Tl* the contact owns a 2004 four winds hurricane motor home. The motor home shakes violently at any speed when it hits a bump on the road. The dealer balanced the tires and aligned the front end; however the failure was not corrected. He contacted ford. Ford told him to take the vehicle to the weight station to make sure the weight was balance correctly. He contacted four winds and they told him it was not their problem. The failure mileage was 20,411 and the current mileage was 30,000. The motor home was not repaired. Updated 12/09/09 *bf the consumer stated whitle driving on a rough road, the rv will somtiems shake violently and the only way to stop it, is to come to a complete stop.
The worst 2004 Four Winds Hurricane problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Fuel system1
- Seat belts1
- Steering1
- Suspension1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Fuel system1
- Seat belts1
- Steering1
- Suspension1
Recalls 6
Service brakes, hydraulic
- What is wrong
- Four winds is recalling 684 my 2002-2006 infinity, my 2002-2007 windesport, my 2004-2008 hurricane, my 2006-2007 megallan and my 2008 fun mover motor homes equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver.
- Risk
- The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
- Remedy
- Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy for this campaign please see 09v‑110. Workhorse will conduct the owner and dealer notification. Owners may contact workhorse at 1‑877‑246‑7731.
Recall number 09V204000 · Recall details
Engine and engine cooling
- What is wrong
- On certain motor homes built on workhorse chassis and equipped with gm 8.1l v8 engines, improper hardening during the heat treatment process can cause the fuel rail pulse damper retainer clip to fracture, resulting in inadequate retention of the damper. If the damper becomes loose, fuel could be pumped by the fuel pump into the under hood area.
- Risk
- In the presence of an ignition source, a fire could result.
- Remedy
- Chevrolet and workhorse are handling the owner notification and remedy for this campaign (please see 06v225 and 06v289). Dealers will replace the fuel rail pulse damper retainer clips on these engines free of charge. Owners may contact chevrolet at 1‑800‑630‑2438, workhorse at 877‑294‑6773 or thor industries at 937‑596‑6849.
Recall number 06V351000 · Recall details
Electrical system
- What is wrong
- Certain motor homes built on workhorse chassis and equipped with actia corporate instrument clusters fail to comply with the requirements of federal motor vehicle safety standard nos. 101 "controls and displays" and 105 "hydraulic and electric brake systems." if the brake fail input falls below a voltage of 1.5v, the brake failure lamp and alarm will be activated. Also activation of the ABS telltale when the ABS is not properly functioning does not always occur.
- Risk
- At night the instrument cluster lights may fail and the driver may not be able to see the instrument panel gauges and the brake warning light indicator which could increasing the risk of a crash.
- Remedy
- Workhorse is conducting the owner notification and remedy for this campaign and reprogram the instrument panel cluster free of charge. Owners may contact workhorse at 1‑877‑246‑7731 or four winds at 574‑266‑1111.
Recall number 06V093000 · Recall details
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
- What is wrong
- On certain motor homes, the fuel lines on the chassis could chafe against the steel floor structure, causing the fuel line to rupture.
- Risk
- Fuel leakage, in the presence of an ignition source, could result in a fire.
- Remedy
- Dealers will inspect the braided fuel supply line to determine if the fuel line has become excessively worn or chaffed. If there is no visible damage to the fuel line, the dealer will secure the fuel line to the main wiring loom. If damage is discovered, the fuel line will be replaced and properly anchored. The recall began july 16, 2004. Owners should contact four winds at
Recall number 04V249000 · Recall details
Seats
- What is wrong
- On certain class a motorhomes equipped with three-point shoulder harness seat belts, the seat pedestal brace was improperly installed or could be missing. Also, the brace could have been installed without utilizing four tec bolts to hold the brace in place.
- Risk
- This could result in the seat belt harness malfunctioning in the event of a crash, which could increase the risk of personal injury or death to the driver or passenger seat occupants.
- Remedy
- Dealers will either add a seat pedestal brace if brace is not present or install necessary hardware or tec bolts to hold the brace in place. The recall began march 31, 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact four winds at 574‑266‑1111.
Recall number 04V127000 · Recall details
Service brakes, hydraulic: brake fluid low warning: lamp
- What is wrong
- Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, "hydraulic and electric brake systems." the brake system warning indicator may not function as required by standard.
- Risk
- In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the brake system warning indicator.
- Remedy
- Dealers will repair the brake warning lamp circuit. Owner notification began may 13, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact four winds at 1‑219‑266‑1111.
Recall number 03V069000 · Recall details
What 2004 Four Winds Hurricane owners say
Most recent owner complaints, unedited.
I received a defect service bulletin which states that 2004 four winds, hurricane motorhomes are equipped with a 3 point shoulder harness seat belts and may have a defect. I had the coach in on july 18, 2006 at mcmahon's rv in colton, ca, picked it up on aug 2, 2006, when I was there picking up the coach I was told the replacement belts came in too late to be installed, I ask them if I could take the belts and have them installed by another rv dealer closer to me, was told no, the coach in for repairs again and ask them if they could order the belts and get them installed, they told me it was a campaign and it was expired, there is no expiration date on my notices. Don't understand why I cannot have these belts replaced while it is in having repairs done. The coach is at mcmahon's in irvine. Please respond as soon as possible, my mh is almost done and ready for me to pick it up.
Consumer complaint concerning 2004 four winds class a hurricane recall on braided fuel supply line. *ts the consumer received recall 04v249000 on the braided fuel supply line. A repair facility repaired the recalled part. After the part was replaced the vehicle caught on fire.
Compare the 2004 Four Winds Hurricane
Other model years
199719992000200120022003200420052006200720082009201020112012
Questions about the 2004 Four Winds Hurricane
Is the 2004 Four Winds Hurricane reliable?
Owners have filed 3 complaints about the 2004 Four Winds Hurricane, 1.5 times a typical Hurricane model year.
What is the most common problem with the 2004 Four Winds Hurricane?
Fuel and propulsion system, with 1 complaint. Next is seat belts (1).
How many recalls does the 2004 Four Winds Hurricane have?
6 recalls, covering service brakes, hydraulic, engine and engine cooling and electrical system.
Was there a recall on the 2004 Four Winds Hurricane fuel system?
Yes, 1 recall: 04V249000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Four Winds Hurricane?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history