2021 Ford Mustang Mach E visibility problems

Filed Oct 29, 2026 · Driver assistance, Electrical · PA

On August 8, 2026, my 2021 Ford Mustang Mach-E Premium experienced a serious electronic lockout. The vehicle was running, with the air conditioning and music on, when the doors locked and I was unable to regain entry. My keys, phone, purse, medication, and other essential belongings were inside the vehicle. I attempted multiple methods to regain access, including the driver’s door keypad, but I was unsuccessful. I remained locked out for approximately 7.5 hours and ultimately had to break the windshield to reach inside and unlock the vehicle. My understanding is that Ford had previously performed a recall remedy addressing a potential electronic door-lockout issue on this vehicle. I am concerned that the vehicle experienced a similar safety-related malfunction after that remedy. I do not yet know the precise technical cause and am requesting investigation. Following this incident, my vehicle experienced repeated 12-volt battery and no-start problems. When the vehicle was left at Kenny Ross Ford for diagnosis, I was later unable to get it to respond to the key or show lights or audible signals, and it did not appear to respond when connected to a charger. The dealership’s inspection subsequently recommended replacing the 12-volt battery and conducting a parasitic-drain test, but the report provided to me did not establish the cause of the original lockout. I am concerned that an electronic failure involving the door-latch system, 12-volt power supply, vehicle control modules, or recall-related software may have prevented safe access to the vehicle. I am requesting that the federal safety agency review this incident in light of Ford recall 25V404, manufacturer campaign 25S65, which addresses a potential lockout condition associated with low 12-volt battery voltage and electronic door latches retaining their locked state. I am not asserting that the recall has been proven to be the cause. I am requesting investigation into whether this incident reflects the same or a related safety defect

Filed Apr 30, 2026 · Visibility · NJ

There’s a known recall. “2021 Mach-E models produced between Feb 24, 2020, and July 18, 2021, are at risk of the glass panels detaching or leaking.” But my car, a 2021 model, isn’t on the list. I just discovered that my headliner is stained and there’s a leak.

Filed Feb 7, 2026 · Electrical, Fuel system · PA

After recall-related software updates were performed on my 2021 Ford Mustang Mach-E, the vehicle began experiencing repeated electrical and climate control failures. The heating and defrost system stopped working, leaving the vehicle without heat and causing the windows to fog, which reduces visibility in cold weather and creates unsafe driving conditions. The vehicle has been taken to multiple authorized Ford dealerships for inspection and repair; however, the problem returned immediately after the repair. The issue was reproduced and confirmed by a second dealer. A required part is currently on back order until the end of Feburary, leaving the vehicle unrepaired for an extended period. In addition, the vehicle experienced 12-volt battery failure and slow charging after the last recall update. These issues were not present prior to the recall. There were no warning lights before the failures occurred. During severe winter weather conditions in Pennsylvania, the lack of heat and defrost made it extremely difficult and unsafe to operate the vehicle. Because of reduced visibility and freezing interior temperatures, the vehicle could not be safely driven and, due to frigid temperatures, has remained parked. I am still making monthly payments on a vehicle that cannot be reliably or safely used.

Filed Jun 1, 2025 · Visibility · CT

Requested dealer to perform recall "Inadequate Front Windshield Bonding/FMVSS 212" Dealer reported "our vendor did not actually perform any work on the windshield, he confirmed work was done elsewhere with a reseal so there was nothing we actually did" There is no documentation supporting the reseal work was done on this vehicle.

Filed May 19, 2025 · Visibility · WV

Per your instructions I'm filling this complaint due to Ford refusing to perform recall 21S42/21V712 Issued on 09-14-2021. I have opened multiple complaints with Ford Corp regarding their dealerships refusal to perform this safety recall in which the roof of my vehicle can fly off during operation. For weeks now I've been trying to get Ford to provide me with a dealership that would perform the recall as I have been refused by 5 local dealerships. Ford tells me "we can't force the dealership to do anything" and have refused to find a dealership that will do this recall and contact me. I have been attempting to get this recall done on and off for 3 years now.

Filed Aug 25, 2024 · Driver assistance, Electrical · WI

The instrument panel center display fell out of the housing today. Keep in mind this display controls things like all HVAC, defrosting, audio, rear cross traffic camera, and is the sole access to the front trunk (frunk). It looks like two seals on the top failed. When driving slightly inclined on a hill, it became detached and was dangling. This caused immediate distraction. The screen did not break. The screen fits back into the casing but there is no mechanism to attach it without complete permanent (ie superglue).

Filed Apr 17, 2024 · Visibility · NJ

The contact owns a 2021 Ford Mustang Mach-E. The contact received notification of the federal safety agency Campaign Number: 21V711000 (Visibility). The contact took the vehicle to the dealer however, the vehicle was not diagnosed or repaired. The contact stated that the dealer was advised to not service the vehicle to prevent damages to the front windshield. The manufacturer was made aware of the issue and informed the contact that the vehicle could not be serviced unless the contact paid for the front windshield to be repaired out of pocket. The vehicle was not paired. The contact had not experienced a failure. Parts distribution disconnect.

Filed Mar 13, 2024 · Visibility · CA

I have been trying for over one year to get the safety recall work completed. Ford tells me to contact the dealership to schedule maintenance. I contact the dealership and they refuse to schedule service and tell me they will call me when they are able to handle the request. I tried contacting ford and they told me they cannot interfere with the dealership's scheduling process.

Filed Sep 28, 2023 · Visibility · 44,000 miles · WI

The contact owns a 2021 Ford Mustang Mach-E. The contact stated that a puddle of water was found in the front driver's side seat after a heavy rainstorm. The vehicle was taken to a dealer where an inspection was performed. The result showed that the adhesion around the windshield was defective which led to water intrusion inside the vehicle. The contact was made aware of the federal safety agency Campaign Number: 21V711000 (Visibility); however, the VIN was not included. The manufacturer was notified of the failure and the contact was provided a case number and referred to the federal safety agency Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 44,000.

Filed Jul 28, 2023 · Visibility · CA

Windshield loose adhesion from paint separation from primer. The Glass windshield in my car had a small chip occur while driving at 40 mph.. about 60 seconds later a crack appeared about 18 inch long lengthwise across the windshield. after being parked will ordering a new windshield the crack grew to 90 percent the horizontal width of the windshield. Later while having the windshield removed for replacement by the owner New View glass in a cool indoor environment we examined the windshield adhesive and found that the paint was peeling off from the primer where the glass adhesive attaches to the car. The strength of the paint or clear coat bond to the primer or car metal is not sufficient to hold in the glass as a structural part of the car body. I am a car dealer so have more windshields replaced that a normal person. It is very unusual to see this condition. I am aware that some 2021 Mustang mach e had a recall for this condition but this VIN was not included in that recall. Perhaps it should have been. The glue just peels off with the clear or paint