Ford Mustang Mach E door locks problems

Filed Nov 4, 2026 · Body, Electrical · FL

The right front passenger door opened unintentionally while driving. When making a left-hand turn, the right front passenger door swung open without any input from the driver or passengers. Upon further inspection, the electric door latch appeared to have no power, causing it to fail in the unlatched position while driving. Fortunately, no passengers were sitting in the right front seat at the time.

Filed Oct 29, 2026 · Driver assistance, Electrical · PA

On August 8, 2026, my 2021 Ford Mustang Mach-E Premium experienced a serious electronic lockout. The vehicle was running, with the air conditioning and music on, when the doors locked and I was unable to regain entry. My keys, phone, purse, medication, and other essential belongings were inside the vehicle. I attempted multiple methods to regain access, including the driver’s door keypad, but I was unsuccessful. I remained locked out for approximately 7.5 hours and ultimately had to break the windshield to reach inside and unlock the vehicle. My understanding is that Ford had previously performed a recall remedy addressing a potential electronic door-lockout issue on this vehicle. I am concerned that the vehicle experienced a similar safety-related malfunction after that remedy. I do not yet know the precise technical cause and am requesting investigation. Following this incident, my vehicle experienced repeated 12-volt battery and no-start problems. When the vehicle was left at Kenny Ross Ford for diagnosis, I was later unable to get it to respond to the key or show lights or audible signals, and it did not appear to respond when connected to a charger. The dealership’s inspection subsequently recommended replacing the 12-volt battery and conducting a parasitic-drain test, but the report provided to me did not establish the cause of the original lockout. I am concerned that an electronic failure involving the door-latch system, 12-volt power supply, vehicle control modules, or recall-related software may have prevented safe access to the vehicle. I am requesting that the federal safety agency review this incident in light of Ford recall 25V404, manufacturer campaign 25S65, which addresses a potential lockout condition associated with low 12-volt battery voltage and electronic door latches retaining their locked state. I am not asserting that the recall has been proven to be the cause. I am requesting investigation into whether this incident reflects the same or a related safety defect

Filed Sep 28, 2026 · Driver assistance, Transmission · NY

My vehicle dash displayed "vehicle not in park" multiple times immediately after I put it in the drive position. At times I could push the "ok" prompt and proceed to drive but when I slowed or. stopped at intersections it would occur again and sometimes it applied the park brake without any action on my part. Around the same time I started getting "door module fault" or "door lock fault" warnings. It's been at a dealer over a month so I don't recall the exact wording now. The dealer diagnosed the vehicle and determined the door module fault made the vehicle think it was moving with the door open and replaced it. After the repair they're now saying it's unsafe to operate because while in their custody it's automatically applying the brake and displaying a "shift indicator module fault" that also requires replacement. They told me Ford doesn't offer coverage beyond the 3/36 basic warranty however it doesn't seem unreasonable to expect a shift mechanism to work for the life of a vehicle but certainly longer than 4 years. The dealer service advisor commented to me that he's seen these gear shift modules fail on several models including F150's as well as EV and combustion models. If this is a component known to fail across different models that posses a safety risk such as unexpected braking it could be an accident waiting to happen if it hasn't already.

