2019 Ford Mustang: engine failure

Filed Oct 21, 2026 · Engine · NJ

My 2019 ford mustang egoboost with only 59,000 miles has a cylinder three coolant intrusion. This is disappointing, as the only right way to fix this according to Ford, is to replace the whole engine. Nobody should expect to have to fix their entire engine. Now on cold starts coolant is leaking in to cylinder three, which is causing misfires and could potentially lead to a safety, risk. Ironically, there’s a lawsuit currently in place for this exact problem. This is a problem, sudden engine failure or stalling due to severe coolant intrusion introduces a dangerous loss of power while operating the vehicle at speed and could lead to a blown or locked up motor. Ford has kept this under wraps since the release of this generation of vehicle.

Filed Oct 13, 2026 · Engine · OK

Known engine coolant intrusion problem with the Ford EcoBoost engine. It misfires and was confirmed by a service center that a whole new engine was needed. Car shaking and rumbling-- gas smell. Afraid of it catching fire.

Filed Aug 18, 2026 · Engine, Transmission · TX

My 2019 Ford Mustang equipped with the 2.3L EcoBoost engine developed a check-engine light, rough startups, engine misfires/rough running, and some engine knocking. The vehicle had approximately 87,453 miles. I took the vehicle to an authorized Ford dealership for diagnosis. The dealer brought the engine to operating temperature, pressurized the cooling system to 21 PSI, removed the ignition coils and spark plugs, and inspected the cylinders with a borescope. The dealer documented coolant intrusion into cylinder #2 due to a failed cylinder head and recommended replacement of the complete long-block engine due to the extent of the damage. The dealer also documented diagnostic trouble codes P0300 and P0316 for misfires, along with P008A and P018C related to low-side fuel pressure. I am concerned that internal coolant intrusion causing misfires, rough operation and engine knocking could result in significant loss of engine power or engine failure while driving, creating a safety hazard, particularly at highway speeds or in traffic. Ford Customer Relations was notified but declined financial assistance because the vehicle is outside the factory warranty and stated that there is no applicable recall for my vehicle. The vehicle has not been repaired and is available for inspection. The Ford dealership's written diagnostic report and photographs of the cylinder inspection are available.

Filed Aug 11, 2026 · Engine · GA

2019 Ford Mustang with 3.2 EcoBoost engine has coolant intrusion into the engine thru a defectively made engine block. Diagnosed by the Ford dealer in Hinesville,GA on August 11,2026. Car has 52,731 miles on it and has always been maintained by the local Ford service department. Car is a daily driver, no abuse or rough driving. Car is available for inspection upon request Coolant intrusion can cause sudden engine failure, loss of power and sudden stoppage at any speed. Overheating due to loss of coolant, engine fire, loss of control of the car. Check engine light came on and engine ran rough on cold start up on [XXX] & i then took it in to be checked out by Ford service. Service advisor stated that this coolant intrusion is due to a Ford known defect in the EcoBoost engines; but that there has been no recall. Only solution he offered was to have a new replacement engine installed for about $13,500. I declined the replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 18, 2026 · Engine · FL

Engine Failure where a replacement engine is required just after a few months of purchasing the vehicle.

Filed Jun 17, 2026 · Engine · TX

Coolant intrusion. This particular motor has caused NUMEROUS issues with 2019 & older Ford models, specifically with the 2.3L Ecoboost engines. The Ford Motor Company should recall & replace the engines of all models affected, mine included. I spent $2200 for a new timing system, tow fees, was broke down on the side of the road when my engine overheated. I bought this car brand new. Financed $27k & owe $3900 right now. Devastated & livid describes how I feel at the present. Coolant intrusion causing hydrolock is a KNOWN issue by Ford, and they should make things right with the owners of the vehicles affected. A new motor will cost $6500. That should NOT be a cost that the customer has to pay.

Filed Apr 7, 2026 · Engine · WA

Description of the Defect: My 2019 Ford Mustang EcoBoost experienced a premature engine failure caused by internal coolant intrusion, resulting in the need for complete engine replacement. This failure is not related to routine maintenance or a head gasket issue, but rather a known internal engine design defect that allows coolant to intrude into the cylinders over time. The vehicle exhibited symptoms including coolant loss without visible external leaks, rough operation, and engine malfunction. Upon inspection by a Ford dealership, the failure was diagnosed as coolant intrusion into the engine, with the only repair option being long‑block (engine) replacement. Ford has acknowledged this failure mode in Technical Service Bulletin (TSB) 19‑2346, which documents coolant intrusion in EcoBoost engines and states that engine replacement—not head gasket repair—is the required corrective action. This bulletin confirms the issue is caused by an internal design flaw that develops over time. Why This Is a Safety Concern: This defect can lead to sudden engine misfires, loss of power, or complete engine failure while driving, which poses a serious safety risk to vehicle occupants and other road users. Engine failure at highway speeds or during normal driving conditions creates the potential for crashes, loss of vehicle control, or roadside breakdowns in unsafe conditions. The failure occurred at very low mileage (~36,000 miles), indicating a premature and abnormal engine defect, not normal wear and tear. Yes, it is available for inspection upon request. Yes, it is diagnostic and confirmed by AutoNation Ford Bellevue [XXX] Direct line: [XXX] No, prior warning and symptoms. First appeared on March 16, 2026. No recall exists despite Ford’s TSBs acknowledging the defect. Ford later redesigned the EcoBoost engine, showing awareness of the issue, yet owners are forced to pay for costly engine replacements after warranty expiration. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 2, 2025 · Engine · FL

Have a 2019 Ford Mustang 2DR 2.3L Ecoboost with 59,500 miles which I took to the dealership with a code P0302 and P0304 present, cylinder misfire, observed coolant level low, performed borescope in cylinder 2 and 4, found coolant intrusion, recommend long block engine replacement which would have cost me $10,728.85. Concern is that the engine can stall suddenly and may cause an accident. Ford Motor Company knows about these kind of engine issues with Ecoboost engines and have not offer any reasonable solutions. Vehicle VIN is the following: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Nov 29, 2025 · Engine · MS

Ford's 2.3L EcoBoost engine defect that causes coolant to leak into the cylinders, leading to engine failures and potential fire risks.

Filed Sep 16, 2025 · Engine · MA

Engine - Blown head gasket This is a common issue with these engines and is a costly repair or potential engine failure.

Filed Aug 28, 2025 · Engine · PA

Check engine light on. Code is p0301 for multiple cylinder misfires. At startup I can hear coolant sloshing around and white exhaust. Coolant is leaking into cylinder 1. The Ford dealer says it needs a new engine. 2019 ford mustang ecoboost at 55k miles.

Filed Aug 28, 2025 · Engine · FL

Coolant intrusion into cylinder 2 at 26,000 miles. Was told by mechanic this is due to thin cylinder wall design between cylinder 2 and 3. And the thin coolant channel cut between them. A new engine block manufactured after 2020 was recommended because the engine design was changed to fix this issue. My warranty expired 4 months prior so I had to fix myself.