Canister purge valve malfunction. Car stalled completely and would not start back up. Thankfully this happened when I was driving slow in a parking lot and not on the busy freeway. Another time it happened at the gas station when trying to re-start my car after putting fuel in. We ran diagnostics on it and it face the error of the canister purge valve malfunction.
2016 Ford Fusion fuel system complaints
Page 3 of 4: complaints 41 to 70 of 92, newest first, as owners wrote them.
Purge fuel valve. Car is stalling at times. Other times it won't start. This has been a recall in the past but not showing on my VIN. Sometimes it is making a noise.
I have a new alternator, new battery, but the PCM unit for the fuses is bad.
Car wouldn't accelerate. Would stall after pumping gas would overheat when idling. Fans were not turning on canister purge valve stuck open causing the fuel tank and oxygen sensor to fail.. Runs rough.
The car started missing like thr transmission was going out til it completely stopped running. Finally had the transmission replaced and it did it again. The tappet on the high pressure fuel pump under the hood ended up being the problem. The cam shaft is wearing a hole in them I just replaced it a second time in 3 months. Now I have metal in my engine and ford said they have been selling them pretty quick so that tells me there is a problem.
I have a car health monitor plugged into my obd ii port, it's out just one day read (cylinder 2 misfire) so I drive to work and then call hiltop ford (richmond ca)to bring it in to see what's wrong. They performed recalls but as far the issue I brought it in for they said, that they had no idea what's wrong with the car and have to replace the entire engine. And directly after telling me this and me leaving I get a call from the sales department trying to set up and appointment to purchase a new vehicle! So now I'm of the mindset that something is fishy. I then took the car to a mechanic I know, during that ride my car begins to overheat, off and on. After getting the car to the mechanic he ran his diagnostics and told me yeah my I have a spark plug that's out and needs to be replaced. I get that done, everything is fine for about 3-4 weeks. Then the same thing happens (cylinder 2 misfire and overheating) at this point I don't trust ford cause they new they at least knew the spark plugs was out. Back to the mechanic I go, he then let's me know that there's a notice out describing the issue so he told me to contact ford to see if they'd fix it. Again ford 'knew nothing' of the sort. And my car just stopped and won't start and it is directly related to the issues the car has had. Now here I am trying to find the best course of action and not have to purchase a new car. Not sure why this isn't recalled when it's happening to a lot of people.
I have had my car for only 3 months now. Absolutely no signs that anything was bad or starting to go out. I was driving with my daughter leaving the bank and my car dies in the middle of the rd in a curve!!! The wrench tool light pops up and says see owner manual/ in the manual this indicates a power train/ awd problem. The car when started idles very rough and doesn't want to accelerate. I have read other complaints that is exactly like mine with the 2016 ford fusion. I am a single mom of 4 and only have this car. I am getting it to a mechanic to see what shows up. From what I have seen on other complaints it has to do with failure of the throttle body sensor! Had someone been behind me we could've been hit due to the car stalling in the rd! Luckily I was going down hill and was able to coast onto a side road!! Thank god! Many other cars the same as mine are experiencing this! Please investigate this problem and recall the parts associated with it!! This is extremely dangerous especially where I live( mountains) with winding roads and less visibility for a car behind me if I stall out in a curve like I did today! I was driving on a secondary road when this happened, near the main road.
While driving on the highway, the car suddenly displayed a 'wrench' indicator which states 'see owner's manual'. The car lost the ability to accelerate (gas pedal/acceleration was disabled). After steering the vehicle to the side of the road, the car began to idle very rough before the car was turned off. I attempted to restart the vehicle, but the engine continued to idle very rough and the wrench light and check engine light both appeared illuminated. Upon inspection with an obd ii code reader, the code 'p2111' was displayed. This indicated a 'stuck open' throttle, resulting in the disabled acceleration of the vehicle. After the code was cleared, the vehicle started normally and was able to be driven home on surface roads. After brief inspection, the throttle appears to be mechanically in good condition, and investigation online indicates many other vehicles of this make/model experience a failure of the throttle body sensor. This explains the symptoms exeprienced by my vehicle despite the mechanical condition of the throttle being good. Fortunately, nobody was hurt, but sudden loss of acceleration could be extremely dangerous in a variety of scenarios, especially at highway speeds.
The car shut off randomly and the check engine light came on. I started the car again and it starts. When I fill up, it starts, but it hesitates to turn off again, and sometimes doesn't come back on. It's something to do with the air in the tank due to it being capless. When it comes to the body, the door alert came on 6/12/2020 stating that the foot was open randomly. I was driving to a nearby store going about 20 MPH with the doors locked and fully shut.
The high pressure fuel pump and sensor went bad after 81000 miles. The car had a whining sound when the gas pedal was depressed. The car sputtered while accelerating. The car lost propulsion at highway speeds.
