2000 Freightliner Columbia problems

What is wrong

On certain truck tractors equipped with jost international jsk 37u series fifth wheels, a fatigue crack can develop in the bracket pin weld under certain loading conditions.

Risk

If left undetected or corrected it could lead to the separation of the fifth wheel top plate from its mounting structure, possibly resulting in a crash.

Remedy

Dealers will replace the bracket pins and repair instructions free of charge. Owner notification began november 12, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jost international at 616‑846‑7700 or by email to [email protected] or freightliner at 1‑800‑547‑0712.

Recall number 03V227000 · Recall details

What is wrong

On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.

Risk

Seizure of the bearings can cause wheel separation or wheel end fire.

Remedy

Dealers will replace both front hubs. Owner notification is expected to begin on or before september 20, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1‑800‑547‑0712.

Recall number 03V112000 · Recall details

What is wrong

Vehicle description: heavy duty trucks and school bus chassis built with bendix air ABS with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.

Risk

This condition could cause the ABS ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.

Remedy

Dealers will replace the ABS ecu.

Recall number 00V232002 · Recall details

Certain 1998-2001 freightliner century and columbia vehicles exhibit a higher rate of front brake air hose leaks than earlier vintage freightliner vehicles.the leaks have been frequently discovered at fmcsa roadside inspections since these inspections are conducted with the brakes applied (pressurizing the air hose) whereas driver pre-trip inspections may not always be performed with the brakes applied. After a thorough technical review of this matter,odi has concuded that while the subject vehicles exhibit a higher rate of front brake air hose leaks than earlier vintage and peer vehicles, these leaks appear to be minor. Freightliner has extended the warranty for this component to 5 years, 500,000 miles and will assist in alerting those vehicle owners whose vehicles are most susceptible to front brake air hose leakage by issuing a service bulletin alerting those owners to the potential for front brake air hose leakage to occur. See attached report for full technical details.

PE03005

Freightliner submitted a defect report on march 21, 2003 in which they identified approximately 5000 trucks as possibly beingaffected by this problem.arvinmeritor (front axle mfr) submitted a defect report onapril 16, 2003, which identifies 6098 freightliner trucks asbeing affected by this recall and 1191 axles sold to freightliner in the aftermarket. Odi notes that there are twointegral hub and bearing assemblies per front axle.freightliner identified vehicles includingfreightliner,sterling, and western star brand name as beingaffected by this recall.see attached summary report for additional details.

PE02088