2022 Ford Maverick transmission problems

Filed Sep 6, 2026 · Transmission · CA

While driving on the streets the powertrain module gave out. It started to jerk around 30 mph and then just would not go.

Filed Aug 18, 2026 · Fuel system, Transmission · CA

While driving my 2022 Ford Maverick on a public road, the vehicle suddenly lost acceleration and would not respond normally when I pressed the accelerator. I was left in the roadway and could not safely continue driving, creating a risk of being struck by other traffic. The vehicle was later inspected by a Ford dealership and diagnosed with a major internal transmission failure at approximately 62,000 miles. The Ford dealership recommended a rebuilt/replacement transmission. The vehicle remains available for inspection. I did not have advance warning that the transmission was about to fail.

Filed Jul 26, 2026 · Transmission · NH

I had stopped at an intersection and when I applied the gas, the truck stuttered a bit before going. It ran okay for less than a mile. I stopped at the next intersection and when I applied the gas, the truck shuttered, started to go then just stopped. It stayed running but didn't want to go. I was able to get it through the intersection but that was it. The message i am getting is powertrain malfunction/reduced power. When we put our diagnosis tool on it, we get code P0757.

Filed Jun 26, 2026 · Transmission · FL

I am filing a formal safety defect complaint regarding a severe catastrophic transmission failure on my 2022 Ford Maverick ( 2.0L EcoBoost 8f35 8 speed transmission ) that poses an immediate safety hazard to occupants and sharing traffic. Upon inspection a heavy volume of metal shavings flakes were discovered also the code PO73D unable to engage in neutral came up. The safety risk of this specific failure is extreme because the vehicle is physically unable to respond to a neutral command the driver cannot clear or cut engine power to the drive wheels during an emergency mechanical malfunction or a potential unintended acceleration event. Furthermore because the metal debris the truck exhibits severe erratic shifting behavior and a persistent risk of sudden high speed wheel lockup drivetrain binding or stalling inactive traffic. Ford motor company is fully aware of this component failure despite my vehicle exhibiting the exact failure mode the exact code PO73D and metal debris found has refused financial responsibility I urge the federal safety agency to upgrade this known issue to a mandatory safety recall

Filed May 30, 2026 · Transmission · FL

Transmission started slipping. Not wanting to pull in drive or reverse

Filed May 27, 2026 · Transmission · NC

Ford has 25N09 addressing the axles for the 2022 Ford Mavericks built later in the 2021 year, but mine was built in September of 21. I have axle issues as well, and this is the first vehicle I've ever had that's this new and has clunking in the CV axles. Mine clunks loudly, and the truck has 114k on it.

Filed May 9, 2026 · Electrical, Suspension · TX

When we brought it in for first oil change at the dealership ; when we got it back it had a broken axle which they tried to say we just needed new tires , after contacting service manager and he and I go for a ride in it they kept it for several weeks and put over 300 miles on it and got ford engineering involved to determine the cause was broken axle. It has been replaced again since then supposedly by a recall but it feels like it is broken again ! Ford took some shortcuts and used inferior parts, infrastructure etc , we had tremendous problems with the battery to which they said their shouldn’t be any reason for this be happening loss of power loss of electrical display and distribution finally I just had to replace the battery on my own because they refused to accept responsibility 4-6 months later a recall for the batteries was issued. The axles on the truck are not sufficient and they are not taking care of it properly! I would also like to report that they cut so many corners on the Maverick that the tailgate just drops no shock absorber nothing just slams on the bumper very dangerous! & They also chose to leave many open” holes” where mud rocks , leaves etc get into the front quarter panels from the hood area at the corner of windshield . So this wet material gets trapped in there n I’m sure will eventually affect the structural integrity of the panel - maybe rust through! Same thing happens with the tailgate fills with debris from bed , rear wheel wells also have a whole. I just wish ford would go back to how Henry Ford ran the company ! Help the federal safety agency

Filed Apr 24, 2026 · Transmission · AL

Vehicle started experiencing loss of power while driving on the highway. After having it towed to the local Ford dealership, we were informed that our transmission was shot and needed to be replaced. The vehicle had 62k miles on and no dash light warning and no ford pass warnings about the issue. It cost us $7k to replace and 4 months without the vehicle.

Filed Mar 30, 2026 · Transmission · CA

There is a Ford Customer Satisfaction Program, 25N09 issued September 2025 which covers half shaft replacement for Mavericks manufactured from 12/01/21 through 11/23/22. The upgraded beefier replacement half shafts were not available until late 2024. The program states that if the half shafts on one side fails that that both half shafts are to be replaced. My 2022 Maverick was manufactured 11/21/2021 (the second month of production), a mere 10 days before the initial date of coverage. The half shaft on one side was replaced on 01/10/25 with the upgraded version of the half shaft under warranty. They did not replace the other side. If the beefier replacement half shafts were not available until late 2024 how am I to believe that my Maverick does not have the same under engineered pieces in the other 68,000 2022 Mavericks?

Filed Mar 13, 2026 · Transmission · PA

My 2022 Ford Maverick (EcoBoost AWD) experienced a sudden transmission failure at approximately 73,000 miles. The dealership diagnosed the issue as coolant contamination entering the transmission due to a failed heat exchanger/transmission cooler. The dealer stated that engine coolant mixed with the transmission fluid, which destroyed the transmission and required replacement of the transmission, replacement of heat exchangers, and flushing of the cooling system. The repair estimate is $11,324.39. Ford acknowledged the issue and provided partial goodwill assistance of $3,079, leaving more than $8,000 out of pocket for the repair. This failure occurred without warning and resulted in complete transmission failure. The dealer indicated that coolant contamination is the cause and referenced Ford service guidance addressing this failure scenario (SSM 53465). I am concerned that a failure of the transmission cooler/heat exchanger can allow coolant to contaminate the transmission and cause catastrophic drivetrain failure at relatively low mileage.