About a year ago the vehicle would just stop for no reason. The check engine light would come on occasionally and it said it was the fuel sensor. Sometimes the car would completely shut down when accelerating or at highway speeds. Took the vehicle in for repairs on october 17, 2019 and the issue was resolved. Now, a few months later, the same thing is happening.*dt*dt consumer replaced the fuel pump on 05/29/20 and since then has recurred 2 more times, unable to accelerate.
I bought the care in april 2017,within a moth I started smell car outside the car when ever I started it. You car smell it up to 75 ft away. Towards the front and drivers side. It s burnt gas. Just like you were filling you gas tank. I took it to my dealer for a check up 5/6 times for this issue. Each time they say nothing wrong and they can't smell the gas. Yet my salesman and other customers in the parking lot has smelled it. Strangers in the grocery store and smelt it and warned me. Including a ford mechanic who advised me to take it to a shop.he was from a different ford dealer.my co-workers smell it. My gas levels are showing it as well. At the time this started I was still under manufacturer warranty at 57,000. Now @ 64,000. Have extended. Found out same car with larger engine has same problem however the dealer refuses to believe maybe me car or the engine may have same problem. Service bulletin:16-00452013-2016 cars. Pcv valve part ej726758b.this was found by a friend a ford engineer. Even he said it s possible the smaller engine could have the same problem. However the dealer won't even look at it.what do I do? Now I hear a rattling sound upfront in the engine area. I only drive approx. 12 miles a say unless I go grocery shopping.like I said it's a 2016 with 64,000, beautiful car.just this one issue. Can't smell when driving only when parked.only from outside of car! It is not the exhaust like I said it is clean unburnt gas! This happens daily.
So this started just about a week ago I noticed I had low coolant, I had serviced my car recently so I thought maybe they just forgot to add some, it wasn't below the minimum line but it was getting near so I topped it off, well not I notice my coolant is leaking further more and more, I've researched it online and many people are having this issue although there's no recall issues there should be, people are paying thousands of dollars for a new engine because of a defect and I fear I'm going to be one of those people also, they claim the 2nd piston goes out due to coolant leaking inside. Please please investigate this defect, ford lied about their ford focus and now it's their ford fusion.
Tl* the contact owns a 2016 ford fusion. The contact stated while driving at 40 MPH, there was an abnormal sound coming from the front of the vehicle. The contact pulled over and inspected the vehicle and became aware that the driver's side front axle was detached from the vehicle. The vehicle was taken to fair oaks ford lincoln located at (2055 w ogden ave, naperville, il 60540) to be diagnosed. The contact was informed that the driver's side control arm and subframe needed to be repaired. The vehicle was towed to an independent mechanic where the diagnosis was confirmed. The vehicle was repaired. The contact stated that after refueling, the accelerator needed to be depressed while starting the vehicle. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the fuel pressure valve needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.
We bought our ford fusion se in august 2019 and now we're told our purge valve needs to be replaced and it isn't covered by warranty. Our check engine light came on when driving on the interstate and we made an appointment immediately to be seen.
Evap fuel vapor canister purge valve assembly failed. Dealer charging $314.00 and said ford does not cover this part under warranty. This is an emission component with many comments about known failure.
My car will shut down and lose all power without notice when I'm at highway speeds. A comment comes on the dash that says something like " transmission is not in gear" or something like that. I'm not sure of the exact words because whenever it does it I'm looking to get to the far right lane so I can come to a complete stop on the side of the highway to come to a stop, put the car in park, turn it off then turn it back on. It's so dangerous to have the car lose all power going 70 MPH. I really think something needs to be done on this before someone gets killed. This has happened probably 5 different times in the past few months. I don't have the exact dates when it's happened but the last time it did I was traveling in kansas city and thought I was going to cause a large accident trying to get my car over to the shoulder without power.
I found a fuel leak on my 2016 ford fusion titanium ecoboost. About 5 months ago when I first notice the problem, a smell of fuel on the left rear passenger side door and as you go further to the rear,the smell of fuel gets stronger, I went to the ground to check for any sign of leaks but I never found any, except for the strong scent of fuel. I thought it was just a fuel thats coming from the fuel refill cap and didnt pay much attention to it. Not until after coming back from work,about 5 months later and went to tend for my vehicle that were parked in our drive way for 5 months, as I sat down on the driver seat and start the engine, I notice the gas on the tank, it was 1/4 left but prior from leaving the vehicle at the drive way, I refuel it and left it with a full tank, so I went around my vehicle to investigate the under carriage of the car and ended up seeing a stain of fuel leak on the ground and as I went deep down under the vehicle were the tank is located, I start to see a trace of fuel dripping down from the gas tank and to the tank shield or tank cover?! I cant named the plate that holds the fuel tank and as I trace it further to the gas tank I saw were the leak is coming from and its coming from were the refill tube was installed..! I start to check the web for any clues on what could cause it from getting a crack on the tank and found that ford fusions had recalls for the same car, same brand, same year but different manufactured month date but same on the manufactured year wich is 2015 and still ford motor company denies a factory deffect and wont grant me a recall that were made at the same year, brand,model but different manufactured month.. I hope that someone could adress this issue and get the problem fixed specially when a problem involves a fuel, it is very serious not only for safety of the motorist but to endanger our ecosystem as well...
