Ford Maverick Hybrid won't shift problems

Filed Oct 27, 2026 · Brakes, Driver assistance · AZ

in the ford maverick hybrid, ford has been aware of parasitic drain issues related to its software in the ABS braking system and it air condition system which causes degradation of the battery. there are service messages sent to ford dealerships regarding these issues (SM 55215, SSM 53801, SSM 54785). There are incidences of Ford dealerships upgrading software, upgrading batteries, and dealing with these as warranty issues. The effects cause no start situations and gear shift lockups with engine limp modes enacted. Through various Maverick owners and forums this has been seen in multiple vehicles. This can create dangerous issues if the system fails in the middle of driving on highways and stranding individuals in remote or unserviceable areas is apparent and with Ford providing service messages to dealership mechanics. It is apparent that it is something in ford's manufacturing process. The outcome to recall should not wait for a dangerous event or death to create said recall, but promote proactive response to the dangers created by faulty software that was created at Ford adn endanger the consumer purchasing their product as this not only affects them but also all others around them as we all travel the highways together.

Filed Sep 14, 2026 · Transmission · KS

My 2022 Ford Maverick Hybrid has twice suddenly entered limp mode and experienced a substantial loss of power. The first incident occurred on or about XXX. After leaving my subdivision, I turned onto [XXX], which has a posted speed limit of 55 mph. The vehicle immediately lost power and entered limp mode, and the engine and wrench warning lights appeared. The weather was clear and sunny. I was able to drive several miles at substantially reduced power and return home. On XXX, at 83,600 miles, Louisburg Ford retrieved DTC P1061, determined that Ford TSB 25-2454 applied, and reprogrammed the required modules. The second incident occurred on 9/13/2026. My husband and I were returning home after traveling through [XXX], [XXX], and [XXX]. We were driving northbound on I-35 near mile marker 182 at the [XXX] exit, just south of [XXX]. It was completely dark and storming, with rain and lightning, when the vehicle again entered limp mode and lost power in highway traffic. We were fortunate to have cellular service and a gas station nearby. Otherwise, we could have been stranded in dangerous conditions. On XXX, at 106,338 miles, the same dealer retrieved the same P1061 code and again applied TSB 25-2454 by reprogramming the PCM. The same loss-of-power condition, code, and Ford-prescribed repair recurred within approximately 11 months and 22,738 miles. The dealer advised that there is no guarantee it will not happen again. I am concerned that this sudden loss of acceleration or motive power could recur at highway speed and cause a crash. I request that the federal safety agency investigate this recurring condition and whether TSB [XXX] provides an adequate remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 13, 2026 · Acceleration, Transmission · CA

As I was traveling on freeway at 65 mph cruise control disengaged. After I was notified to service engine soon and check engine light came on. Throttle was unresponsive forcing me to cross 4 lanes of the 5 freeway. Pulled over and shut off vehicle checked fluids. Nothing out of spec.restarted vehicle and would not get out of limp mode.

Filed Dec 20, 2025 · Transmission · WA

When driving at higher speeds (60-70mph) and needing to pass another vehicle the clutch slips which triggers the accelerator to shut down. Leaving you helpless in the passing lane. All you can do is hope there is space to safely pull off the road and shut the engine off. This puts it in limp mode.

Filed Nov 5, 2025 · Driver assistance, Electrical · TN

I had been driving for 2 hours on the interstate when the truck starts losing power and warning lights start flashing. I got the truck to the shoulder before it slammed to a stop. I turned the engine off and waited until all the power turned off before restarting. The truck would only run in limp mode at 35 mph. I drove on the shoulder of the interstate to the next exit. I disconnected the battery and reconnected which allowed me to drive it normally to the dealership. After two days the dealer called to say they didn’t see any codes and there wasn’t anything wrong with it even after I sent pictures of the warning messages. This is the 5th time this has happened under similar circumstances.

Filed Sep 7, 2025 · OH

On sept6,2025 while driving on highway at 65mph truck went into limp mode so you could not accelerate although trying to and the speed of the truck decreased. Had to pull off to berm of road for safety. Turned truck of and it appeared to reset itself and there were No Warning lights on dashboard when this occurred. This could have been a deadly accident if I wasn't able to get off on berm as quickly as I did! Vehicle will be scheduled with dealer this week! But this is an ongoing problem as stated in Ford maverick community website.

Filed Jun 27, 2025 · Electrical, Transmission · 9,000 miles · VA

The contact owns a 2022 Ford Maverick. The contact stated that the rotary gear shifter was stuck in park(P). The contact had to wait for over 15 minutes for the rotary gear shifter to move. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that recently the rotary gear shifter moved independently when touched by the arm. The vehicle was not diagnosed or repaired for the most recent failure. The contact stated that the failure persisted. In addition, while using the USB plug, there were several unknown messages displayed on the screen. The contact stated that after a while, the radio turned off independently. The manufacturer was not notified of the failure. The failure mileage was approximately 9,000.

Filed Dec 17, 2024 · Transmission · CA

Vehicle spontaneously went into limp mode while driving on the highway. Slowed to 20 mpg and would not accelerate. Required pulling onto the shoulder of the road.

Filed Sep 18, 2024 · Engine, Transmission · CA

Issue: Shift SYS Fault, DTC P07E6 System: Transmission Description: Emergency parking brake failed to disengage (solenoid could be heard attempting to move), as a result the transmission would not shift out of park. Check engine light and multiple codes/warnings illuminated on dash. Vehicle could not be moved or shifted into neutral. Waited 10-15 minutes before 2nd attempt, parking brake still failed to disengage. Then waited for 3 hours for third attempt, at which point emergency brake successfully disengaged. Check engine light no longer lit and no codes/warnings present on dash. Nothing changed or was done to the truck between the 2nd and 3rd attempt. Reproduction: Will drop off at dealer for confirmation in coming weeks. Warnings: Engine check light, Shift SYS fault, DTC P07E6, See dealership -> all illuminated after parking brake attempted to disengage during 1st and 2nd attempt.

Filed Jul 21, 2024 · Electrical, Fuel system · NC

Driving at approximately 65 miles per hour. Vehicle suddenly went into neutral I was forced to pull over on a busy highway. The dashboard was illuminated with several warning lights and messages. After one key cycle, I was only able to drive in a limited limp mode. After a second key cycle and waiting a few minutes, I was able to drive like normal but an engine light stayed illuminated.