Filed Sep 12, 2026 · Acceleration, Electrical · VA

Multiple intermittent electrical/software malfunctions in my Ford Mustang Mach-E, one of which poses an acute safety risk. STEERING WHEEL BUTTON / UNCOMMANDED ACCELERATION: A button on the steering wheel, when pressed, causes the vehicle to suddenly accelerate to a high speed with no corresponding throttle input from me, and speed cannot be immediately brought back under control. This creates a serious risk of collision to myself, passengers, and other road users. DOOR LATCH: A door does not open fully ("bounce open") as designed. This matches Ford recall 25V404, covering doors that may fail to open, potentially trapping an occupant during an emergency exit. ALARM SYSTEM: Alarm is either overly sensitive (false triggers) or fails to trigger when it should — an inconsistent fault suggesting an underlying electrical issue. DISPLAY SCREEN: Center/instrument screen intermittently goes black while driving, temporarily removing visibility of speed, warnings, and camera views. REAR SOUND BAR: Rear-seat speaker intermittently stops working. Not itself a safety risk, but suggests a broader wiring/electrical fault affecting several systems at once. Component available for inspection: Yes, upon request. Reproduced/confirmed by dealer or independent shop: UNKNOWN. I have called the dealer twice and been unable to reach anyone to schedule diagnostic service. Inspected by manufacturer, police, or insurance: UNKNOWN. No inspection has occurred yet. Warning lamps/messages before failures: UNKNOWN. No consistent warning appeared beforehand; symptoms occur intermittently without advance alert.

Filed Sep 8, 2026 · Driver assistance, Electrical · NY

Impacts: Electric system software & fools/locks/linegae. The EV vehicle has suffered a catastrophic, complete failure of its central software architecture, specifically impacting the APIM module and RDS system. Ford's internal In-Vehicle Technology (IVT) records confirm this failure originated in December 2025 while vehicle was fully under its 3-year bumper-to-bumper warranty. Because vehicle's underlying diagnostic and software infrastructure is completely frozen in an unresolved "updating" loop, the vehicle's onboard diagnostic tools are entirely incapable of reading or reporting critical hardware and structural component failures. Initial service was May 26. This software failure has caused severe, active safety hazards. In July 2026, the driver-side door latch completely failed to secure. Because software is bricked, no diagnostic code or dashboard warning was generated. As a 100% disabled driver, I was forced to drive 35 minutes home from an oncology medical appointment physically holding the driver’s door shut at speed on public roads to prevent it from swinging open. Furthermore, vehicle's network connectivity has completely shut down while driving on 3 separate occasions. During door latch failure, I was trapped in a rural area with zero cellular service. Because onboard telematics and modem systems are frozen and failing to receive critical safety patches, vehicle's SOS Post-Crash Alert System and tracking telemetry are severely compromised. If an accident or ejection had occurred due to the door latch failure, emergency services would have had no automated tracking link. Ford has failed to repair this after multiple extended dealer stays and has admitted through their IVT department that vehicle is unfixable due to massive never before seen software failure via standard service and requires manufacturer buyback. Dealer files att show no vehicle updates since Feb 2026 tho IVT confirmed May 28 not updates since Dec 2025 from Ford known software glitch.

Filed May 18, 2026 · Body · 1,700 miles · CA

The contact owns a 2025 Ford Mustang Mach-E. The contact stated that upon entering the vehicle and backing out of his driveway, heard an abnormal scraping sound coming from the vehicle. Upon exiting the vehicle, the contact discovered that the charging port door had opened independently and scraped the garage door frame. As a result, the frame on the charging port door had detached from the vehicle and was on the floor. Despite the failure, the contact slid the panel back into the door; however, the charging port door would not close. The contact then used painter tape to secure the charging port door and drove immediately to the dealer. As the contact explained the failure to the dealer, they contended that the failure was caused by normal use and that the repair would not be covered under warranty or recall. The manufacturer was notified of the failure by mail and received a response that the repair would not be covered under warranty. The contact then called the manufacturer and was informed that there were no programs that would cover the repair. The vehicle was repaired. The failure mileage was approximately 1,700.