I have a 2012 ford focus and as you know a 2016 fusion as well . Shortly after I purchased my focus I received a recall for the purge valve a couple weeks ago my check engin light came on and now it's doing the same dying at stop lights and even on more then one occasion either dying while driving or one last night doing 75 MPH on freeway in the fast lane with no shoulder and heavy traffic I called ford coprportat and they said there were no realls for this vehicle, I just passed 60,000 miles and not my warranty is up.
While driving down the freeway at 70 MPH all of a sudden had a loss of throttle service wrench light, airbag light, see owners manual lit up happened in an area where there was nowhere to pull off the freeway very unsafe heard of a recall that had happened for a throttle body issue that I never received notice for car mileage currently around 60, 500 miles ford fusion se have a known issue with this among other ford products is it going to take someone to get killed in order for a recall to be reordered talk to the dealer and they are not willing to help me told me that I have to pay for all of the stuff out of pocket. This has happened about four times so far and I am currently not driving the vehicle as I feel unsafe in that vehicle
Tl* the contact owns a 2016 ford fusion. While driving approximately 25 MPH, the contact heard a strange grinding sound coming from the rear driver's side of the vehicle. Also, an abnormal burning odor entered the cabin. The vehicle stalled and the check engine warning indicator illuminated. The vehicle was taken to imperial ford (8 uxbridge rd, mendon, ma 01756, 508‑473‑2800) where it was diagnosed that the solenoid and purge control failed. The vehicle was currently being repaired. The manufacturer was made aware of the failure. The failure mileage was 74,000.
All off a sudden, it will take off then. I have to stop and reset all the safety issues
On going! Dealership here in florida states okay? Stearing is a problematic , electrical systems need to be checked, turning needs to checked. They have my car listed as a hybrid? It is not. Multiple complaints
Takata recall, loud humming/ vibration noise appears to be coming from underneath rear of vehicle. First started while driving on the street, pulled over to check and it was when the engine would not turn back on, engine light turned on, after this the key fob push to start has not been working and every time you pump gas the engine has problems turning on, only turns on after pressing the gas.
I'm losing has very fast
When filling gas tank it seems to have air in the tank. Sometimes after filling the car won't start for a couple minutes and when it does, it sputters like it will cut off, but after you get it running it's okay. Also, you can never get the same full tank distance, it will vary each fill up with the same fuel economy with each fill up.
I have received a settlement form as well as for this lease fusion and my first one as well. I it not acting correct! Gas smell , sterrng, horn weak, took to dealership at woodbridge with my friend while I am not in fla . For the short while the previous car red 2015 was replaced at purvis ford in fredricksburg, va. When I was here last time in 2015. It was ready to blow!
Car dies while driving on city street or exiting freeway. Cause unknown. Driving the ford fusion titanium on city streets results in the car dying while in motion as the speed slows, for instance to make a right or left turn onto another street. When the car dies I have been able to coast to the side of the road, a parking lot, or left turn lane where I have to completely turn off the vehicle and try restarting. Just prior to the car dying a vibrating or revving noise can be heard from the driver's side rear passenger door/gas tank door area. This seems to occur at 55 MPH or lower, and especially while decelerating at turns, red lights, or exiting a freeway. I have managed to get out of the way of other cars but this is a very dangerous situation. The occurrence was about once every 4 months until lately the frequency increased to monthly. I have not driven the car since this occurrence on 11/4/2018 as this is too dangerous. The gas tank revving noise serves as about a 3 second warning, which allowed me to take evasive actions. I'm taking it to a ford dealership.
Car repeatedly dies after driving about 4-10 miles after first starting. Has died on me while at busy intersection (middle of it!) and has died by train tracks! Also died while merging onto interstate, has also died while driving on interstate. Happens while in motion. Ford says its purge valve system ($700) same issue with recall on 2012-2018 ford focus, but ford will not pay for this dangerous problem that has happened to many ford owners!
Car will sound like someone is reeving their engine behind me but its the car. Then car will shut down as I am driving down the road. Everything still works but can not get the car to move. Try to hit the gas pedal and nothing happens. Went to advanced auto and they said it was code p1450 the guy explained it to me as the fuel vapor canisters the purge valves does not operate properly resulting in abnormal pressure changes in the fuel tank.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Ford Fusion?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history