2022 Ford Maverick Hybrid: adaptive cruise control problems

Filed Jan 13, 2026 · Acceleration, Transmission · CA

As I was traveling on freeway at 65 mph cruise control disengaged. After I was notified to service engine soon and check engine light came on. Throttle was unresponsive forcing me to cross 4 lanes of the 5 freeway. Pulled over and shut off vehicle checked fluids. Nothing out of spec.restarted vehicle and would not get out of limp mode.

Filed Jun 10, 2024 · Engine, Transmission · OK

I was driving on the highway at about 65 MPH. Without warning, the vehicle dashboard displayed “Selected Gear Will Engage at Lower Speed,” the vehicle shifted itself to neutral, the accelerator pedal stopped responding, and the vehicle began coasting to a stop. I had to avoid high speed highway traffic to make it to the side of the road. When I had slowed to about 5 MPH, the vehicle forcibly shifted to park, and engaged the parking brake on its own — causing an abrupt stop. I could not shift out of park. The check engine light, wrench icon, traction icon all illuminated, the chime sounded and a series of errors displayed: “Service Advance Trac” “Collision Prevention Unavailable” “Hill Start Unavailable” “Service Engine Soon” among others. After power cycling the vehicle, the warning messages and icons remained, but I could shift into drive. However, the vehicle wouldn’t travel above 30 MPH, and seemed to accelerate on its on, as if it were on cruise control set at 30 MPH. Abruptly stopping on the highway is very dangerous, and could have caused a serious accident. Unless there is a catastrophic failure (which there wasn’t) the vehicle should never uncontrollably stop, especially on the freeway.

Filed May 11, 2024 · Engine, Transmission · VA

Drove my car home and parked in my driveway with no issues. 9 hours later when I was about leaving for work, started the car but car won't start. I jumpstarted the car then all of a sudden the (Drive) Shift knob light was flashing, warnings started flashing, hill start assist not available, service vehicle soon, pre collision assist not available, service advance Trac, and parking brake applied automatically and total loss of power. When I pressed on the gas, it wouldn’t go and no throttle response. When I let off the brake and was NOT pressing the gas, it would start to accelerate all on its own up to about 28/29 mph all on its own, acting like it was in cruise control

Filed May 11, 2024 · Engine · WV

On [XXX] my husband was traveling on [XXX] in Pennsylvania between mile markers [XXX] and [XXX], on cruise control driving 75mph. As he was starting up a steep incline, the Maverick (without warning) started to lose speed, went into LIMP mode (power to engine failed ) and the dashboard lit up with several different errors. He was in heavy traffic and had to swerve to the left median to pull over to safety, narrowly avoiding an accident. He did a vehicle inspection to ensure all fluids were still intact, wires were secure, etc. and did not detect anything wrong. He let the Maverick sit for 15 minutes and started the vehicle. The Maverick started with no issues, so he assumed it was a fluke and continued driving to reach his destination of Upstate NY from West Virginia. Before he could reach the NY border, his Maverick suddenly went into LIMP mode again while traveling up another incline on cruise control (also at 75mph). This time he was able to swerve to the right median to avoid causing an accident. He followed the same steps as before, and the Maverick turned on again without issue. He continued his drive to NY and was able to successfully make it without using cruise control. He brought it to our local Ford Dealership in Hagerstown, MD (the Ford dealerships in NY did not have capacity to assess the Maverick as we were only in NY for a couple of days). Our local Ford Dealership was not able to find anything wrong with the Maverick and said because they could not generate the same errors there was nothing they could do. We did show the the history of the errors as it's all contained on the Ford App, but they dismissed it as they couldn't figure it out. This happened again on [XXX] driving down [XXX] between mile markers [XXX]-[XXX], in a construction zone. He was thankfully able to pull over, narrowly avoiding getting rammed by a semi truck behind him. Our dealership refuses to help us fix the error. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 25, 2024 · Electrical, Engine · WV

