm told that the problem has been corrected in the new engines. After talking with Ford Service and a local car repair shop in Franklin, KY, I learned that this is a common problem with Fusions and Escapes and both have replaced many motors. Unfortunately, my car has not been recalled nor was I made of the widespread problem through Ford (my engine is a 1.5-liter EcoBoost 4-cylinder engine). I have done further research into the matter and I'm shocked and disappointed that Ford has not been transparent with consumers about this matter. I have taken immaculate care of my car, serviced it routinely, and always quickly responded to recalls. Now that I know more about the faulty engine, I do recall some random symptoms such as the car loosing a bit of power, smoke out of the exhaust, and the car shaking when started in the morning and having to restart it. All of the symptoms were random and did not consistently happen so I really didn't think much about it. I have a call into Ford's Customer Care Team and they are checking into the matter further. I noticed there's a class action lawsuit filed in Delaware about the engine problem. The firms representing the plaintiffs are Berger Montague PC and Capstone Law APC. I'm thankful that this issue did not put me in arm's way or the safety of others were put at risk.
The car recently misfired 3 times. I took into get oil change and have the misfire checked into. The misfires started 11/4/21. Car would run rough and then stall out. It would sit for a minute or two and start and run fine. There were no check engine lights or gage to show the car was running hot. I never dreamed it was a cracked cylinder. The Dealer performed EEC test diagnosis and found previous misfies in cylinder 1 in mode 6 of PCM. Found coolant level low, pressure tested cooling system and found that cylinder 1 with coolant intrusion. Short block replacement. I see online that there have been recalls on 2013 -2014 Ford Fusion and other 2013-2015 vehicles for this exact problem of a lack of coolant circulation causing an engine to overheat resulting in a crack in the cylinder head. In these models dealers were installing a coolant level sensor with supporting hardware and software at not charge to customer. Ford dealer is charging me $5,000 for short block replacement, which I feel is a defect of the Ford Engine Design. I purchased by car in Nov. 2014 so it only makes sense that this engine had the 2014 design problem. I declined repairs at that moment, to investigate the problem and asked for my car. The dealer stated they had to put my car back together so it would be about 20 mins. When I got the car back it seems to be running normal like when I took it in, but down the road about 3 miles the car started to sputter and stalled. After sitting a few minutes with flasher on in traffic on a major road, the car would start up and wouldn't go over 15 mph and continued to stall. I called dealer and they gave me the number to the towing company they use. The car was towed back to dealership. The Ford dealer is charging me $5,000 for short block replacement. They did file a complaint with Ford Motor Co. Customer Relationship Center and they stated the dealer had opened a case by no programs in place for assistance. The dealer is telling the consumer this occurred due to a Ford design flaw. If this
The Car is making a sloshing sound in the engine, runs hot and will lose power due to overheating. This happen to me, forcing me to exit off the interstate (thank goodness I was near an exit). The check engine light also came on. Once the car cooled down (approx 45min) I was able to street drive home and have never been able to drive the car since. The code the car displayed once checked was P302/P1299. After looking online discovering a manufacturing defect from Ford causing coolant intrusion with this vehicles engine, I then got the vehicle towed to the dealership thinking the TSB (technical service bulletin) would cover the repairs needed (new engine long block) but it does not per Ford. The dealer gave me an invoice for the repair of over $8,500. The engine (1.5L, 2.0L) has several TSB's because for this issue from Ford but NO recalls to replace the engine. There are multiple years and models affected (2014-2019, Fusion, Edge, MKZ). I currently have a car that I can't drive and can't get any help from Ford to resolve the manufacturing defect. I hope you all can provide some help by encouraging Ford to recall the engines.
I was driving home from work at 10:30p. I pulled out of the parking lot at work when I lost power in the motor. Traffic was flowing and almost got T-bones. Right before I pulled it off the road it started to jerk like I was riding a bull. In the parking lot I shut it off and looked under the hood and checked everything but everything looked good. Started it back up and it started to run fine. So the next day it over heated took it to Ford and told them what was going on. They said someone bottom your car out so I turned it in to the insurance and they started a claim Ford fixed it. 2 days later it did It again over heated. Take it back in they fix it again pick it up again 2 days later over heats again. This is the third time it’s been in there and this time they say there is a TSB technical service bulletin-21-2269 that’s been out for over a year. At this point they tell me that no one has issued a recall on it. For the safety of others it should be recalled because if I had my kids in the call and got hit or killed over it someone would be paying.
2015 Ford Fusion SE 1.5L ecoboost While driving I have had loss of engine power posing risk in traffic. I refilled coolant and the misfire in cyl 1 inspired spark plug replacement. The problem recurs and I discover coolant in these engines has (secretly) known defect since 08 leaking into engine. At over 5 years though under 60K mi, Ford will not help / address the problem. Just did 3rd spark plug replacement and googled up the defect. Would love to get (long not short) engine replacement like other models have received with this. Would expect to get al least the reprogramming or other ideas for mitigation help from Ford.
