2021 Ford Mustang Mach E steering problems

Filed Oct 3, 2026 · Brakes, Steering · NC · crash

I was involved in a car accident on the XXX I was in the turn lane and a second vehicle hit my driver side, spun me around, and I ended up facing the opposite direction. What occurred next is my safety complaint. The vehicle continued to travel forward and, in fact, accelerated and I was unable to turn or stop in spite of hitting the brake. It caused me to hit a third vehicle and I stopped short of a gas line. There was a recall on this vehicle 22S29. The issue was a functional safety monitor software fault which potentially caused unintended acceleration, unintended deceleration, or unexpected movement I purchased the car in 2023. The recall was dated May of 2022 and was noted on the market valuation report / supplemental information. I was not aware of this recall and I do not believe the issue had been corrected prior to purchase in spite of being told that all recalls had been addressed prior to my purchase. Luckily, nobody was severely injured. I sustained chest wall contusion from the airbag, possibly rib fracture(s) and sternal fracture. My grandson who was [XXX] old was in the backseat and he was not injured luckily but was very traumatized. There were no warning signs. There was a police report but no ticket. The car was totaled so it is not in my possession at this time. The auto dealer that had performed several recall issues for me after my purchase did not have any record that this particular recall had been addressed. I have filed a complaint with Ford as well. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 4, 2025 · Steering · AZ

The car steering oscillated right and left similar to a 2022 recall description.

Filed Jul 30, 2024 · Brakes, Steering · WI

My car has repeatedly had to have rotors replaced due to warping. Between 12,000 and 36,000 miles I’ve had 7 pairs of rotors replaced. After exceeding 50 mph, when braking I decided violent steering wheel vibrations between 43-35 MPH when braking normally. I have service records and video to back up my claim. Ford is calling this “normal wear and tear” however no other 2021 mach-es vehicles in my geographic area have had this issue, in fact none have had to have rotors replaced at all. This is a serious safety issue, occurring approximately every 3,000 miles. This points to a defective vehicle, Ford refuses to cover the repairs now that the vehicle has passed 36,000 miles despite having a verified service record of 7 rotor replacements. The date below is for the most recent issue, it has been going on for a year and a half. Ford clearly doesn’t understand how to fix it, as the same fix has been recommended every time to the same result. I can’t upload the videos but happy to send for additional support of my the defective vehicle assertion, it helps to show how much of a safety issue this is.

Filed Apr 17, 2024 · Brakes, Fuel system · HI

This is a follow up to ODI 11510437 that was filed via the phone in 2/2023 related to now the federal safety agency Recall 23V687. The vehicle in question experienced exactly the issue described in the recall notice. Our incident was part of the federal safety agency investigation. The vehicle had its high voltage battery junction box replaced in +/- March 2023, but the new box was the same design as the old box that is poorly engineered. Notices sent out in Fall of 2023 indicating that there was a recall were not sent to us for this vehicle. Similarly, the notice sent in April 2024 informing Mach E owners to schedule appointments at their dealer was not sent to us for this vehicle. Upon contacting Ford, they indicated that this vehicle is not part of this recall. After insisting on speaking to a supervisor, he claimed that it was now a part of the recall but refused to provide me any written acknowledgment of this. When pressed further he then said that our vehicle was not part of the recall because the part was already replaced. When I explained that the part replace was the same defective part he told me to call the dealership or the federal safety agency because he would do nothing further. He went on to say that there was nothing further he would or could do, nor would it transfer me to anybody at Ford that could address our unique circumstances. Upon calling the federal safety agency they advised, (amongst other things), that we file a complaint via this portal.

Filed Dec 9, 2023 · Acceleration, Driver assistance · TX

After transitioning from i35 south, to Highway 183 towards Austin-Bergstrom International Airport, the auto-pilot (Ford Blue Cruse) fails, the speedometer fails, the battery level indicator fails, the instrument cluster fails, cruse control picks a random speed and struggles to keep it, lane keep assist is erratic at best. This occurs every time, and in both directions, I take my vehicle on that highway. I took a video of it this last time, and offered it to Ford. They recommended I file this report with this agency.

Filed Aug 22, 2023 · Electrical, Fuel system · NY

I am filing this complaint regarding the potential failure of the High Voltage Battery Junction Box. There have been many failures reported on the forums some experiencing multiple failures. Ford provided a software update that supposedly predicts an impending failure reducing available propulsion power. I do not feel comfortable driving a vehicle with a ticking time bomb. Losing propulsion power while driving at highway speeds could result in a serious safety senerio. I would like to see Ford provide a real fix.

