2022 Ford Maverick Hybrid: stuck in gear or won't shift

Filed Sep 14, 2026 · Transmission · KS

My 2022 Ford Maverick Hybrid has twice suddenly entered limp mode and experienced a substantial loss of power. The first incident occurred on or about XXX. After leaving my subdivision, I turned onto [XXX], which has a posted speed limit of 55 mph. The vehicle immediately lost power and entered limp mode, and the engine and wrench warning lights appeared. The weather was clear and sunny. I was able to drive several miles at substantially reduced power and return home. On XXX, at 83,600 miles, Louisburg Ford retrieved DTC P1061, determined that Ford TSB 25-2454 applied, and reprogrammed the required modules. The second incident occurred on 9/13/2026. My husband and I were returning home after traveling through [XXX], [XXX], and [XXX]. We were driving northbound on I-35 near mile marker 182 at the [XXX] exit, just south of [XXX]. It was completely dark and storming, with rain and lightning, when the vehicle again entered limp mode and lost power in highway traffic. We were fortunate to have cellular service and a gas station nearby. Otherwise, we could have been stranded in dangerous conditions. On XXX, at 106,338 miles, the same dealer retrieved the same P1061 code and again applied TSB 25-2454 by reprogramming the PCM. The same loss-of-power condition, code, and Ford-prescribed repair recurred within approximately 11 months and 22,738 miles. The dealer advised that there is no guarantee it will not happen again. I am concerned that this sudden loss of acceleration or motive power could recur at highway speed and cause a crash. I request that the federal safety agency investigate this recurring condition and whether TSB [XXX] provides an adequate remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 13, 2026 · Acceleration, Transmission · CA

As I was traveling on freeway at 65 mph cruise control disengaged. After I was notified to service engine soon and check engine light came on. Throttle was unresponsive forcing me to cross 4 lanes of the 5 freeway. Pulled over and shut off vehicle checked fluids. Nothing out of spec.restarted vehicle and would not get out of limp mode.

Filed Jun 27, 2025 · Electrical, Transmission · 9,000 miles · VA

The contact owns a 2022 Ford Maverick. The contact stated that the rotary gear shifter was stuck in park(P). The contact had to wait for over 15 minutes for the rotary gear shifter to move. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that recently the rotary gear shifter moved independently when touched by the arm. The vehicle was not diagnosed or repaired for the most recent failure. The contact stated that the failure persisted. In addition, while using the USB plug, there were several unknown messages displayed on the screen. The contact stated that after a while, the radio turned off independently. The manufacturer was not notified of the failure. The failure mileage was approximately 9,000.

Filed Dec 17, 2024 · Transmission · CA

Vehicle spontaneously went into limp mode while driving on the highway. Slowed to 20 mpg and would not accelerate. Required pulling onto the shoulder of the road.

Filed Sep 18, 2024 · Engine, Transmission · CA

Issue: Shift SYS Fault, DTC P07E6 System: Transmission Description: Emergency parking brake failed to disengage (solenoid could be heard attempting to move), as a result the transmission would not shift out of park. Check engine light and multiple codes/warnings illuminated on dash. Vehicle could not be moved or shifted into neutral. Waited 10-15 minutes before 2nd attempt, parking brake still failed to disengage. Then waited for 3 hours for third attempt, at which point emergency brake successfully disengaged. Check engine light no longer lit and no codes/warnings present on dash. Nothing changed or was done to the truck between the 2nd and 3rd attempt. Reproduction: Will drop off at dealer for confirmation in coming weeks. Warnings: Engine check light, Shift SYS fault, DTC P07E6, See dealership -> all illuminated after parking brake attempted to disengage during 1st and 2nd attempt.

Filed Jun 14, 2024 · Engine · NJ

On June 13th 2024 my Maverick suddenly lost power and all lights on dashboard lit up. Apparently this has been documented by others, and vehicle then went into LIMP MODE and was not responding to accelator pedal properly and would not move beyond 30mph. Engine light is still on, and my Ford App shows 3 messages: 1. SERVICE ENGINE SOON 2. POWERTRAIN SYSTEM FAILURE 3. COLLISION AVOIDANCE UNAVAILABLE

Filed Jun 5, 2024 · Transmission · VA

Was driving at 60 mph, without warning vehicle displayed error with power train module and shifted in to neutral. Vehicle lost engine power and would not respond. Vehicle would not shift into drive, pressing on accelerator pedal did nothing. Without warning vehicle shifted itself into park very abruptly. Could not shift into drive or low drive. Turned vehicle off and the. back on, vehicle would shift into drive. Attempted to get out of the flow of traffic, would not accelerate, almost collided with another vehicle. Vehicle would only accelerate to 30-35mph.

