2017 Ford Mustang: fire, smoke or burning smell

Filed Jul 24, 2026 · Electrical, Seats · UT · fire

Was driving, all the sudden I heard a pop and a little bit of smoke and the smell of burning plastic came from under passenger seat. Pulled over, noticed it was coming from electrical harness under seat that controls the heated and cooled seats. Disconnected plug and saw that it had burnt out & caught fire. Have left it unplugged with no incident since.

Filed May 28, 2025 · Brakes, Electrical · IN · fire

Was driving and the traction control light came on car started shaking, pulled over got out to look and the car was on fire. Fire started in the right rear of the trunk Where the backup camera wire harness is located. It has not been inspected. Car is currently at an impound lot but is available for inspection.

Filed Mar 3, 2025 · Engine · 25,000 miles · NJ

The contact owns a 2017 Ford Mustang. The contact stated while driving at various speeds, there was white smoke coming from under the hood. No warning light was illuminated. Upon further investigation, the contact related the failure to TSB: 19-2260; however, the vehicle was not included. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 25,000.

Filed Jun 26, 2024 · Driver assistance, Electrical · OR · crash · fire

Was in the car during a very slow, around 5mph front end collision. The knee airbag went off at low speed. I. Exited the vehicle to look at damage and then I sat back in the driver seat. Upon sitting back in the driver seat I noticed the smoke that had cleared from the airbag had started to build back up and became more dense. I had my feet outside the door while sitting in the driver seat and when I when I looked around I noticed a fire getting larger and larger from the pillar to my left, between the rear seat and the front driver seat. I didn’t have anything to put it out so I tried to blow it out and it was getting larger and larger melting more of the plastic up the pillar. I ripped off a work shirt I had and was able to smother the fire with it. Had I not been able to smother it this fire would have engulfed the whole vehicle. After observing the damage the wiring harness had shorted out and burnt/ caught on fire that goes from the front of the vehicle to the back.there was no prior damage to the vehicle and no damage to the car other than the front end collision during the accident.

Filed May 24, 2024 · Engine · 83,000 miles · TX

The contact owns a 2017 Ford Mustang. The contact stated that while driving at approximately 15 MPH and making a U-turn, the engine overheated, and the vehicle stalled. There was smoke coming from the tail pipe. There was an abnormal odor of coolant in the vehicle. The contact opened the hood and noticed that the engine oil was milky, and the coolant reservoir was empty. The engine overheated, and the message “Limited Power Due to Overheating” was displayed. The check engine warning light was illuminated. The contact researched the failure and indicated that the failure was due to the head gasket and engine. The vehicle was towed to the local dealer but was not diagnosed or repaired. The manufacturer was contacted and opened a case. The contact was referred to the dealer for assistance. The failure mileage was approximately 83,000.

Filed Nov 15, 2022 · Engine · 6,000 miles · VA

The contact owns a 2017 Ford Mustang. The contact stated while driving approximately 10 MPH, he detected smoke coming from the vehicle. The contact noticed that oil was leaking from the headers. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the valve cover gasket was leaking. The vehicle was not repaired due to parts being backordered. The manufacturer was not contacted. The failure mileage was approximately 6,000.

Filed Jul 5, 2022 · Airbags · 57,000 miles · TX · crash · fire · 2 injuries

The contact owns a 2017 Ford Mustang. The contact stated while driving approximately 20 MPH and making a left turn the contact crashed into a vehicle going straight through the intersection. The contact's entire front end crashed into the other vehicle's driver-side front fender by the driver's front wheel. The contact's vehicle spun 180 degrees and the air bags deployed, however, the bags ignited and set the contact's clothes on fire. The vehicle stopped in the roadway. The contact exited and the police arrived on the scene and filed a report. The contact was offered medical attention but instead was taken to the ER by her mother. The contact suffered second-degree burns on her left forearm and elbow, additional burns left side of the abdomen and both shins, also a large cut on her left shin. The contact's only passenger had bruises on his right hip, and no burns or lacerations. The passenger refused medical attention on scene and also did not follow up for medical attention. The vehicle was taken to an impound lot. The vehicle had not been diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 57,000.

Filed May 27, 2021 · NC · crash · fire

2017 ecoboost mustang , 31k miles, 17 yr old daughter pulls out of neighborhood going to high school! 1/4 of a mile (4 houses) down she hears a loud boom then car bursts into flames under the hood near firewall or windshield wiper arms. Cause is coolant leaking into the cylinders, which in turn caused the misfires, and engine to catch on fire. Ford has been aware of this issue since 2016.

Filed Jun 15, 2020 · Transmission · 35,250 miles · IL

Clutch failed in 3rd gear while traveling down a four lane street. Car stalled in traffic and would not restart. Almost caused an accident with driver following vehicle due to sudden stall. Car would not restart due to being stuck in gear. Recently received service at two ford dealerships. Notified dealers of strong burning smell coming from car and noise being made by transmission in 2nd and 3rd gear. Was informed that the problem was remedied. Two days later, car stalled in traffic and clutch pedal fell to the floor and stuck there.

Filed Aug 2, 2019 · Engine · 19,400 miles · TX · fire

2017 ford mustang gt premium with less than 20k miles while driving stalled and engine caught fire. No prior warnings, smells or leaks on the garage floor. I have the fire report and all other documents but couldn't get them to upload.