Filed Jun 8, 2023 · Brakes, Electrical · LA

I was driving on the highway (12) in Mandeville, Louisiana and the car (a 2021 all electric Mustang Mach E with only 13k miles) flashed a 'Stop care safely now' sign and then proceeded to power down within 3 seconds of the message. I exited (luckily I was at my exit) and felt the car lose power on the exit ramp. Three signals came up (battery - yet I was at 100% - then a turtle mode and not sure what the third symbol was) and then the car locked up - went into park, would not move or allow me to put into neutral to pull off a very busy highway ramp. I was forced to a dead stop on the ramp (very dangerous). I put on my hazard lights but cars still pilled up all around me, beeping etc. at high rates of speed. I called 911 and the police came out (took about 10 minutes during which time I had to direct traffic around me - again very dangerous) and asked that I move the car but the car would not move or even go into neutral. A DOTD tow truck towed me to a nearby Winn Dixie and then the roadside assistance towed to the Ford Dealer. The Ford Pass app send me the message attached below that said it was forcing a software update and the car would not be able to be used during this update - while the car was in drive and while I was driving it down a four lane highway! Very unsafe considering the car was connected to WIFI at home and that update could have been done at any time - not while driving. There was no notice prior to this that a software update was needed and we have it set for updates to happen at 1 am. The car relies upon software (not firmware) to run and if that fails, the car just locks up. This car should be recalled. I am lucky no one was injured including me trying to direct traffic on a busy high speed highway ramp. The policeman was very frustrated and made me get out of the car. Then the DOTD driver confirmed it would not budge. Thank God this didn't happen while I was in the middle of a 4 lane highway. It would have been like stopping on a train track.

Filed Jun 6, 2023 · Acceleration, Electrical · AL

Erratic behavior when semi-autonomous Blue Cruise engaged. Fault may be due to failures/malfunctions in side view mirror camera modules.

Filed Jul 31, 2022 · Electrical, Fuel system · MO

On May 14, 2022, I stopped twice on a 120 mile trip to recharge my Mach E at a level 3 DC charger. Upon completing each charge, the ring around the charging port turned red and I received a default message. I plugged my car into my home level 2 charger and the car completely locked down and I was unable to reenter the car. I have since learned that this is the classic sign of a HVBJB failure. The dealerships updated the car's programming but did not replace the HVBJB. The HVBJB subassembly in ALL Ford Mach-e vehicles has known defects with 'under-designed' main contactors that are known to fail under normal charging and driving conditions as outlined in current open Ford recall notice for my vehicle 22s41. Unfortunately, the internal damage to contactors is not visible externally, and warning notices on display only after damage has occurred, and can result in sudden loss of propulsion power at highway speed, loss of power steering, and power brakes... and failure of other 12v systems due to failure to charge the 12v battery properly after contactors are damaged. Less catastrophic results can include failure to start; which can 'strand' driver's and passengers in remote areas, bad weather conditions, as well as cause loss of use for weeks due to delays in replacement parts and local Dealerships needing equipment and training to effect removal/replacement of faulty unit with a new HVBJB having re-designed 'beefier' components.​ ​ My complaint is that Ford's recall notice 22s41 is a software-only attempt to prevent future damage, and does not require removal of the part(s) which are KNOWN TO FAIL to be replaced with the re-designed components which are available, and have been used to repair failures under warranty. I have no way of inspecting the original equipment to evaluate current condition; and failure can result in sudden and unexpected loss of power, steering, and braking as well as potentially 'stranding me' in unsafe conditions.

Filed Jul 21, 2022 · Electrical, Fuel system · VA

The HVBJB subassembly in ALL Ford Mach-e vehicles has known defects with 'under-designed' main contactors that are known to fail under normal charging and driving conditions as outlined in current open Ford recall notice for my vehicle 22s41 the federal safety agency Campaign Number: 22V412000. Unfortunately, the internal damage to contactors is not visible externally, and warning notices on display only after damage has occurred, and can result in sudden loss of propulsion power at highway speed, loss of power steering, and power brakes... and failure of other 12v systems due to failure to charge the 12v battery properly after contactors are damaged. Less catastrophic results can include failure to start; which can 'strand' driver's and passengers in remote areas, bad weather conditions, as well as cause loss of use for weeks due to delays in replacement parts and local Dealerships needing equipment and training to effect removal/replacement of faulty unit with a new HVBJB having re-designed 'beefier' components.​ ​ My complaint is that Ford's recall notice 22s41 ( the federal safety agency Campaign Number: 22V412000) is a software-only attempt to prevent future damage, and does not require removal of the part(s) which are KNOWN TO FAIL to be replaced with the re-designed components which are available, and have been used to repair failures under warranty. I have no way of inspecting the original equipment to evaluate current condition; and failure can result in sudden and unexpected loss of power, steering, and braking as well as potentially 'stranding me' in unsafe conditions unable to re-start my vehicle.​ ​ I would like to see the federal safety agency strengthen the Ford recall to include both improved software AND removal/replacement of the HVBJB sub-assembly with the new 'beefier' parts.