Filed May 18, 2024 · Electrical, Engine · AL

The Maverick unexpectedly switched to limp mode and had engine failure while in motion. The Maverick would not go over approximately 25mph unless coasting faster on a downhill. On some uphills, it struggled to maintain 10mph. Turning the vehicle off and back on again did not alleviate the issue. Approximately two months ago, I started to have a check engine light on. It took the dealership two months to get my Maverick in for service. The service finally occurred this past Monday/Tuesday (13-14 May). Ford thought they fixed the issue which they had not. They also did the current recalls on the truck. This most recent highly dangerous issue happened after those recall software updates. The FordPass Alert: "The powertrain control module has detected the engine timing chains have exceeded 95% of their useful life and requires service now. The control system invokes a symptom of limited power." This is a common issue amongst Maverick Hybrid owners and Ford is not doing anything to fix the issue. Many Maverick owners are having it happen multiple times and at speeds up to 70 or 75 mph. it is preferable that Ford be forced to take responsibility and fix the issue before people are serious injured or killed. Thank you.

Filed May 14, 2024 · Engine, Transmission · CA

While driving on the highway my car randomly went into limp mode rapidly and nearly caused an accident. I do know the code was U1011. It is a PCM fault stating the PCM and the engine has lost connection. It has been noted to turn on and off randomly and cannot be replicated until it reappears. Dealerships have been giving the run around that it goes away so it’s not a problem. Everyone to include me is having the problem after getting a recent PCM update recall done. My local ford deal shops even say they can see the fault happens, but will not do anything to solve the issue. This fault puts me and everyone in the road as risk randomly sending my car into limp mode without warning or signs.

Filed May 11, 2024 · Engine · WV

On [XXX] my husband was traveling on [XXX] in Pennsylvania between mile markers [XXX] and [XXX], on cruise control driving 75mph. As he was starting up a steep incline, the Maverick (without warning) started to lose speed, went into LIMP mode (power to engine failed ) and the dashboard lit up with several different errors. He was in heavy traffic and had to swerve to the left median to pull over to safety, narrowly avoiding an accident. He did a vehicle inspection to ensure all fluids were still intact, wires were secure, etc. and did not detect anything wrong. He let the Maverick sit for 15 minutes and started the vehicle. The Maverick started with no issues, so he assumed it was a fluke and continued driving to reach his destination of Upstate NY from West Virginia. Before he could reach the NY border, his Maverick suddenly went into LIMP mode again while traveling up another incline on cruise control (also at 75mph). This time he was able to swerve to the right median to avoid causing an accident. He followed the same steps as before, and the Maverick turned on again without issue. He continued his drive to NY and was able to successfully make it without using cruise control. He brought it to our local Ford Dealership in Hagerstown, MD (the Ford dealerships in NY did not have capacity to assess the Maverick as we were only in NY for a couple of days). Our local Ford Dealership was not able to find anything wrong with the Maverick and said because they could not generate the same errors there was nothing they could do. We did show the the history of the errors as it's all contained on the Ford App, but they dismissed it as they couldn't figure it out. This happened again on [XXX] driving down [XXX] between mile markers [XXX]-[XXX], in a construction zone. He was thankfully able to pull over, narrowly avoiding getting rammed by a semi truck behind him. Our dealership refuses to help us fix the error. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 7, 2024 · Electrical, Engine · TX

While driving at approximately 40mph, the 2022 Ford Maverick Hybrid suddenly went into "Limp Mode" with speed instantly dropping to approximately 10mph. Did not lose power, the dashboard stayed lit but showed no warnings. Vehicle would not accelerate above 10mph. This happened without warning. I pulled over and shut off the vehicle then restarted it and after that, it operated fine. If I had been driving on a highway at a higher speed I could have had a major accident. Currently trying to get a service appointment, waiting on a call back from the Ford dealer Service Manager. Again, there were no warnings or error messages before or after the problem occurred.

Filed Apr 29, 2024 · Engine, Transmission · CA

On 4/27/24 Vehicle went into limp mode after driving for less than 90 seconds. Multiple various errors messages (powertrain, hill assist, collision, check engine) lit up, vehicle was accelerating on its own when in drive. No error messages prior to this incident. Similar incident happened around 3/10/23 while at Ford service for recall software updates but issue was not confirmed at that time. Vehicle is at Ford service now for second incident. Ford service states when the vehicle got a recall completed for the SOBDCM update, it triggered the vehicle to not update fully and causes the warning messages and can force the vehicle to go into limp mode and lose power.