On April 1, 2024, while using cruise control going uphill on the interstate in heavy traffic, the truck went into LIMP mode without warning, and multiple lights appeared on the dashboard. Once I swerved over to the side of the road I turned the truck off, let it sit for 15 minutes and turned it back on. Turning it back on allowed the truck to get out of LIMP mode, but the check engine light remained. This happened several times on my drive, but I was able to finally finish my drive several hours later. Next day, all lights on the dashboard were off. The ford dealership could not determine the source of the issue or recreate the issue. This is a major concern as this issue put my safety at risk and could have caused a major accident on a major interstate, putting others’ safety at risk as well. On April 23, 2024, I went to start the truck, and the battery was dead. I confirmed no lights were on to drain the battery, and from April 23, 2024 forward, my power windows randomly stop working.

Filed Apr 22, 2024 · Acceleration, Electrical · CT

Vehicle was in cruise control driving along the highway at-speed when the engine suddenly cut out and cruise control stopped maintaining speed. Pressing the accelerator did nothing, but the brakes still worked. After turning cruise control off the accelerator was still having no effect, and the vehicle did not let me re-engage cruise control. All other electronics (navigation, music, dash, hazard lights, etc.) continued to work fine, but I noticed that the light on the gear selector was blinking instead of the normal solid yellow. I pulled over onto the shoulder and came to a stop, at which point the vehicle put itself into park and engaged the parking brake. Several warning and advisory messages appeared on the screen advising me not to drive the vehicle, and almost all of the warning lights on the dash lit up. The electronics continued functioning for a time, but after a short while (less than 2 hours) they died as well. This included the locks, mileage indicator, windows, hazard lights, and gear shift—the vehicle could not be put into neutral. The vehicle was loaded onto a flatbed tow truck and taken to a dealership. Service invoice is attached. To summarize, it appears that a failure in the heat exchanger caused engine to cut out. Cause of electrical failure after stopping is unknown.

Filed Apr 17, 2024 · Electrical, Engine · 18,000 miles · MI · 1 injury

The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 45 MPH, his girlfriend who was occupying the front passenger's side seat, informed him that there was an abnormal odor inside the vehicle. Additionally, the contact sustained severe headaches while driving. The contact drove to the hospital, where he was informed that there was an elevated level of carbon monoxide in his blood, and he had sustained carbon monoxide poisoning after two hours of exposure. The contact also stated that the check engine warning light was illuminated intermittently. The vehicle was taken to the dealer, where it was determined that the heater exchange needed to be replaced. The vehicle was repaired. Additionally, the contact stated while driving 70-75 MPH with the Adaptive Cruise Control engaged, a message indicating that the gear was changed forcibly was displayed, and the Eco mode was disengaged, and the engine stalled. The contact was able to pull to the side of the road. The messages "Service Advancetrac", "Service Engine Soon" "Pre-collision Assist Not Available" and "Hill Assist Not Available" were displayed on the instrument panel. Additionally, the messages "Power Train System Fault" and "Collision Assist Unavailable" were displayed on the mobile app. The traction control warning light was illuminated. The contact was able to restart the vehicle after several attempts and a Police Officer assisted the contact in driving to the other side of the road. The contact was able to continue driving at 45 MPH. The vehicle was taken to the dealer, where the failure could not duplicated because the check engine warning light was not illuminated. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 18,000.

Filed Mar 31, 2024 · Engine, Fuel system · MI

I experienced a loss of engine power/propulsion at 71 mph. There were no warning lights, messages or chimes to indicate something was wrong. I only noticed I was losing speed when the cruise control went to the standby/cancelled state from the 71 mph set point. The accelerator pedal was completely unresponsive. I coasted to the side of the freeway and performed a key cycle by powering the vehicle off, opening and closing the driver’s door to put the modules to sleep. Once the instrument panel cluster and center stack screens went dark, I restarted the vehicle and was able to proceed with my trip. It’s worth noting that I recently had the instrument panel recall repair performed which was a reflash of the IPC module. Other Maverick drivers have reported similar incidents after Ford 24C01/the federal safety agency 24V140 was “fixed.” I will be reporting this to the manufacturer as well.

