2020 Ford Transit electrical problems

Filed Nov 4, 2026 · Electrical · 256,000 miles · MN

Odometer Fraud. The contact purchased a 2020 Ford Transit. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 82,000 and at the time of maintenance, it was discovered that the mileage was 256,000.

Filed Jul 29, 2026 · Electrical · 168,000 miles · NJ

Odometer Fraud. The contact purchased a 2020 Ford Transit. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 69,000, which was confirmed by a fraudulent Carfax report the seller provided to the contact. However, upon searching the VIN on a Ford mobile app, it was discovered that the mileage was 168,000.

Filed Dec 12, 2024 · Airbags, Electrical · 68,000 miles · CT

The contact owns a 2020 Ford Transit. The contact stated that the AWD and air bag warning lights were illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the actuator and sensor needed to be replaced, and a software update needed to be performed. The vehicle was repaired, but the failure recurred. The dealer determined that the transfer switch, new air bag, and seat repair kit were needed. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 68,000.

Filed Dec 4, 2024 · Electrical · TN

The van will not start on a regular basis. Usually within a week the battery voltage has depleted to the point the van will not start. Have to put a charger on it often. This is a commonly reported problem on many forums.

Filed Nov 20, 2024 · Electrical · CA

My Balmar 2nd alternator on my Winnebago Ekko has just failed. This is a Winnebago installed electrical system component mounted in the Ford Transit chassis engine bay that provides electrical charging to the RV coach batteries. There was an initial the federal safety agency Safety Recall 23V‑234 issued in 2023 after numerous Balmar units failed; in some cases the Balmar unit failure caused a fire in the engine bay. I had the Safety Recall work performed in July 2023 by authorized dealer Dennis Dillion RV in Boise Idaho per the attached invoice and the Balmar charging system had been working well until now. I am aware that there are ongoing reports by other Ekko owners of the Balmar alternator failures reoccurring after the Safety Recall work was performed, and in some cases even after Balmar 2nd alternators' were replaced, which suggests the initial solution provided by the Safety Recall was not sufficient to prevent a failure. Within minutes of starting to drive my RV today I noticed an unfamiliar whining sound from somewhere under the hood that I had not heard before and immediately checked my coach batteries while driving a short distance and went from the batteries discharging significantly to not charging at all. I opened the engine hood and had smoke visible and a strong burning smell coming from the passenger side of the engine bay where the Balmar unit is located. I was very concerned about the potential for an engine bay fire, but fortunately was very close to my home, so my RV is now parked in my driveway. See attached screenshots showing the initial voltage discharge while driving and then the batteries not getting any charge while under power. Also attached is the Recall 23V‑234 repair instructions. I plan to unplug the Balmar alternator to prevent the potential for a fire while awaiting a response from Winnebago how to proceed. Despite the federal safety agency Safety Recall having been performed, there are reports of alternator's failing and risk of vehicle fires remains.

Filed Oct 7, 2024 · Electrical, Steering · MD

In march 2024 my vehicle unexpectedly cutoff on [XXX] heading into wash. Dc. Called a tow to my mechanic and had the alternator and battery replaced. Mechanic noticed that the vehicles battery light remained and investigated further. After amonth in the shop we observed that components were utilizing battery power when the system should be off. We heard mechanical diagnostic sounds, and the battery would not maintain a charge after being driven. Upon getting it home and a day later upon jump starting again and when i began to turn the wheel, a violent jerking response came from the steering column. Cheched the dash and several popup windows had to be closed. AWD, BATTERY, and low fuel. There was also the wrench light on the dash itself. Went on the Ford forum and many others were describing the same issues, mainly battery drain. I thought i had disconnected the cargo area lights only to find out i did disconnect part but not them all only to further discover Ford engineered the vehicle where most of the features that were described in the forum not so accessible such as the fuse panel 'fuse 32' because theres no clear indication of where that is exactly on the diagrams. Ive have pretty much used the vehicle on occasions where im moving my equipment. As of september, i received a letter from fords "Customer Satisfaction Program" in which i responded only to be told from Bannister Ford that the Software Update that would fix High-Torque launches would not be installed because the battery light was on. Now to me, this sounds like a catch-22 because the issue is with their electrical design where if one problem occurs they have a fix but you wont get it until you fix the prom (ideally with them). all the while I'm setting up the appointment im being served ads for add-on services. Its october 2024 and i am just sick of this van. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 1, 2024 · Electrical, Lights · CA

The Vehicle head light comes on while the vehicle head light switch is at off position and when you hit the remote on off button the light turns off. And later comes back on again . And at night driving the light goes off and on some time .it just black out on road can we get advise if this is recall issue since we seen many customers having complaints about the same issue on website and also on ford forums

Filed Jun 1, 2023 · Electrical, Engine · TX · fire

THIS IS A SECOND CASE FOR A DIFFERENT VIN WITH THE SAME ISSUE. 11524889. The battery's junction box in the engine compartment is melting. While I was driving, I heard a loud pop, I opened the hood, and saw smoke coming from the junction box. I noticed the box was melting around a fuse. The melting is significant, and the vehicle looked to be on fire. The smoke stopped, but I feel the vehicle could easily have caught on fire completely. There are recalls for this same exact issue but for other Ford Models. I have a fleet of these vans, and this has now occurred to 6 of them. I know other owners that this occurred to as well. I have called Ford Goodwill and they have declined to cover it under the 3-year, extended warranty. The melting was so bad on one that the actual harness was burnt as well. This is a dangerous issue that Ford already knows this happens. I have receipts for all of these repairs and the technician acknowledging the junction box melting. I have emails from Ford where they apologize for the issue, and they say they cannot cover it under warranty. They refuse to comment on the safety danger this poses on all. This is an amazon delivery van and there are thousands of these that could catch fire in someone's house or business.

Filed Jun 1, 2023 · Electrical · TX · fire

The battery's junction box in the engine compartment is melting. While I was driving, I heard a loud pop, I opened the hood, and saw smoke coming from the junction box. I noticed the box was melting around a fuse. The melting is significant, and the vehicle looked to be on fire. The smoke stopped, but I feel the vehicle could easily have caught on fire completely. There are recalls for this same exact issue but for other Ford Models. I have a fleet of these vans, and this has now occurred to 6 of them. I know other owners that this occurred to as well. I have called Ford Goodwill and they have declined to cover it under the 3-year, extended warranty. The melting was so bad on one that the actual harness was burnt as well. This is a dangerous issue that Ford already knows this happens. I have receipts for all of these repairs and the technician acknowledging the junction box melting. I have emails from Ford where they apologize for the issue, and they say they cannot cover it under warranty. They refuse to comment on the safety danger this poses on all. This is an amazon delivery van and there are thousands of these that could catch fire in someone's house or business.

Filed Feb 27, 2023 · Driver assistance, Electrical · CA

Rear camera (back up camera) will stop working. Also, rear (right-side) and side sliding door "door open alert" false indicates, beeps horn while driving but is sporadic.