Filed Jan 22, 2026 · Electrical, Transmission · FL

I am requesting immediate escalation regarding my 2021 Ford Mustang Mach-E (VIN: [XXX] ), which is currently undrivable due to being stuck in “Power Accessory Active” mode. The vehicle will not enter Drive. The dealer has diagnosed DCEM / high-voltage system-related faults and stated that recall repairs cannot be completed unless I first pay approximately $3,000 to repair the “main battery.” My concern is that the symptoms and failure mode exactly match the known High-Voltage Battery Junction Box / DCEM defect described in Ford Safety Recall 23S56, including: •Vehicle unable to drive •High-voltage system refusing to close contactors •Vehicle remaining in accessory power mode •Safety-related loss of motive power While my VIN may not be currently listed as eligible for these recalls, my vehicle is exhibiting identical symptoms and failure modes associated with the following Ford safety recalls: •HV Battery Junction Box / DCEM defect (Recall 23S56) •Powertrain / Software Update (Recall 22S29) •12-Volt Battery / Door Latch Entrapment Risk (Recall 25S65) It is important to note that other Mustang Mach-E owners have reported the same recall-related failures even when their VINs were not listed for these recalls. These failures involve contactor issues, loss of motive power, and vehicles being stuck in accessory mode — identical to the symptoms my vehicle is experiencing. Given that my vehicle is experiencing a safety-related loss of motive power, Given the safety implications and known defect history, I request that this matter be reviewed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 28, 2025 · Body · PA · crash · 1 injury

I bought this car in August of 2024. It started having issues with the door lock in September and in December I decided to sell it back to the dealer but was in a car accident on the way to the dealership. Unfortunately the door jamming issue caused repair problems and the auto repair shop could not fix the door issues. I lost the car to the repair shop in a lien sale due to the cost of repair which was over $20,000. In August of 2025 Ford issued a recall which allowed the auto repair shop was able to fix the car and sell it to a dealership. I have contacted Ford several times in relation to the issues with the car and how they caused me to loose the car, but they have not responded despite the promise to do so in 7-15 business days. Loosing this car has caused deep stresses in my life. I have lost several business clients because I'm no longer able to get around. I have had my life impacted to the point of having to relocate. I bought the car outright paying $45,000. Ford has refused to do anything to compensate for my loss.

Filed Aug 21, 2025 · Electrical, Fuel system · FL

I lease a 2024 Ford Mustang Mach-E. On [XXX] the vehicle suddenly displayed a High-Voltage Battery Fault, Powertrain Malfunction / Reduced Power warning. The dealer replaced the High-Voltage Junction Box (HVJB), however I am unsure whether the actual root cause was ever identified. This failure shows a major defect in the high-voltage electrical system. Separately, my vehicle is also subject to Recall 25S65 / the federal safety agency 25V404, where a discharged 12-volt battery can prevent the electronic door latches from opening, risking passenger entrapment. Ford has no remedy available and has only projected a future software update. My car is still at the dealership. These two issues are connected: the HV system (through the HVJB) powers the DC-DC converter that keeps the 12-volt battery charged. A failure on the HV side can starve the 12-volt system, which directly creates the entrapment risk described in the recall. I live in Florida, where extreme heat makes this risk especially dangerous for children, pets, and elderly passengers. What is my emergency plan...carry a hammer to break the windows on every trip? This is an unreasonable and unsafe expectation for consumers. Ford has not provided any fix or assurance of safety. I have specifically asked Ford whether my car is safe to drive — they have not provided any assurances, merely repeating that Ford has not issued a stop-driving order on the vehicle. This unresolved defect substantially impairs the use, value, and safety of my vehicle, and Ford has failed to provide an adequate repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 18, 2025 · Electrical, Locks · 50,000 miles · CA

The contact owns a 2021 Ford Mustang Mach E. The contact received notification of the federal safety agency Campaign Number: 25V404000 (Electrical System, Latches/Locks/Linkages); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that his wife parked and turned off the vehicle; however, while attempting to exit the vehicle, his wife was locked inside the vehicle. The contact quickly searched for how to unlock the vehicle. The contact pushed the exterior door lock twice, and his wife was able to unlock and exit the vehicle. The contact called Ford Assistance Service, and the vehicle was jump-started and the vehicle was driven to the dealer. The dealer diagnosed the vehicle with battery failure. The contact was informed that the battery needed to be replaced. The battery was replaced. The dealer confirmed that the software update for the recall repair was not yet available. The manufacturer was not made aware of the issue. The failure mileage was approximately 50,000.