Filed Feb 26, 2024 · Engine, Transmission · NY

Engine completely fails while driving at highway speeds. Press on accelerator and no power. However Electronics, dash etc, are still on. It has happened 6 times in 2 weeks. Maverick has 26K miles. Each time I have had to coast to a safe shoulder or exit without any ability to accelerate. No warning lights, messages or other symptoms prior to occurrence. I have had it happen in "Normal" mode while using cruise control and lane assist. I have had it happen in "Normal" mode without using lane assist or cruise control. When it does happen, warning light says pull to safety, and check engine light remains on. I Am able to brake, place car in park, turn off car, restart, check engine light remains on and then am able to drive briefly again. It then happens again. Originally happened on Feb 14, 2024, then again on Feb 22, 2024, and then 4 times on February 25, 2024. Have taken back to dealer each time. Dealer cannot find anything associated with Code readings. Dealer is unable to duplicate. Ford has been unresponsive in providing any service bulletin. I am not the only Maverick Hybrid vehicle experiencing this. An outstanding engine failure and engine fire recall remains without resolution from Ford. I have given them permission to drive vehicle 100 miles, as that is when it first occurs. My vehicle is not safe to drive. My daughter and I were almost killed on high speed highway when the engine failed and 18 wheeler barreling down behind us. Ford has offered no solution or steps to compensate for this danger.

Filed Mar 9, 2023 · Engine · CO

Issue: Gasoline engine shutdown unexpectedly while driving. The following identical events occurred once each on June 14 and June 15, 2021. In both instances I was driving northbound with the (adaptive) cruise control set at 72 miles per hour, with Driver Alert enabled, and with extreme west-to-east crosswinds in excess of 50 mph per highway warning signage. While driving I received several driver alert messages – assumed to be due to the high crosswinds – which I ignored as I was not drowsy. Then without warning the gas engine shutdown and would not re-engage (pressed the accelerator to the floorboard), requiring me to quickly move to the shoulder of the roadway before the vehicle came to a complete stop. I shutoff the ignition, waited for about 30 seconds, and then restarted the vehicle and continued driving without further incident each day despite the fact that the wind persisted and the Driver Alert messages continued. This happened once on two consecutive days and has not occurred since, making note of the fact that I have not driven in severe wind conditions since. Fortunately these two events occurred in sparsely populated areas of Wyoming and Montana with fewer vehicles on the roadway, had it happened on a more densely traveled highway the safety of myself and others could have been at risk.

Filed Mar 2, 2023 · Driver assistance · NY

On Monday 2/27/2023 I was driving northbound on the Taconic Parkway in New York going with my cruise control and co-pilot360 adaptive lane control engaged. I think I dozed off for about 20 seconds and during this time my co-pilot disarmed and my Maverick drove off the highway. Fortunately I regained control before I hit a sign or trees. I damaged a front rim, but it was a very close call. I am a very good driver normally, but this feature should be investigated. I understand that it is not "autopilot". I have the dash-camera video here: https://youtu.be/z6hpNyx3snc a. Co-pilot shuts off at .020 b. Truck leaves road at .036

Filed Oct 29, 2022 · Brakes, Driver assistance · GA

Maverick Hybrid brakes are inconsistent. Sometimes you can brake smoothly, sometimes you cannot and the brakes will grab suddenly and lurch. Using Adaptive Cruise is miserable because the truck lurches back and forth and feels like it can't transition between friction and regenerative braking. There are no warnings on dash, truck has 1,000 miles. It is dangerous because getting more braking force than you anticipated can lead to being rear ended and not getting the brake force you anticipate can cause you to rear-end someone else.