The contact owns a 2015 Ford Fusion. The contact stated while driving 40 MPH, the engine started to overheat as the check engine light illuminated the instrument panel. The contact had taken the vehicle to an independent mechanic where it was discovered that coolant had leaked into a cylinder, resulting in engine damage. The dealer was notified of the failure and the contact was informed that there were no recalls on the vehicle for the engine. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 135,000.
2015 Ford Fusion SE with 99k miles, well maintained and only two owners. Driving car down highway and engine begins to shudder. Pulled over as check engine lights were flashing and engine in critical condition. Had to tow car to nearest Ford delearship which is Maxwell Ford in South Austin, Texas. Ford mechanics determined it was MISS FIRE ON CYLINDER 2 VALVE BROKEN IN CYLINDER HEAD and need complete engine reassembly. Ford quoted $7,871.21 for a new engine block. Car not under warranty and they did not offer to pay. Also charged $238.07 to evac the AC. Reading about hundreds of complaints across carcomplaints (https://www.carcomplaints.com/Ford/Fusion/2015/engine/engine-2.shtml) as well as the current class action lawsuit that was filed in December 2020 (https://www.carcomplaints.com/Ford/Fusion/2015/engine/engine-2.shtml).
Overheated warning light flashed then went off when car was cooled down for 45 mins and then started right up and no warning light was ever seen again to come on then drove car 30 miles next morn car wouldn't start.checked engine coolant and it was all gone no visible leak.. no warning light Refilled coolant car tried to start and put out white smoke from tailpipe. Car started barely and was rough running again no warning light showing drove car to mechanic and he said car engine was blown .. so looked on different forums and found that the Ford fusion and Ford escape motors the 1.5 liter was a real lemon and the overheat light warning of low coolant or overheating of engine has had problems for several years on these 2 vehicles that had the 1.5 engine in them .. you can no longer buy the 1.5 because they were so terrible that they quit making them is what I'm being told .. I would like this engine to be recalled for all the problems it has given thousands of people
We bought this car at the end of May 2020. When we bought it it had 48,000 miles on it. We have had this vehicle for 14 month and have religiously kept up on maintenance. Started having issues beginning of July 2021. Today, 7/22/2021 we received notice that the car needs a new engine due coolant leaking into the cylinders. We have only put 17,000 miles on this car. There is absolutely no reason for it to need a new engine.
I have received a message on my dashboard regarding 1. Engine Coolant Over Temperature 2. Power Reduced to Lower Engine Temperature. I have taken the car to a repair shop Thursday and Friday. I believe car is a lemon. Have had the vehicle for only 17 days. I can’t keep calling off work due to non operational vehicle. I would like to get this issue resolved or otherwise I would not be able to pay my car note
Took car in to ford dealership to have check engine light assessed. Was told there was a coolant leakage through the #1 cylinder and I would need to have the motor replaced. I was quoted $7100.
The contact owns a 2015 Ford Fusion. The contact stated upon starting the vehicle, the vehicle failed to accelerate while the accelerator pedal was depressed due to an engine misfire. The contact also stated that a quarter of a gallon of coolant was added within two weeks with the vehicle leaking coolant. The contact stated that the check engine warning light was illuminated. The vehicle was then taken to a local dealer where it was diagnosed with the spark plugs needing to be replaced. The vehicle was repaired however, the failure occurred. The vehicle was taken to an independent mechanic where it was diagnosed with the engine needing to be replaced. The vehicle was not repaired. The contact related the failure to an unknown technical service bulletin. The manufacturer was informed of the failure and referred the contact to the federal safety agency. The failure mileage was approximately 75,000.
Engine overheated on highway. Cracked engine block. Could have been hit by other vehicles. Short Block replaced by Ford dealer which I had to pay for. There were prior engine codes [usually P302] . A local auto repair shop replaced coils but wasn't able to find cause.
My 2015 Ford Fusion is having an issue where the coolant is leaking into the cylinders. I had new spark plugs and coils replaced twice in less than a week because of this issue because they broke. It’s an issue I have read that a lot of Ford fusions have but no recall has been issued. To fix this problem, Ford gave me an estimate of over $8000 and it should be fixed by ford since it’s a revolving issue with certain models.
The contact owns a 2015 Ford Fusion. The contact stated while driving 55 mph, the vehicle stalled. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with the head gasket needing to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure but offered no additional assistance. The failure mileage was approximately 130,000.
Car idles rough and almost stalls causing a safety issue. The problem is a bad block. Coolant leaks into the cylinders causing the car to lose power and smoke out the exhaust. The problem was diagnosed by a local auto repair shop. No check engine lights or warnings came on the dash.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Ford Fusion?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history